2009 Chrysler Aspen 4X4

Owner complaints

What owners report most

1. Air bags4
2. Electrical system1
3. Fuel/propulsion system1
4. Power train1
5. Seat belts1
6. Tires1
7. Vehicle speed control1

Latest complaints

• Aug 14, 2018NE145,000 mi
  Fuel/propulsion system

  SUV stalls after filling fuel tank. Often it will require multiple cycles of starting and stalling before it will continue to run. Problem appears to be more severe in cold weather. the SUV has stalled in traffic on multiple occasions. additionally gas will splash out during fueling.

• Dec 2, 2017MS
  Electrical system · Power train · Vehicle speed control
  For no known reason my 2009 chrysler aspen 4X4 will engage on its own, I have repeatedly taken it in to the dealership (which by the way IS horrible) they can not figure out what the problem IS . However since I have a lifetime warranty they have claimed I need every single part covered under the…

  For no known reason my 2009 chrysler aspen 4X4 will engage on its own, I have repeatedly taken it in to the dealership (which by the way IS horrible) they can not figure out what the problem IS . However since I have a lifetime warranty they have claimed I need every single part covered under the warranty with not results. the first time I called the dealership regarding this I was told to bring the truck in immediately as this IS an extremely dangerous problem due to the fact when it IS engaged the truck will loose power. It engaged while I was on the freeway doing 70 mph and dropped instantly to 20 mph and would not go over 35mph. my overhead console, dash and radio at random go out. According to the dealership I needed a new radio 3 times each time the radio would start working again for the same reason it stopped, unknown. I turn on the turn signal they flash between left, right and hazard.

• Apr 13, 2017PACrash1 injury
  Air bags · Seat belts · Tires
  TL* takata recall. The contact owns a 2009 chrysler aspen 4X4. The vehicle was included in nhtsa campaign numbers: 16v947000 (air bags) and 16v352000 (air bags). The manufacturer failed to supply the remedy parts to the dealer to receive the repair in a reasonable time frame. While driving downhill…

  TL* takata recall. The contact owns a 2009 chrysler aspen 4X4. The vehicle was included in nhtsa campaign numbers: 16v947000 (air bags) and 16v352000 (air bags). The manufacturer failed to supply the remedy parts to the dealer to receive the repair in a reasonable time frame. While driving downhill on an s curve at an unknown speed, the vehicle went over an ice patch. The front passenger side tire fractured, causing the vehicle to be unstable and crash. None of the air bags deployed. The seat belt failed to restrain the driver, which caused bruising from hitting the steering wheel. Medical attention was required. A police report was filed. The vehicle was towed to a dealer where it was determined that the vehicle performed as designed. The vehicle was not repaired. The contact was waiting for a response from the manufacturer to determine a solution to repair the vehicle. The failure mileage was not available. Parts distribution disconnect. ..updated 06/08/17 *bf (recall related incident) ts *cn

• Feb 21, 2017TN
  Air bags

  TL* takata recall. The contact owns a 2009 chrysler aspen 4X4. The contact received notification of nhtsa campaign number: 16v352000 (air bags); however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• Jan 3, 2017IL
  Air bags

  Takata recall it IS unacceptable that, in almost a year, no replacement part has been designed to remedy this potentially deadly issue! Chrysler needs to be held accountable for repair or replacement within a reasonable time frame, which I feel has lapsed.

• Aug 1, 2016MD
  Air bags
  TL* takata recall. The contact owns a 2009 chrysler aspen 4X4. the contact received notification of nhtsa campaign number: 16v352000 (air bags) and stated that the remedy and parts were not available within a reasonable time frame to schedule the recall repair with the dealer. The manufacturer…

  TL* takata recall. The contact owns a 2009 chrysler aspen 4X4. the contact received notification of nhtsa campaign number: 16v352000 (air bags) and stated that the remedy and parts were not available within a reasonable time frame to schedule the recall repair with the dealer. The manufacturer did not give a specific date for when the part would become available. The contact had not experienced a failure. Vin tool confirms parts not available.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
• 10229178Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
• 10224887RES / RHA / REB Radios That Support Bluetooth and Hands-Free 1. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands; DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Hands Free Module (and associated components) are the systems responsible for these features. A power cycle may be required for the hands-free module for proper diagnosis. Please reference; 8T - Navigation/Telecommunication Diagnosis and Testing (DIAGNOSIS AND TESTING - HANDS FREE PHONE)
• 10224693Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10221512Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
• 10220489Valve Body. These may cause over drive cycling.
• 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10220099Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10220098Authentic Mopar Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar Glass.
• 10220097Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10219732HVAC Distribution Housing
• 10217510Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 1021645482212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
• 10209647W5A580 (NAG1) Valve Body - complete
• 10191460Valve Body. These may cause over drive cycling.
• 10175743Disinfectant Solution Recommended for COVID-19
• 10175735Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
• 10169249Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
• 10169247Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
• 10169245Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
• 10166537RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
• 10139985Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10139978Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
• 10130081Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.
• 1013008005182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
• 10130079Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
• 10129047Warranty Operations Newsletter Updates from Warranty Operations
• 10129046Warranty Operations Newsletter Updates from Warranty Operations
• 10129045CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.
• 101290441NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
• 10129043Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
• 10129042Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
• 10129041P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement part can be obtained by ordering the same part number (CBSZR068AA) Please return suspect parts back to your facing depot using Return Code 02, before 02 September, 2016.
• 1012900882212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
• 10121927NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
• 10121846RES / RHA / REB Radios That Supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) are the systems responsible for these features. A power cycle may be required for the hands-free module for proper diagnosis.~ Please reference; 8T - Navigation/Telecommunication Diagnosis and Testing (DIAGNOSIS AND TESTING - HANDS FREE PHONE)
• 10044182Chrysler: flash: mil illuminating with transmission and driveability improvements. This bulletin involves flash reprogramming the powertrain control module (pcm) with new software. Also included model ram1500 model year 2010 and model dakota model years 2009-2010.
• 10038196Chrysler service campaign. See document search button for owner letter. The oil change interval has been lessened to 30K miles.
• 10037973Chrysler: malfunction light IS on and information on reprogramming the ecm. 2009 durango/aspen.

Every Chrysler Aspen 4X4 model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.