2022 Hyundai Santa Fe Plug-In Hybrid
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Santa Fe Plug-In Hybrid › 2022
These records cover every 2022 Hyundai Santa Fe Plug-In Hybrid. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2022 Hyundai Santa Fe Plug-In Hybrid. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111…
Risk and remedy
Risk
A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.
Remedy
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit…
Risk and remedy
Risk
A fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe Plug-In Hybrid vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Dealers will inspect and replace the fuel tank, as necessary, free of charge. Owner notification letters were mailed March 20, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 240.
Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.
Risk and remedy
Risk
An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.
Remedy
Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 238/011G. This recall is an expansion of recall numbers 22V-354 and 22V-458.
Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe HEV and Santa Fe PHEV vehicles. The instrument cluster liquid-crystal display (LCD) may invert the image on the screen upon vehicle startup, making the display illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101…
Risk and remedy
Risk
An illegible instrument cluster will not show information such as vehicle speed or safety system warnings, which can increase the risk of a crash.
Remedy
Dealers will replace the instrument cluster, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 217.
Owner complaints
27 complaints2 involved a crash
What owners report most
Latest complaints
- Engine · Power train
The car was shaking alot but the engine light was off. Started it the next dat and the check engine light came on. Went to auto zone to see what the codes were. The 1st and 3rd cylinder are misfiring. The car was just serviced for the 60,000 mile tune up in june 2026. This problem started August…
The car was shaking alot but the engine light was off. Started it the next dat and the check engine light came on. Went to auto zone to see what the codes were. The 1st and 3rd cylinder are misfiring. The car was just serviced for the 60,000 mile tune up in june 2026. This problem started August 14, 2026. The dealership is stating that the spark coils or cylinders are not under warranty even though it was just serviced
- Engine
2022 Hyundai Santa Fe Plug-in Hybrid, confirming the exact symptom “the gasoline engine continues running after the vehicle is switched off.” the vehicle is on and your burn fuel and if the fuel tank is full then some major issue may occur.
- Unknown or other
My passenger's front door side vent window glass shattered unexplainably while I was making a left hand turn at 15 mph. This occurred at 7:25am in the morning after pulling my car out of my garage and driving about 1/3 mile before the unexplained glass explosion/shattering. The sound made was a…
My passenger's front door side vent window glass shattered unexplainably while I was making a left hand turn at 15 mph. This occurred at 7:25am in the morning after pulling my car out of my garage and driving about 1/3 mile before the unexplained glass explosion/shattering. The sound made was a loud bang/pop. Air temperature was around 68 degrees, no air conditioning was being used at the time. No other cars or pedestrians were around when it occurred. I inspected the glass and it does not appear as if there was any possibility it was caused by a rock or a projectile such as a bullet or bb gun. As mentioned the component that failed was a fixed vent window that does not open. Fortunately no passengers were in the car when the glass shattered. It has not been inspected since insurance will not cover the cost of the glass replacement. (Safelite glass to replace for $346.00 (my insurance deductible exceeds that amount). No warning signs before it occurred. (Possible manufacturing defect -impurities in glass? I don't think it was body flex or vibration which may have caused the explosion as I was driving only 15mph. I don't believe it is attributable to thermal stress either -due to no variation between internal and external air temperature)
- Unknown or other
This is a 2022 Santa Fe PHEV with just 33k miles on it. While driving on freeway, vehicle displayed warning sign for "Check Hybrid System" and the Check Engine light and Battery light switched on. Sensing a loss of power with the acceleration, I managed to get off the freeway and had to get the…
This is a 2022 Santa Fe PHEV with just 33k miles on it. While driving on freeway, vehicle displayed warning sign for "Check Hybrid System" and the Check Engine light and Battery light switched on. Sensing a loss of power with the acceleration, I managed to get off the freeway and had to get the vehicle towed to the nearest dealership. Once they checked the vehicle, they reported they had to recalibrate the HSG resolver motor and claimed the issue was now fixed. I collected the vehicle back from the dealership and to my horror, on the drive back home, the exact same problem resurfaced and I experienced a loss of power and stalling again. Now I have to tow the vehicle to another dealer again. Searching the internet for this problem shows that many other drivers have experienced and reported this issue, so I am recording my formal complaint. Twice in the space of a few days, I have experienced a safety issue that could have affected myself and my family and other drivers on the road. Hyundai needs to investigate and figure out the proper resolution for this failure and institute a recall to address ASAP.
