2021 Blue Bird All American School Bus
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Blue Bird › All American School Bus › 2021
These records cover every 2021 Blue Bird All American School Bus. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
18 recalls name the 2021 Blue Bird All American School Bus. Newest first.
Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and…
Risk and remedy
Risk
An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Remedy
Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).
Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor…
Risk and remedy
Risk
Roof panels that separate during a crash can increase the risk of injury.
Remedy
Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2024 Vision 2020-2023 All American school buses. The convertible seats may have been incorrectly installed, which can result in an unsecured seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk and remedy
Risk
An unsecured seat may not adequately restrain an occupant, increasing the risk of injury during a crash.
Remedy
Dealers will inspect and repair the seat, free of charge. Owner notification letters were mailed March 04, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24CM-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2014-2024 All American school buses equipped with 39" High Back seat restraining barriers. The bolts securing the restraining barriers to the floor may separate when fully loaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 222, "School…
Risk and remedy
Risk
An unsecured seat restraining barrier may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy
Dealers will install a longer bolt with rectangular washer and nut, free of charge. Owner notification letters are expected to be mailed January 16, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CU-SB. This recall is an expansion of recall number 23V-777.
Blue Bird Body Company (Blue Bird) is recalling certain 2021-2024 All American and 2021-2022 Vision school buses. A software error in the instrument cluster may cause the air pressure gauges and the visual and audio low air warnings to not function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard…
Risk and remedy
Risk
Air gauges and warnings that do not alert the driver to air pressure loss can result in driving without functioning brakes, increasing the risk of a crash.
Remedy
Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed July 27, 2023, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CH (School Bus).
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All American and Vision School Buses, equipped with PowerDrive 7000 electric drive systems. The System Control Module (SCM) may activate the anti-rollback feature, causing the vehicle to reverse faster than expected when the vehicle is in reverse and pointing downhill with the brake pedal…
Risk and remedy
Risk
A vehicle reversing faster than expected can increase the risk of a crash.
Remedy
Dealers will update the SCM software calibration, free of charge. Owner notification letters were mailed May 10, 2023. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CG (SB)
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.
Risk and remedy
Risk
An improperly grounded air compressor can cause electric shock, increasing the risk of injury.
Remedy
Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American buses. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
The remedy for this recall is still under development. Owner notification letters were mailed on July 30, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BH-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The drivetrain may experience an electromagnetic noise on the Control Area Network (CAN) bus, which may cause a loss of electrical power to the power steering pump.
Risk and remedy
Risk
A loss of assisted power steering increases the risk of a crash.
Remedy
Cummins will replace the High Voltage Low Power Inverter Harness, and install an overlay harness, free of charge. Interim owner notification letters were mailed on May 22, 2021. Owner notification letters were mailed on October 25, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American school buses. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air…
Risk and remedy
Risk
Unintended spring brake application may occur, increasing the risk of a crash.
Remedy
Dealers will replace the SC-3 check valves, free of charge. Owner notification letters were mailed on November 18, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BE-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The electric drive train cannot detect isolation faults when the high voltage contactors are closed.
Risk and remedy
Risk
An undetected high voltage isolation can expose service personnel to high voltage, increasing the risk of injury.
Remedy
Blue Bird will notify owners, and dealers will update the Vehicle Control Unit software or install a different combination of High Voltage Power Distribution Unit hardware, free of charge. The recall began on May 22, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BD-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2022 Vision and All American buses. The seats with integrated 3-point seat belts may have been installed incorrectly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Risk and remedy
Risk
An incorrectly installed seat can increase the risk of injury in the event of a crash.
Remedy
Blue Bird will notify owners, and dealers will inspect the seats and install any missing hardware, as necessary, free of charge. The recall is expected to begin April 9, 2021. Owner notification letters were mailed February 03, 2022. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BB-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2021 Vision and All American school buses. The nut that secures the steering wheel to the steering shaft may not have been properly tightened.
Risk and remedy
Risk
An improperly tightened steering wheel could detach, resulting in a loss of vehicle control, increasing the risk of a crash.
Remedy
Blue Bird will notify owners, and dealers will inspect and tighten the steering wheel nut, as necessary, free of charge. The recall began August 26, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AY-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All-American and 2019-2021 Vision school buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to…
Risk and remedy
Risk
In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants.
Remedy
Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. This recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2021 Vision and All American school buses equipped with factory-installed air conditioning (A/C) systems. The A/C circuit breaker may have been installed incorrectly.
Risk and remedy
Risk
Incorrect installation of the air conditioning circuit breaker may increase the risk of a fire.
