1995 Ford F Series (medium)

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 3055700Unknown
• 612728Some vehicles may experience oil leaking from the shift lever. *Mjs
• 51861Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients.
• 51417Suspension - noise from front spring rear hanger - revised rear spring hanger insulator pad - vehicles equipped with 6000, 7000 or 9000 lb axles built through 10/1/97.
• 50440Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds.
• 50429E4OD trans may emit a tick/rattle noise when driving at light loads in 1ST gear at 1100 to 1800 rpm rpm.
• 50356Information on aode/4r7w transmission main control & case replacement.
• 46478The use of petroleum-based grease as a lubricant in servicing disc brakes IS no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. If petroleum-based grease IS used to lubricate any part of the disc brake system, it could cause rubber parts to swell if lubricant contacts the rubber material.
• 46477The engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even though the engine IS at its proper operating temp on some vehicles. This IS caused by the coolant temp sending unit not being positioned in the main stream of coolant flow. Install a new temp sender fitting.
• 46476Hard starting or a no start concern may occur on some vehicles. This may be due to diesel fuel draining out of the fuel injection system back into the fuel tank. This condition causes the injection system to lose its prime which leads to longer starter engagement times for engine shutdown period. Install a diesel fuel check valve (f5hz-9285-aa) on the fuel return line at the rear of the engine.
• 46446On f/b series w/ fd 1060 engine there may be a concern regarding insuffi- cient in-cab heat. To resolve this, the current thermostat can be replaced with a new low leak thermostat. The needed parts are available from cummis engine. Refer to tsb 95-20-12.
• 46415W/ hydraulic brakes & tilt hood, hydraulic fluid may leak from the brake pump reservoir. Tsb 95-10-13 provided a reservoir support bracket to minimize leakage. It was determined that this repair was not entirely effective. Engineering IS working on a process to remote mount the reservoir from the engine onto the radiator support bar.
• 45971Engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine
• 45970Generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95.
• 45945Leaks - oil - front cover or gear housing vehicles with fd1460 engine.
• 45754Improved air compressor support bracket.
• 45087Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump.
• 44093A/c compressor may be damaged due to the overall length of the hose between the accumulator and the compressor. The hose may not be adequate to to allow for engine movement.
• 41023The engine wiring harness may become pinched between the cab and left hand frame rail.
• 39914Battery covers for outboard frame-mounted batteries rattle or crack.
• 39718Throttle - hand throttle difficult to operate.
• 39234Steering - revised camber specification.
• 39233Stationary engine cover cracks.
• 39132The hydromax brake reservoir mounting bracket may seperate or fluid may slosh from the reservoir.
• 38066Starter stays engaged after key IS released.
• 37754Mounting location of the air compressor governor interfering with power steering hose.
• 37744Multi-piece driveshaft misalignment with center bearing.
• 37743Main front end accessory drive belt rolls off.

Every Ford F Series (medium) model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.