2008 BMW F 650 GS
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › BMW › F 650 GS › 2008
These records cover every 2008 BMW F 650 GS. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2008 BMW F 650 GS. Newest first.
BMW of North America, LLC (BMW) is recalling certain 2013-2017 F800R and F800GT motorcycles, 2014-2018 R1200GS and R1200GS Adventure motorcycles, 2016-2017 S1000XR motorcycles and 2015-2017 R1200R and R1200RS, 2008-2012 F650GS, 2008-2018 F800GS, and 2014-2017 F800GS Adventure motorcycles. When equipped with the optional aluminum luggage cases, the rear…
Risk and remedy
Risk
If the rear reflex reflectors are obscured from view, it can increase the risk of a crash.
Remedy
BMW will notify owners, and dealers will install reflectors on the cases or for the case mounts, an additional bracket with rear reflex reflectors, free of charge. The recall began October 16, 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW IS recalling certain 2008 through 2010 f 650 GS motorcycles manufactured from january 11, 2008, through december 8, 2009. a washer may interfere with the front disc brake fasteners' torque. as a result, over time, a fastener or mutiple fasteners could become loose, allowing the brake disc to become loose.
Risk and remedy
Risk
A loose brake disc may interfere with proper braking performance and may increase the risk of a crash.
Remedy
BMW will notify owners and dealers will repair the vehicles free of charge. the safety recall began on january 13, 2011. owners may contact BMW at 1-800-525-7417.
BMW IS recalling certain model year 2008 and 2009 F650 GS and f 800 GS motorcycles manufactured from september 27, 2007 through march 30, 2009. the drive chains may not have been produced to specification. as a result, over time the drive chain could break.
Risk and remedy
Risk
If the broken chain becomes trapped between the rear wheel and the frame, the rear wheel could lock up, possibly resulting in a crash.
Remedy
BMW will notify owners and dealers will replace the drive chain and sprockets on the affected motorcycles free of charge. the safety recall began on august 30, 2010. owners may contact BMW at 1-800-525-7417.
BMW IS recalling certain model year 2008 through 2010 F650 GS and F800 GS motorcycles manufactured between january 2008 and december 2009. during engine operation, a vacuum IS created in order to draw fresh air into the canister. this air then mixes with the fuel vapors captured by the canister, and IS subsequently combusted. Due to the routing of the…
Risk and remedy
Risk
Water could flow into the canister causing a stalling condition increasing the risk of a crash.
Remedy
Dealers will inspect and add an additional hose and route it such that the present defect IS prevented. this remedy will be performed free of charge. the safety recall began on may 13, 2010. owners may contact BMW at 1-800-831-1117.
BMW IS recalling 509 my 2008 F650 GS and F800 GS motorcycles. the tightening of the chain sprocket fasteners may have resulted in various levels of torque being applied.
Risk and remedy
Risk
It IS possible for the fasteners to work loose from the sprocket, increasing the risk of a crash.
Remedy
Dealers will loosen and inspect the chain sprocket fasteners. those that have been damaged will be replaced. in all cases, the fasteners will be retightened. the recall IS expected to begin during january 2009. owners may contact BMW at 1-800-831-1117.
BMW IS recalling 373 my 2008 F650 GS motorcycles. due to production and assembly tolerances, the length of one or more of the front brake disc fasteners may be insufficient. if the length of a fastener was insufficient, this could result in the fastener not being tightened according to specifications.
Risk and remedy
Risk
If this happened, the fastener could work loose from its threads. in some cases involving multiple fasteners, the brake disc could loosen, increasing the risk of a crash.
Remedy
Dealers will remove the brake disc fasteners and replace them with new longer fasteners. the recall IS expected to begin during january 2009. owners may contact BMW at 1-800-831-1117.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10249027The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.
- 10211897The motorcycle will not start. The vehicle battery is empty even though the battery charger was permanently connected to the 12V power socket.
- 10205109Stress corrosion cracks may occur on the studs of certain milled footrests from the BMW Motorrad special accessories catalog for the GS models.
- 10201169Vehicle battery not charged despite the battery charger being connected to the on-board socket (manufactured before 2009)Headlights and rear lights light up intermittently despite the ignition being switched off and the battery charger being connected to the on-board socket.
- 10200262The wiring harness of the F 650 GS and F 650 GS Dakar (R13) models is routed along the right-hand top rail of the frame. Weld spatter on the frame and/or adverse routing in the vicinity of the banjo bolt of the hydraulic spring base adjuster can result in the chafing of the wiring harness.
- 10200257The clutch plates do not tolerate frequent and prolonged operation at the clutch friction zone, causing a shorter service life in motorcycles that see intensive use
- 10193504Leaks have been reported in fork legs. The cause is reported be from oil lubricating film with accompanying dirt/grease ring is incorrectly interpreted to be a leaking fork leg. Investigations have shown that the part is not defective.
- 10182619Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.
- 10149510Oil leaking from around the oil sump gasket.
- 10147995Gear lever does not return to neutral position. Uneven faces on shifting pawl.
- 10147915Occasionally it's not possible to downshift the transmission; especially from 3rd to 2nd gear.
- 10147911Transmission rattles when the engine is at operating temperature and idling.
- 10038217BMW: crankcase pressure diagnosis and information for all vehicles. Updated on 4/24/2013.
- 10037025BMW: procedure for determining and replacing incandescent and halogen light bulbs under warranty.
- 10033130BMW vehicles: fuel level sensor repairs. Where it IS necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as well. In some cases, epc does not show that the repair kit IS available separately in the illustration, but it IS available in the parts description. All models. No model years listed.
- 10030825BMW motorcycle: engine fuels containing ethanol. BMW motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. Ethanol mixtures in proportions higher than 10% can have an adverse effect on performance and can result in damage to components that come into contract with fuel. No warranty claims whatsoever for damage caused in this way will be accepted. No model years listed.
- 10030770BMW motorcycle: update of bms kp software to cip 12.0 or greater status. Noticed that some f650/f800 GS (K72) motorcycles could display a tendency to stall when coasting or when the clutch IS disengaged. No model years listed.
- 10029624BMW motorcycle: the coolant inlet hose IS not compliant with the applicable BMW specifications. Engine operation can cause the inlet hose to widen and become correspondingly shorter; overtime this contraction in length can cause the hose to work back off the water pump nozzle for enough to allow coolant to escape. No model years listed.
- 10029188BMW mc: wiring harness of motorcycles IS routed along right hand top rail of frame. Weld spatter on frame and/or adverse routing in vicinity of banjo bolt of hydraulic spring base adjuster can result in chafing of the wiring harness. Model years unknown.
- 10028386BMW vehicles: routing ABS front wheel speed sensor cable. The wiring harness front wheel speed sensor periphery plug connection IS mounted on the fork cover at the bottom.
- 10026845BMW motorcycle: replacement of fuel-pressure sensor. Check of position of protective film (F-800 GS only).
Every BMW F 650 GS model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.