1994 Buick Roadmaster
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Buick › Roadmaster › 1994
These records cover every 1994 Buick Roadmaster. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 1994 Buick Roadmaster. Newest first.
Defective lower control arm ball joint attachment nuts were not properly torqued and can loosen.
Risk and remedy
Risk
If the lower control arm ball joint loosens, fatigues and separates from the front suspension knuckle, it could cause loss of vehicle control.
Remedy
Dealers will inspect both front lower control arm ball joint attachment nuts for proper torque. If the ball joint has loosened from the knuckle, both the ball joint and the knuckle will be replaced.
These vehicles fail to conform to fmvss no. 124, "accelerator control systems." at low temperatures, excessive friction can occur in the accelerator pedal assembly.
Risk and remedy
Risk
Consequence of non-compliance: in the event of a failure of the trottle return spring, if there IS excessive friction in the pedal assembly, the engine speed may not return to idle increasing the potential for a vehicle crash.
Remedy
Dealers will replace the accelerator pedal assembly.
The fuel tank attachment strap fasteners were not properly tightened. The fasteners can completely detach, eventually allowing the fuel tank to sag and the bottom of the tank to strike the roadway.
Risk and remedy
Risk
This can result in a fuel tank leak and fire if the leaking fuel IS exposed to a source of ignition.
Remedy
Dealers will retighten the fuel tank strap fasteners.
Paint on the wheel mounting surfaces can act as a shim between the wheel and the rotor/drum. As the vehicle IS driven, the wheel imbeds into the paint, loosening the lug nut and causing a loss of clamp load.
Risk and remedy
Risk
Once clamp load IS lost, all tire loads are taken by the wheel studs resulting in a fracture of the wheel studs. This could cause the wheel to separate from the vehicle and could result in a vehicles crash without prior warning.
Remedy
Dealers will clean the wheel mounting surfaces for all four wheels. Also, the wheel studs will be inspected for damage and will be replaced as necessary.
The engine oil cooler inlet hose may have been installed too close to the steering gear causing chafing. The chafing can eventually wear through the hose's protective sleeve resulting in engine oil leaking onto the engine.
Risk and remedy
Risk
If this occurs, the oil leak onto the engine can result in an engine compartment fire.
Owner complaints
85 complaints11 involved a crash4 involved a fire6 injuries
What owners report most
Latest complaints
- Fuel/propulsion system
Went and filled the fuel tank with fuel , I went about 100 yards to another store , stayed in the store about 30 minutes , when I came out I noticed fuel on the ground on the left side around the fuel tank
- Fuel system, gasoline
Tl*the contact owns a 1994 buick roadmaster. He noticed a small amount of gasoline near the fuel tank. He immediately notified the dealer to have the vehicle inspected and didn't receive a response. He also notified the manufacturer in reference to recall# 94v210000 (fuel system…
Tl*the contact owns a 1994 buick roadmaster. He noticed a small amount of gasoline near the fuel tank. He immediately notified the dealer to have the vehicle inspected and didn't receive a response. He also notified the manufacturer in reference to recall# 94v210000 (fuel system, gasoline:storage:tank assembly:mounting), and was informed by a representative that his vin number was excluded. The manufacturer also stated that they would not assume responsibility for the repair. The vehicle has not been repaired. The failure and current mileages were 130,000.
- Suspension › Front › Control arm › Lower ball joint
The consumer was driving 7 mph when the vehicle lost control due to the ball joint dislodging. *Ak the lower ball joint failed due to the nut backing off. the ball joint fell out of the knuckle causing the vehicle to collapse and drag on the ground. (Recall ID number : 96v019000) *tc *jb
- Electrical system › Ignition › Switch
Upon turning vehicle off key become stuck in the ignition switch. Vehicle was towed to dealership, technician replaced ignition switch. *Ak
- Tires › Tread/belt
I purchased 4 new goodyear tires approximately 3 years ago. while driving on florida tpk on 1/4/04 I could hear a thumping sound from the left front tire. I got off at the next exit to look at tire and I could see that the tread had separated from the tire. we stayed at a local hotel that night…
I purchased 4 new goodyear tires approximately 3 years ago. while driving on florida tpk on 1/4/04 I could hear a thumping sound from the left front tire. I got off at the next exit to look at tire and I could see that the tread had separated from the tire. we stayed at a local hotel that night and brought the car to a nearby goodyear dealer. he confirmed that it was a tread separation and replaced the tire at a discounted price. he said that he has never seen such a thing on this brand, integrity p225/70r15. I don't have the dot numbe, but the dealer does. goodyear auto service center 30100 s dixie hwy homestead, fl 33030. the original tires were purchased at pompano tire and auto, pompano beach, fl. while we are disappointed that goodyear did not replace the tire at no cost, we just can't believe that they denied any liability or responsibility for the defect in this tire. if I did not pull off the road when I heard the noise, the tire would have blown at high speed and we could have been killed or killed someone else. when I challanged goodyear they responded with they don't fully replace tires according to their guarentee. I know there have been recalls by goodyear in the past because of this problem with other tire models. someone should look into this to make sure that it does not happen again or that they recall this model. I've inclosed pictures and a copy of the invoice from the dealer. I had to replace the other fron tire also to have the same tread wear on the front but are fearfull that one of the other tire might develop the same problem. my beef IS with goodyear, not the local dealer. he did the best he could bassed on goodyears policy.*ak
