1995 Blue Bird TC2000
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Blue Bird › TC2000 › 1995
These records cover every 1995 Blue Bird TC2000. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
18 recalls name the 1995 Blue Bird TC2000. Newest first.
Certain school buses fail to comply with the requirements of federal motor vehicle safety standard no. 221, "school bus body joint strength." one or more of the bolts attaching the driver's platform to the floor structure was omitted.
Risk and remedy
Risk
The rear of the driver's platform may not be properly retained in the event of a crash which could increase the risk of injury or death to passengers.
Remedy
Blue bird will notify its customers and inspect and repair the affected units. owner notification began on november 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 478-822-2242.
Certain transit buses fail to comply with requirements of federal motor vehicle standard no. 101, "controls and displays." this standard requires specific labeling for "engine start" and "engine stop." the wording of the labels on these vehicles do not meet the requirements of the standard.
Risk and remedy
Risk
The operator could place the engine switch in a position other than that intended, increasing the risk of a crash.
Remedy
Owners will be provided with new decals and installation instructions. owner notification began august 29, 2002. owners who do not receive the free label and installation instructions within a reasonable time should contact blue bird at 1-478-822-2242.
Vehicle description: school buses. these buses fail to meet the 60 percent joint strength requirements of fmvss no. 221, "school bus body joint strength."
Risk and remedy
Risk
In the event of a vehicle crash, the roof may not be supported sufficiently, causing personal injury to bus occupants.
Remedy
Owners will be contacted and advised to inspect each roof joint. owners will install repair rivets in each joint found to have insufficient quantity of rivets in each examined 8 inch section.
Vehicle description: school buses. the wall side attaching bolts for some of the passenger seats may have been installed too close to the edge of the seat ledge and in the wrong attaching hole resulting in weakening of the seat ledge at the attachment points.
Risk and remedy
Risk
In the event of a frontal crash, the rear attaching bolt of these seats could pull out of the seat ledge increasing the risk of injury to the seat occupant.
Remedy
Blue bird will furnish to distributors and owners, parts and instructions necessary to strengthen the passenger seat attachment at the wall side.
Vehicle description: front and rear engine school buses equipped with 60 gallon side mounted fuel tank barriers. these buses do not comply with the requirements of fmvss no. 301, "fuel system integrity."
Risk and remedy
Risk
In the event of a vehicle crash, the fuel tank could be damaged, leaking fuel, possibly resulting in a vehicle fire.
Remedy
Blue bird will ship instructions and modification kits to the owners of these buses.
Interference between the hydraulic brake hoses or bleeder valves and the "reyco" air suspension components can occur causing failure of one of the hydraulic fittings.
Risk and remedy
Risk
Failure of the hydraulic fittings can cause a loss of brake fluid resulting in loss of brakes increasing the risk of a vehicle accident.
Vehicle description: school buses equipped with bostrom driver's seat model F222 or bostrum "routemaster" seat. blue bird option 2821 or 2824. the seat pedestals are fatigue cracking adjacent to the weld which secures the pedestal's upper plate to the upper, telescoping portion of the adjustable column support.
Risk and remedy
Risk
The upper mounting plate and seat upper gradually becomes loose resulting in the upper plate detaching from the supporting column and the seat can fall from its mounting. this can result in personal injury to the driver.
Remedy
Dealers will repair these pedestals with a newly designed pedestal bracket kit.
Passenger's clothing can unknowingly become caught in the forward handrails at bus doors when exiting the bus.
Risk and remedy
Risk
When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion, the individual IS subject to being dragged by the bus. This can result in serious injury or death.
Remedy
Owners will be directed to remove all forward handrails. Provisions will be made for those owners operating in states which mandate a forward handrail that a replacement handrail will be provided.
Air suspension torque arm can come in contact with the air brake chamber mounting bracket resulting in broken s-cam mounting bracket.
Risk and remedy
Risk
This can result in the loss of brake lining contacton the rear wheel increasing the potential for a vehicle accident.
Remedy
Dealers will modify vehicles to incorporate an axle seat spacer and replace the cam shaft and cam shaft bracket with a longer cam shaft and cam shaft bracket on both right and left rear brake assemblies to provide sufficient clearance.
The wrong circuit breaker was installed in the electrical panel which could cause an interruption of the 8-light warning system.
Risk and remedy
Risk
The 8-light warning system would stop functioning while discharging passengers increasing the risk of a vehicle accident or an exiting passenger being struck by an oncoming vehicle.
Remedy
Owners will be notified to check and replace as necessary the circuit breakers. Owners can also have these circuit breakers checked and replaced at an authorized dealer.
