2022 Hino L-Series
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hino › L-Series › 2022
These records cover every 2022 Hino L-Series. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11006074We have determined that certain 2022 2024MY Hino S-Series vehicles equipped with 5.2L (4HK1) diesel engines and option (IE1) 4-wheel disc brakes were built with an Engine Control Module (ECM) and Diesel Exhaust Fluid Control Unit (DCU) containing an On Board Diagnostic (OBD) calibration error for Diagnostic Trouble Codes (DTC) P2201 NOx Sensor Circuit Performance Sensor 1 and P20EE Diesel Exhaust Fluid (DEF) System NOx Trap Low Efficiency.
- 110060712011 MY through 2021 MY vehicle may experience an exterior mirror stay that is loose or drifts slightly from its position. In these rare conditions an enhanced mirror stay, mirror stay mount, related fasteners and revised torque specifications have been released to correct this condition. This procedure provides directions for installation of the enhanced components. 2022 MY vehicle may experience cracking of the door structure around the lower mirror base on the driver side or passenger side. In these rare conditions, the effected door needs to be replaced. In addition, an enhanced mirror stay, mirror stay mount, related fasteners and revised torque specifications have been released to correct this condition. This procedure provides directions for installation of the enhanced components.
- 110060652022 to 2025 MY L-series are equipped with an engine start detection frequency monitor. Once the monitor has detected a predetermined amount of starts the meter will display Change starter & starter relay. The monitor must be reset any time the starter is replaced .
- 110031652022-2025 my l series low def fault codes 3497, 3498 tech tip no: 24-011
- 11000898This article will provide dealership technicians with information on how to open a tech assist case and discuss what is required when opening a Tech Assist Case.
- 11000897After connecting to a truck using DX3, it may be necessary to review or create a DX Diagnostic Report for review.
- 1025131622-23 my l-series coolant degas bottle supersession
- 10249761This TechTip was assembled with the most common service procedures to help technicians determine which diagnostic tool to use when performing general ABS/EBS diagnosis, Lane Departure Warning (LDW) diagnosis, Steering Zero Point Learning and ABS/EBS Module Programming.
- 10238883Allison 3000 series transmission plug inspection
- 10238881Some trucks built prior to May 9, 2022 may experience reduced or intermittent cooling performance from the air conditioning system. If a subject vehicle exhibits this condition, its likely that the refrigerant was overcharged during vehicle assembly. This procedure provides instructions for proper recovery and recharge of the refrigerant system and appropriate warranty claim application information.
- 10237343After a re-calibration of a Cummins Engine ECU, DTC 2222 Fuel Level (Main Tank) Sensor Circuit - Voltage Above Normal or Shorted to High Source may set in the engine ECU. This is likely the result of a re-calibration event where the Save / Restore Adjustable Parameters selection was not checked during the re-calibration using Cummins INSITE.
- 10228940L-SERIES RADIATOR HOSE CLAMP-COOLANT LEAK. The subject vehicles may exhibit coolant leaking from either the inlet or outlet radiator hose connections of the radiator or auxiliary transmission cooler. This leak may be due to reduced clamp retention at these 4 locations. If a coolant leak is identified coming from any of the 4 locations, this procedure provides installation instructions and directions to install the new style hose clamp at all 4 locations.
- 10222356Tt-22-017 l-series diagnostic trouble code (dtc) 0559 tech tip
- 102134902022My-2023my l series trucks a/c performance issue tt-22-012
- 102134882022My-2023my l series trucks coolant level sensor failure. Sb-22-013
- 10209672Engine related hino components for the 2022-2023 model year l series trucks equipped with a cummins engine tt-22-006
- 10209670Diesel fuel in the diesel exhaust fluid (def) tank tech tip tt-22-005
Every Hino L-Series model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.