1986 Flxible Metro
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Flxible › Metro › 1986
These records cover every 1986 Flxible Metro. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
8 recalls name the 1986 Flxible Metro. Newest first.
These buses have the headlights automatically activated whenever the windshield wipers are activated. No other exterior lights are activated by windshield wiper activation. This does not comply with the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."
Risk and remedy
Risk
Consequence of non-compliance: this could cause a visibility problem increasing the potential for a vehicle accident.
Remedy
Dealers will modify the electrical wiring to activate all exterior lights whenever the windshield wipers are activated.
The entrance door emergency release mechanism may exceed the 20 lb. Force allowed by fmvss 217.
Risk and remedy
Risk
Buses would not comply with standard.
Remedy
Repair release cable mechanism to comply with standard.
Due to increased bulb load on the flasher, when operated in hazard mode, flasher did not meet performance requirements of fmvss 108.
Risk and remedy
Risk
Buses do not comply with fmvss 108.
Remedy
Install a combination turn hazard flasher that complies with standard.
An incorrect bolt may have been installed to retain the tilt steering column pivot bushings.
Risk and remedy
Risk
Bolt may not maintain specified torque and could breakor work loose and fall out, resulting in loss of steering control.
Remedy
Install proper sae grade 5 bolt.
The flashing mode of the deceleration light system IS not in compliance with fmvss 108.
Risk and remedy
Risk
Flashing deceleration lights may be confusing to otherdrivers; buses do not comply with fmvss 108.
Remedy
Modify deceleration lights to remove the flashing mode.
Steering column lower shaft may be too long allowing excessive thrust load to be applied to upper housing bearings and steering transfer box bearings.
Risk and remedy
Risk
Bearings could fail or seize, resulting in loss ofsteering control.
Remedy
Replace steering column assembly with one of proper length.
Incorrect lock washers may have been installed on the tilt steering column pivot bushing bolts and the column housing pivot may be misaligned. consequence of defect: pivot bolt could loosen and result…
Risk and remedy
Remedy
Install proper lock washer and correct misalignment of column housing pivot.
Only two emergency window exists were identified on the left side of the bus, instead of three required by fmvss 217. consequence of defect: buses do not comply with fmvss 217.
Risk and remedy
Remedy
Emergency exit instructions will be added to the third window on the left side to identify this window position as an emergency exit.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Drag link failure
There is no summary currently available
Every Flxible Metro model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.