These buses are equipped with an entrance door handrail off set brace attached to the interior wall and the handrail. The attachment point at the wall IS incorrectly positioned permitting the entrapment of the "connecticut nut/string test device" between the upper edge of the brace and the lower edge of the seat ledge. Passenger's clothing could unknowingly…
Risk and remedy
Risk
When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion, the individual IS subject to being dragged by the bus. This can result in serious injury or death.
Remedy
Dealers will inspect and relocate the bracket as necessary. Owners can inspect and relocate the bracket IS so desired.
These vehicles could have a latch which scrapes an aluminum trim piece increasing the force required to open. This does not comply with fmvss no. 217, "bus window retention and release."
Risk and remedy
Risk
Consequence of non-compliance: in the case of an emergency, an occupant may not be able to open the window to use as an emergency exit.
Remedy
Dealers will install a new cam lock plate.
An improper mix of adhesive was applied to the interior side panel joints resulting in the buses failing to conform to the joint strength requirements of federal motor vehicle safety standard no. 221, "school bus body joint strength.":
Risk and remedy
Risk
Consequence of non-compliance: in the event of a collision, the side panel of the bus may not protect the occupants at the level required fmvss no. 221
Remedy
Dealers will inspect and repair with correct adhesive if the sealer was not cured properly.
The floor line handrail bracket can expand during use and create an opening which could entrap coat strings, etc. And other articles of clothing.
Risk and remedy
Risk
When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion,the individual could be dragged by the bus. This can result in serious injury or death.
Remedy
Dealers will replace the flat split floor line bracket with a round tubular bracket.
These units are equipped with a counter weight assembly made up of 300 pounds of 1/4" plate steel welded together and bolted between the frame rails in the rear overhang just forward of the rear bumper. Some of the welds have broken due to insufficient welds, corrosion, or ice expansion.
Risk and remedy
Risk
These plates can drop to the roadway becoming a hazard to following vehicles increasing the potential for an accident.
Remedy
Dealers will install a mechanical retaining device which clamps the plates together and fastened with threaded fasteners. Bus owners will have the option of repairing their own vehicles.
Passengers clothing can unknowingly become caught in the handrails at bus doors when exiting the bus.
Risk and remedy
Risk
When a passenger's clothing becomes caught in the handrail, and the bus driver closes the door and puts the vehicle in motion,the individual IS subject to being dragged by the bus. This can result inserious injury or death.
Remedy
Dealers will install a set screw to the metal clamp which retains the intermediate handrail. A high impact molded plastic "clam shell" will be placed over each end of the intermediate handrail completely covering the clamp and eliminating all catch-points. the flange of the existing floor line bracket will be crimped securing the vertical section of the primary tublar handrail at the floor line.
The aisle side styrofoam knee pads on the subject barriers are 11" wide and not 14.5" as required by fmvss no. 222, "school bus passenger seating and crash protection."
Risk and remedy
Risk
Consequence of non-compliance: this condition could increase the potential for injury in a vehicle accident.
Remedy
Dealers will replace the incorrect pad with the correct 14.5" knee pad.
Quench cracks occurred in the pitman arm pinch bolt during the bolt manufacturing process, causing a weakness in these bolts.
Risk and remedy
Risk
These cracks can cause the bolts to fracture resulting in a loss of steering control and increasing the potential for a vehicle crash.
Remedy
Blue bird will provide replacement bolts for all affected units.
Owner complaints
7 complaints1 involved a fire
What owners report most
Latest complaints
- Suspension › Rear › Springs › Air suspension system
Rear air suspension upper shaft bracket which IS riveted to the frame IS cracking and tearing from the frame. common problem. have also 5 other buses with this problem. please provide further information. *Ak
- Equipment adaptive/mobility
The bus had been shut off and parked for approximately 1 hour when the wheel chair lift caught fire and burned(ricon model s5005 serial #48330).
- Vehicle speed control › Cables
Accelerator cable broke.
- Vehicle speed control › Accelerator pedal
Consumer was driving and applied force to the accelerator pedal, the plastic retainner plate broke, causing the vehicle to decelerate, part #bbb1091503. *ak
- Vehicle speed control › Cables
Accelerator cable pulls through pedal. tt
- Vehicle speed control › Cables
Accelerator cable pulls through pedal. tt
- Vehicle speed control › Cables
Accelerator cable pulls through pedal. tt
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10128588Blue Bird Troubleshooting Guides: Blue Bird announcement of the addition of troubleshooting guides for assisting in the service of the Blue Bird products. These troubleshooting guides are available on the Vantage website.
- 600077Vehicle experiencing turbo pipe breaking at top flange.
Every Blue Bird TC2000 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.