Remedy
Blue Bird will notify owners, and dealers will inspect the installation of the A/C circuit breaker, correcting it as necessary. Any damaged circuit breakers will be replaced. These repairs will be performed free of charge. The recall began July 6, 2020. Owner letters were mailed on November 30, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AR-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2021 Vision and All American school buses. The foot pedal parking brake assembly may have been improperly assembled possibly resulting in a failure to hold the vehicle stationary on an incline when the vehicle is loaded to its maximum weight. As such, these vehicles fail to comply with the…
Risk and remedy
Risk
Unintended vehicle movement can increase the risk of a crash.
Remedy
Blue Bird will notify owners, and dealers will inspect the foot pedal parking brake assembly application force and adjust it as necessary, free of charge. The recall is expected to begin July 3, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AP-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2008-2021 Vision and All American school buses. The seat barrier behind the driver seat with an integrated 3-point seat belt may have been installed incorrectly and may be missing the reinforcing bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety…
Risk and remedy
Risk
In the event of a crash, the seat barrier may not adequately protect the occupant seated behind the seat barrier separating them from the driver seat with integrated 3-point seat belt, increasing the risk of injury.
Remedy
Blue Bird will notify owners, and dealers will inspect and properly install the seat barrier including adding reinforcing bracket, as necessary, free of charge. The recall is expected to begin April 23, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AM-SB.
Blue Bird Body Company (Blue Bird) is recalling certain 2019-2021 All American and Vision school buses. An insufficient number of rivets were installed in the roof sheets, allowing the roof sheets to separate in the event of a severe impact. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS)…
Risk and remedy
Risk
In the event of a crash, if the roof sheets separate, there is an increased risk of injury.
Remedy
Blue Bird will notify owners, and dealers will inspect the roof joints and add the sufficient number of rivets, as necessary, free of charge. The recall began October 22, 2019. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R19AH.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10220365SM2203: EV Recommended Starting Procedure This Service Memorandum is to announce the proper starting procedure to be followed for all Cummins EV powered units. The sequence is required due to multiple electronic modules required to wake up and start communicating over the CAN (Controller Area Network) on EV Power Train Product.
- 10220363SM2022 EV Maintenance and Service Documentation This Service Memorandum is to announce information on Cummins Power Electric buses now available at Quickserve Online. Dealer must have access to Quickserve to obtain these service maintenance and repair procedures.
- 10217921Cummins recently issued Temporary Repair Practice (TRP2484) for certain vehicles with DEF sensor failures in which DEF sensor replacement parts are not available. This provides a temporary ECM calibration that inhibits engine warning messages for communication errors with the DEF sensor allowing continued operation without engine derate. Regulators are allowing for this temporary calibration to be loaded in the engine ECM by a Cummins authorized repair location if the DEF sensor fails. This temporary calibration does not repair the failure therefore a final repair must be performed and the original calibration be re-installed. Field Service has been requesting an ECM image be uploaded within the support ticket as part of the diagnostics and is carried over into Service Update 2201 (SU2201). In order to receive an authorization code and utilize Cummins TRP2484, you must follow the process, as outlined in SU2201. The specific component affected is Assembly Code: 35-300 Emissions Components.
- 10201694Models Affected: 2010 thru 2021 All American Subject: This update provides information on the new surge tank fill necks for All American Instructions: There is a new kit available from Part Sales; 10066291 - Kit, Neck, Surge Tank. This kit is available for use with the All American & TX4 surge tanks. Remove and discard existing neck from tank Install new neck using items in Kit 10066291 Kit, Neck, Surge Tank
- 10201629The intent of Service Update SU2103 is to announce a new Shaw Development Technical Bulletin. The Technical Bulletin is intended to guide Shaw Development customers in troubleshooting fault codes related to the DEF tank assembly on Cummins engine equipment. This document is intended to be a living document, and the details and processes within can/will change as system designs evolve, or other new information comes to light. Access to this Shaw Development Technical Bulletin will be available on the Blue Bird Vantage website.
- 10164994Blue Bird has determined that the CIT brand air conditioning relays should be replaced with Song Chuan brand relays (PN 00079077). Additionally, the wiring harness (PN 10023917) connected to the relay base should be inspected for any sign of damage and replaced, if necessary. Blue Bird will provide parts at no cost and will reimburse the repair time in accordance with the information presented below. Affected Units: This service bulletin includes: Certain model year 2015-2021 Vision School Buses manufactured from August 5, 2014 through September 11, 2019. Certain model year 2016-2021 All American School Buses manufactured from May 8, 2015 through September 8, 2019. Certain model year 2016-2021 Vision Non-school Buses manufactured November 20, 2014 through August 10, 2019. Certain model year 2015-2020 All American Non-school Buses manufactured September 15, 2014 through September 7, 2019. A separate printout is included which lists all of your buses that are affected by this service bulletin
Every Blue Bird All American School Bus model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.