2025 BMW I4 XDRIVE40
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › BMW › I4 XDRIVE40 › 2025
These records cover every 2025 BMW I4 XDRIVE40. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Owner complaints
6 complaints
What owners report most
Latest complaints
- Electrical system
Charging interrupted-failed. Unable to fully use EV. Dealer confirms issue & has EV for two weeks, BMW USA has been notified, no remedy offered.
- Electrical system · Engine
Entire car was bricked after a software update (03/2026.54). Even the gear could not be changed to neutral for placing on a tow truck. Nothing wrong with the batteries. After more than 12 hours, finally the engine powered on but the software failure notification sign would still not work, and car had to be towed to authorized service center for a clean software reinstall.
- Visibility/wiper
I was driving last night on the highway in a monster rainstorm in Long Island, NY. In a full monsoon the wipers stopped working stuck in the up position. I was fortunate to not get in a very serious accident as I was going 50mph with ZERO visibility. I was able to make it to the side of the road…
I was driving last night on the highway in a monster rainstorm in Long Island, NY. In a full monsoon the wipers stopped working stuck in the up position. I was fortunate to not get in a very serious accident as I was going 50mph with ZERO visibility. I was able to make it to the side of the road where i drove with my hazards to exit the highway and pull into a gas station. I could have been killed. I called BMW to have the car towed to the dealer as it was still raining and I was unable to drive. It was over 2 hours for the tow so I waited for the rain to stop and then I drove home.
- Back over prevention › Sensing system › Camera
The backup camera at night is very dark and unsafe. I can barely see anything. It’s a major safety issue even though sensors can warn you, I almost ran over my neighbor while backing out of the garage. My wife has a 2025 X5 that does not have this issue at all. I see online forums where tons of people are complaining about the same issue, making it very unsafe.
- Wheels
My 2025 BMW i4 has experienced two distinct but related tire safety issues involving abnormal wear and repeated structural failures. Issue 1: Extreme Accelerated Tire Wear The factory-installed tires on my new vehicle were fully worn out in approximately 4 months and ~5,000 miles. All four tires…
My 2025 BMW i4 has experienced two distinct but related tire safety issues involving abnormal wear and repeated structural failures. Issue 1: Extreme Accelerated Tire Wear The factory-installed tires on my new vehicle were fully worn out in approximately 4 months and ~5,000 miles. All four tires required replacement. This level of wear is far outside normal expectations, including for heavy EVs or performance summer tires, and indicates abnormal loading or alignment behavior. Issue 2: Repeated Structural Failures of Right Rear Tire After replacement tires were installed by the BMW dealer on 12/04, two separate right rear tires developed holes/structural failures within a short period. One failure occurred by 01/09, approximately 30 days after installation, while the tire was nearly new. Damage was located at the inner shoulder/inner sidewall transition area, not consistent with normal tread wear or road damage. The recurrence of structural failure on the same wheel position strongly suggests a localized vehicle-related cause rather than tire defects or driving behavior. The dealer stated there were “no issues with the vehicle” and attributed both problems to normal EV weight and summer tire wear. No documented alignment measurements, wheel runout checks, or suspension diagnostics were provided. After the repeat right rear failure, the dealer proposed reinstalling the same tire type without offering any corrective action. The replacement tires installed were summer-compound tires during winter conditions, which increases brittleness and susceptibility to structural damage on heavy EVs. A nearly new tire developing a hole presents a blowout risk. The combination of extreme accelerated wear of all four tires and repeated structural failure of the right rear tire represents a predictable and ongoing safety concern.
- Other/i am not sure · Tether, lower anchor (on car seat or vehicle)
Nuna had a major recall for their rava convertible car seats as your organization is aware of. However, there are two main issues that I'm having that Nuna has refused to address nor do they have a viable solution for. The first is that with the recall fix which was new material they sent out, the…
Nuna had a major recall for their rava convertible car seats as your organization is aware of. However, there are two main issues that I'm having that Nuna has refused to address nor do they have a viable solution for. The first is that with the recall fix which was new material they sent out, the harness button is covered by Fabric and when the rava is in rear-facing mode it becomes almost impossible to reach the harness release button. Nuna recommended using the leg rest to address the issue, however, the issue does still persist. In a time of emergency, it would be incredibly difficult to get the child out quickly , and normally it is just very difficult. I have attached image so you can understand what I'm talking about. The second issue is that the Fabrics that Nuna has issued for the recall do not match the Fabrics of the original purchased equipment. This is a huge problem because there are now mismatches in fabric types versus inserts and consumers paid for a certain type of fabric and have only gotten the black or the granite as replacements as part of the recall. For the date that these things happen as is required by this form , I've put in and around the date that I received the Fabrics.