- Tires › Tread/belt
While driving at 65mph right rear tire tread separated while driving. Manufacturer notified. *Ak
- Structure › Frame and members
Consumer took vehicle to the mechanic for regular oil change, and found out that frame rusted and had a hole. which was a safety issued. Dealer not notified. *Ak
- Seat belts › Front › Buckle assembly
The seat belt on the drivers side doesn't stay clipped. Dealer notified. *scc
- Engine and engine cooling
Consumer states while traveling without any indication vehicle stall. Consumer had vehicle service technician notice temperature gauge needed to be replaced. Please provide further information. mr
- Suspension
Vehicle jerks when putting it into reverse or drive. Also, when driving 60mph vehicle shakes. Please provide any further information.*ak
- Electrical system › 12v/24v/48v battery
Consumer states undersized connector stud failed causing vehicle to lose all power while driving, dealer inspected vehicle and found stud was melted, dealer replaced the battery positive connector on the under hood fuse box and cleaned the cables and connectors. *slc
- Electrical system › Ignition › Module
Computer module failed to operate properly, leaving consumer stranded. dealer has replaced module. please provide any additional information.*ak
- Seat belts › Front › Buckle assembly
The spring in the seat belt buckle would not allow the seatbelt to stay fastened, consumer had to purchase the passenger side buckle even though it wasn't needed and IS requesting reimbursement for the belt kit. *slc
- Engine and engine cooling › Engine › Gasoline
Engine stops running with out any pattern... Hot, cold fast,slow. *ak
- Electrical system › Horn
Horn won't honk unless steering wheel IS straight ahead-always-replaced by dealer once, with no improvement. gm paid for the part: $600!!! dangerous! caprice and fleetwood are the same b body series of gm full-size, rear drive, V-8 vehicles (their last of these)!
- Electrical system › Wiring › Front underhood
Engine IS dead when the battery terminal gets hot. yh
- Electrical system › 12v/24v/48v battery › Cables
The engine failed while driving due to a melted cable from the battery to a computer that controled the engine. Yh
- Suspension › Front › Control arm
Our car has been dealer maintained since its purchase. the passenger side ball joint broke as we were slowing to make a turn, thereby escaping personal injury. the dealer which maintains the car stated they have greased the joint with each oil change and the failure was due to previous trauma.…
Our car has been dealer maintained since its purchase. the passenger side ball joint broke as we were slowing to make a turn, thereby escaping personal injury. the dealer which maintains the car stated they have greased the joint with each oil change and the failure was due to previous trauma. however, there has been no damage to any of the wheels (e.g. Hitting a pothole, accident, etc.) nor has a tire been replaced due to this type of damage. therefore, we feel the car was built with an inherent safety defect. *Ak
- Fuel system, gasoline › Delivery
Smelled gasoline. noticed leakage within inches of the left exhaust pipe. entire crossframe was wet. contacted dealer . dealer discovered that fuel leakage was caused by chafing of fuel lines. *ak *ML
- Engine and engine cooling › Cooling system
Factory installed water pump without the bearing seal. This caused coolant leakages and overheating. engineer inspected original water pump and stated that the bearings were not sealed and should not have failed at 45000 miles. *ak *ML
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
While driving consumer tried to use ABS brakes, and vehicle would not stop. Vehicle was still moving at about 1MPH ,for a mile before actually stopping.*ak
- Engine and engine cooling · Suspension
Front cam oil leak repair 2 times bad front spring replace overheating, replaced thermostat and water pump, to no avail, coolant sensor installed problem solved. model roadmaster
- Electrical system › Horn
Horn works part-time. dealer says "linked to air bag-$603 to fix."ak
- Air bags · Electrical system › Horn
Horn works part-time. Dealer says "linked to airbag-$603 to fix."
- Electrical system › 12v/24v/48v battery
The positive cable from the battery has completely melted, causing the vehicle to lose all power. Dealer has seen vehicle. *ak
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10246631Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- 10168979This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable. E version update is to add administrative details.
- 10165876This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable.
- 10141381This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
- 603086Some vehicles experience engine miss/ poor driveability symptoms.
- 54332Experiencing engine noise.
- 54328Experiencing intermittent steering column snap or click noise when turning.
- 52601Engine noise (install valve stem oil seal).
- 52106Water in air pump and/or dtc p0410, p0412, p1415, p1416, p0100, p0101, p0102 and dtc 48 (install air pump service kit).
- 45823Unknown
- 37956Automatic door lock feature may not operate.
- 37951Wiper chatter during cold weather.
Every Buick Roadmaster model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.