1991 Chevrolet G Series
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › G Series › 1991
These records cover every 1991 Chevrolet G Series. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Owner complaints
3 complaints1 involved a fire
What owners report most
Latest complaints
- Engine and engine cooling › Engine › Gasoline
Vehicle fire.
- Latches/locks/linkages › Doors › Latch
Drivers side door locking post cracking away from main body of vehicle, causing door to fail to close properly. *Dh
- Seat belts › Front › Anchorage
Shoulder belt anchor located 40 inches above seat surface, making it impossible to adjust for comfort. *Dh
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 609709Subject regarding a hard, no start or excessive gray or white smoke condition on start up after recent glow plug replacement.
- 41063Recall 91-c-50 - general motors has determined that certain 1991 chevrtolet c/k trucks, M/L and g vans equipped with 4.3L engines [rpo LB4 or rpo LU2 (m van only)] may be emitting non-methane hydrocarbons (nmhc) in excess of california emissions standards. California emissions standards were established to protect the public health and wealfare from dangers of air pollution. Excess emission of nmhc may cause a vehicle to fail state mandated emission tests. To correct this condition, dealers are to install a new oxygen sensor.
- 39428Inoperative door lock/latch.
- 39304Cold engine knock.
- 39303Transmission leak at rear extention housing and prop shaft.
- 39270Unknown
- 39074Rear and side cargo door latch rattles.
- 39070New cast iron exhaust manifold and stainless steel gasket to correct engine noise condition.
- 38076California recall - general motors has determined that certain 1991 c/k trucks, M/L and g vans with 4.3L engines may be emitting non-methane hydrocarbons in excess of california emission standards. To correct this condition, dealers are to install a new exhaust oxygen sensor.
- 37947Oil pressure gauge reading concerns.
- 37942Transmission extention seal leaks.
- 37844Insufficient heater performance.
Every Chevrolet G Series model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.