1994 Holiday Rambler Aluma Lite
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Holiday Rambler › Aluma Lite › 1994
These records cover every 1994 Holiday Rambler Aluma Lite. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 1994 Holiday Rambler Aluma Lite. Newest first.
The federal certification label incorrectly states the gross axle weight rating (gawr) causing the load ratings for the tires and tire pressures to be wrong. This does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Risk and remedy
Risk
Consequence of non-compliance: incorrect tires and tire inflation can result in tire failure and possible vehicle accident.
Remedy
Owners will sent replacement certification labels and instructions for replacing them. If they prefer, owners can have their dealers replace these labels for them.
The storage compartment at the rear of the unit does not have a specified storage weight limitation and can therefore be loaded beyond the manufacturer's intentions. Also some units were designed with a fresh water tank located at the rear of the unit. As a result, these trailers exhibit reduced stability while being towed.
Risk and remedy
Risk
Overloading of the rear storage compartment especially with a full, rear-mounted fresh water tank, can cause reduced trailer stability and increase the potential for an accident.
Remedy
Dealers will place a label on the storage compartment to indicate the maximum storage weight capacity, will relocate the fresh water tank on the affected models, and install a "hensley arrow" hitch which will provide a better towing stability. The "hensley arrow" hitch will not be a required part for the remedy on the 1995 aluma-lite 31cfs travel trailer due to the unit's shorter length.
Two latches mounted on each side of the rear engine access cover and secure the cover when the motorhome IS in transit were not positioned correctly.
Risk and remedy
Risk
The latches were not consistently positioned in the same location on the engine cover to obtain positive contact and could come loose under certain driving conditions.
Remedy
Dealers will straighten out the latch to provide additional length required to ensure positive contact to secure the engine cover.
High temperatures produced by the generator exhaust pipe can result in heat distortion and subsequent rupture of the air lines. A rupture would cause a malfunction of the instrument panel air pressure gauges and/or engagement of the manual parking/emergency brake.
Risk and remedy
Risk
If the air line ruptures, the manualparking/emergency brake will engage, abruptly stopping the vehicle without warning, which can cause an accident.
Improper torque of the retaining bolts and nuts of the steering column slip shaft, which provides the connecting link between the upper steering column and the steering gear box, may cause the steering column slip shaft to separate at either the upper or lower connection of the shaft.
Risk and remedy
Risk
Separation of the steering column slip shaft at either the upper or lower connection of the shaft results in loss of steering control. this could occur without warning and result in a vehicle crash.
Remedy
Inspect and retorque the slip shaft retaining bolts and nuts. However, if, after the inspection, the bolts and nuts are found to be loose or overtorqued, new bolts and nuts will be installed and properly torqued.
Owner complaints
12 complaints
What owners report most
Latest complaints
- Equipment › Recreational vehicle/trailer
TL* - the contact received nhtsa recall # 06e076000 concerning rv, dometic. ndr1062 dometic refrigerator. the contact has not had any problems with holiday rambler to date and understood the safety risk involved. the production number was921 14 60 83, and the manufacturing date was 03 /31 /1999 . *ak
- Structure › Frame and members
Prepairing to travel north after our winter stay in south fl, we discovered that the body was seperating from the frame again. we could look into the gap and see that the elevator bolt heads that were to hold the unit togther had pulled through the base channel of the body frame structure. hrc…
Prepairing to travel north after our winter stay in south fl, we discovered that the body was seperating from the frame again. we could look into the gap and see that the elevator bolt heads that were to hold the unit togther had pulled through the base channel of the body frame structure. hrc again wanted us to take the unit to a dealer for inspection. rhone's had been no help with these ongoing structure problemsin the past. we decided that we would delay inspection untill we arrived in tx in october. in july we found that we could not open the front curb side door without first jacking up the rear of the trailer. the door dead bolt lock could no longer be used. at the same time, due to a damaging water leak, we discovered that the roof had cracked over the passage door. we patched the cracked, but have not been able to repaid the custom fabicated and perminately installed counter on the front curb side of the unit. we would continue traveling until we reached tx and hoilday world of houston.
- Tires
Before leaving san antonio, tx for our appointment with holiday world of houston, we discovered a buldge in the curb side rear tire. we mounted the new spare (purchased from rhone's in sept.). After arrining at holiday world in houston, we purchased and mounted 3 new goodyear marathon 15" load range "d" tire.( dot number: tire size: 15 )
- Structure › Frame and members
Upon arriving in san antonio, tx from md, we had a 3" gap between the trailer body and floor. we contacted hrc. they refered us to holiday world in houston, tx for investigation and repairs as may needed. at that time the cause was not known so any warraty coverage was in guestion. after our 10…
Upon arriving in san antonio, tx from md, we had a 3" gap between the trailer body and floor. we contacted hrc. they refered us to holiday world in houston, tx for investigation and repairs as may needed. at that time the cause was not known so any warraty coverage was in guestion. after our 10 day commentment in san antonio, we proceeded to houston slowly. hoilday worlds finding was astomishing. the factroy had never bolted the frame to the trailer body! hrc did agree to pay for the necessary labor and material costs to bolt the trailer together, but would not reinburse us for our 3 weeks of living expenses while we waited for this work to be completed.
- Tires
Rear curb side tire blow-out on us RT15, williamsport, pa damaging fender. Called rhone's for road sevice. they changed tire and we returned to their shop where we purchased a new spare tire.( dot number: tire size: 15 )
- Electrical system › 12v/24v/48v battery
The battery kill switch, located on the top ofthe battery box, front curb side under body floor, would not stay wood screwed in place. Rhone's relocated to the back sheetmetal wall of the battery box. No warranty coverage.
- Wheels › Hubcap/cover
Right curbside wheel bearing grease seal out of hub allowing gease leakage into brakes. replace all brake parts and bearing seals. no warrnty coverage.
- Tires
Tire failure: during tire rotation, we found a deep gouge on the inside tire wall, curbside rear. Gouging was caused by the shock bolt having not been removed after installation. Cut off all shock bolts, mounted spare tire and returned gouged tire to rhone's for replacement under warranty.( dot number: tire size: 15 )
- Structure › Frame and members
Rear of trailer wandering on return trip from fl. rear storage compartment dropping from body floor. underbody belly pan wrinkled and distorted. returned to rhone's 6/94. no comment on sway. Compartment drop & underbelly wrinkle "poor workmanship at factory". no corrections.
- Structure › Body › Door · Wheels › Hubcap/cover
Right rear hub froze.
- Suspension › Multiple axle
Dual axle design causes trailer to sway back and forth. *Dsh
- Structure › Frame and members · Suspension › Rear
Fish tailed very badly almost losing control. Main frame of trailer broke causing rear to drop. Please describe. tt
Every Holiday Rambler Aluma Lite model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.