2019 Chevrolet Sonic

Owner complaints

What owners report most

1. Unknown or other3
2. Engine2
3. Engine and engine cooling2
4. Fuel/propulsion system2
5. Electrical system1

Latest complaints

• Nov 13, 2024MD
  Electrical system · Engine · Fuel/propulsion system

  The thermostat housing and water pump keeps failing and leaking.The seat heaters dont work. The car started leaking antifreeze real bad which cause it to overheat and lock up. Yes it has been confirm by a dealer that alot of the chevys been coming for new thermostat housing and water pumps. No vehicle was only inspected by a dealer. The overheating like came on and then 10 seconds later the car locked up

• Jul 29, 2024PA81,400 mi
  Engine and engine cooling
  The contact owns a 2019 Chevrolet Sonic. The contact stated while pulling into the garage, the high engine temp warning light illuminated, and the engine was overheating. The contact immediately turned off the vehicle. The contact stated there was coolant underneath the front of the vehicle. The…

  The contact owns a 2019 Chevrolet Sonic. The contact stated while pulling into the garage, the high engine temp warning light illuminated, and the engine was overheating. The contact immediately turned off the vehicle. The contact stated there was coolant underneath the front of the vehicle. The contact had learned that the water pump failure was common for the vehicle and believed that the water pump had failed. The contact was able to identify an extended warranty for the failure. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure when it was confirmed that the VIN was not covered under warranty or recall. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 81,400.

• May 24, 2024TN47,600 mi
  Engine and engine cooling › Engine › Gasoline › Turbo/supercharger
  The contact owns a 2019 Chevrolet Sonic. The contact stated the RPMs rose abnormally high. The contact stated that the check engine warning light had illuminated. The vehicle was taken to an AutoZone where it was scanned and diagnosed that the turbo charger had failed and needed to be replaced. The…

  The contact owns a 2019 Chevrolet Sonic. The contact stated the RPMs rose abnormally high. The contact stated that the check engine warning light had illuminated. The vehicle was taken to an AutoZone where it was scanned and diagnosed that the turbo charger had failed and needed to be replaced. The diagnostic scan retrieved DTC code: P0299. The manufacturer was made aware of the failure. The failure mileage was approximately 47,600.

• Apr 24, 2024PA
  Engine

  There is no temperature indicator and the car overheats. This caused the hose to the coolant to leak. I had the housing unit replaced but then the car still ran hot. I had the get the whole thermostat replaced. No forum could assist with the replacement of the 2019 as if this year model doesn’t exist and the part needed doesn’t fit properly making my car inoperable.

• Feb 5, 2024MD
  Fuel/propulsion system

  cooling ISSUES - the WATER PUMPLE , cooling TANK . the WHOLE COOLING . my CARE HAS BEEN SHOP 5 TIMES AT JBA for cooling system

• Feb 5, 2024MD
  Unknown or other

  Cooling Issues with 2019

• Jan 15, 2024MD
  Unknown or other

  the CAR WAS BOUGHT IN May 24 of 2019. Since the car has been in the shop 4 times at JBA in Glen Burnie MD were I bought car From . Car been in Shop at JBA 01/29/2020 -Coolant Leaking , Was back in Shop 07/25/2022 - Water Pump Leaking , Car was Leaking Coolant, Back in shop October 2023 - For Over heating , Cooling System, Here we are January of 2024 car going back in shop at JBA or Cooling Issues

• Jul 16, 2019MA25 mi
  Unknown or other

  Vehicle IS making a loud 'howling' noise. I brought it to the dealership, and they said that there IS no fix to it.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11011989This service bulletin provides information on the harmful effects of ethylene glycol in transmission fluid.
• 11011900This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
• 11011805This Preliminary information communicates a GM part number forreflective high temperature heat or insulating tape when repairing wiring harnesses.
• 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
• 11011709This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
• 11011444This Preliminary information communicates to the dealer a process for accessing the procedure to add attachments to a GM technical assistance case using the dealer case management tool.
• 11011420This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the dealer contacts TAC.
• 11011205This informational bulletin explains Unscheduled Supplemental Services and the importance of GM Simplified Maintenance Schedules.
• 11011119This Preliminary information communicates to dealers GM is working on a solution for outdated Apps
• 11010651This service bulletin informs the technician of an alternate lift procedure that has been developed when the lift plate does not fit the top of the transmission case for 6T30, 6T35, 6T40, 6T45, and 6T50 Transmissions.
• 11010576This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
• 11010545This service bulletin provides information on key code security rules and information on GM keycode look-up applications (U.S).
• 11010495This bulletin provides information on Warranty Administration Required Operating Procedures - 8 Points (U.S. Only).
• 11010493This warranty administration service bulletin provides information about GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period.
• 11010491This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
• 11010490This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
• 11010488This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.
• 11010421This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
• 11009764This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
• 11009756This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management.
• 11009532This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
• 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
• 11009170This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
• 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
• 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
• 11009039This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
• 11009037This service bulletin provides information on Enhancing Field Product Reports with Digital Pictures.
• 11008986This Preliminary information communicatesdirection and examples when diagnosing multiple DTCs, one of which includes U**** Byte 71 DTC.
• 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
• 11008906This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
• 11008898The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect.
• 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
• 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
• 11007777This Preliminary information communicates that the radio remaining on for 11 minutes after RAP is canceled willresolve itself after a few drive cycles.
• 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
• 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
• 11007721This service bulletin provides information on AGM batteries that require less frequent charging in storage.
• 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
• 11007196This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies.
• 11007155This informational bulletin advises the technician that the engine and related parts will be debited if found that the tech did not properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged by the tech.

Every Chevrolet Sonic model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.