2004 BMW R1200 ST

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10249027The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.
• 10204667One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.
• 10201170When diagnosing fault codes (0x3A13D7, 0x3A13D9), technicians erroneously condemn the electronic throttle grip, which analyses show is rarely the culprit.
• 10182619Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.
• 10149288Navigator V maintains a Bluetooth connection to a mobile phone for a short period.
• 10147756Mist forms in the headlight. This is due to condensation and goes away again.
• 10135006Incorrect tire pressure appears in the instrument cluster. Contamination or obstruction of the RDC sensor.
• 10037025BMW: procedure for determining and replacing incandescent and halogen light bulbs under warranty.
• 10033130BMW vehicles: fuel level sensor repairs. Where it IS necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as well. In some cases, epc does not show that the repair kit IS available separately in the illustration, but it IS available in the parts description. All models. No model years listed.
• 10030825BMW motorcycle: engine fuels containing ethanol. BMW motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. Ethanol mixtures in proportions higher than 10% can have an adverse effect on performance and can result in damage to components that come into contract with fuel. No warranty claims whatsoever for damage caused in this way will be accepted. No model years listed.
• 10029706BMW motorcycle: wheel speed dependent, clearly audible clanking noise occurs when braking to adjust speed. E series (K25; k25/02; k25/03; k25/11; k25/12; k25/hp; K26; K27; K28; K29; k29/hp; K40; K41; K43; k43/hv; K44; k589/03; K71). No model years listed.
• 10027805BMW motorcycles: esa rear spring strut cannot be calibrated with the GT1, cip error 14007. All models with esa, except r1200r (K27), r1200gs (k25/11) and r1200gs adv. (K25/12). Model years unknown.

Every BMW R1200 ST model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.