- Electrical system · Engine · Fuel/propulsion system
First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months…
First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months in the service center with continuously new issues. Every time they assure us it is fixed and we try to take it home, it develops another failure and the check engine light returns. The technicians have told us they have no explanation for the multiple failures and are not confident they can permanently fix the vehicle. The failures are unrelated and are with the manifold, gasket, CVVD,, oxygen sensor, and battery. A bolt also sheared off in this time frame and had to be drilled out. In the last failure, the car began smoking heavily and dripping oil. We've requested a replacement. Hyundai said they will not replace the vehicle (nor buy back) and it is acceptable that multiple systems and parts fail within 3 years.
- Engine · Unknown or other · Vehicle speed control
I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took…
I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took car and immediately noticed grinding noises and straight back to Hyundai. They claim it's fine. Today same issue with reversing and aggressive car jolting. Hyundai is going to take it back tomorrow. I do not feel safe in this vehicle. It felt like the transmission was going to give out on the freeway. The rpm are maxing out at 5-20 mph and sometimes don't want to engage in drive. Extremely unsafe for freeway driving. There is something terribly wrong with this cars engine or transmission. Unsafe for Hyundai to release for use.
- Unknown or other
I believe my vehicle is part of the parking prawn recall. It jerked and jolt when in park very aggressively. When we proceeded to try to move the car in reverse it did not budge.
- Lane departure › Assist · Lane departure › Blind spot detection · Steering
The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however…
The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however the issue would eventually happen again. This has happened while driving on the highway and other various road situations without warning and making the vehicle very unsafe. I have taken my vehicle to Hyundai Ourisman in Bowie, Maryland (the dealership where I purchased the vehicle) three times over two years and they have failed to fix the problem. They have even replaced the battery in the car.
- Electrical system · Forward collision avoidance › Automatic emergency braking · Lane departure › Assist
Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting…
Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting to slow the car. Attached photo shows an indicated speed of 0mph, however was travelling approximately 50mph at this time. I also have video of the errors occurring, but there is not a way to upload video.
- Engine · Fuel/propulsion system · Power train
Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on…
Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on the freeway and lost acceleration causing me to pull off the road in median. The third time, I was at a stoplight and when the light turned green, I had almost no movement after edging into the intersection. Eventually, at about 5 mph, the car regained speed. The check light went on in the first event and the car was supposedly repaired at the second dealership by re-tensioning "pins". However, no lights or warnings went on for incident #2 or #3 that occurred after the earlier repair effort. The vehicle is currently at the dealership service center for it's 7th day of "unable to replicate the problem" after incident #3.
- Power train
From park to Drive or reverse there’s an issues with changing in between doing so. Loud noise and shake to the car when engaging in the new gear. Then it sounds like the cars accelerating but parked, not moving. When you put it back in drive a loud thud then revving noise occurs. Once driving…
From park to Drive or reverse there’s an issues with changing in between doing so. Loud noise and shake to the car when engaging in the new gear. Then it sounds like the cars accelerating but parked, not moving. When you put it back in drive a loud thud then revving noise occurs. Once driving again just after there’s little to no movement when you put your foot on the pedal. When you drive it’s slow to go. You can hear the car trying but you’re hit going the same pace as the other cars on the road. Seems unsafe. This has happened more than once. I mentioned it to the delayer they said it was fine. No issues.
- Forward collision avoidance › Automatic emergency braking
While driving on the freeway, another vehicle passed me in the lane to the right of me. Right before it passed me, my car triggered automatic emergency braking for no reason. It was very terrifying. The other car was in its own lane the entire time. This has happened multiple times.
- Trailer hitches
The contact owns a 2022 Hyundai Santa Fe. The contact received a notification for NHTSA Campaign Number: 23V181000 (Trailer Hitches); however, the parts for the repair were unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer…
The contact owns a 2022 Hyundai Santa Fe. The contact received a notification for NHTSA Campaign Number: 23V181000 (Trailer Hitches); however, the parts for the repair were unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.
- Electrical system · Fuel/propulsion system · Power train
I was idling for 15 minutes and then drove for 10 minutes at which time the Check Hybrid System Stop Safely alert showed on my dashboard with the red light. I was on a bridge and could not stop in the middle, this was very terrifying and dangerous as I was loosing acceleration and speed and it…
I was idling for 15 minutes and then drove for 10 minutes at which time the Check Hybrid System Stop Safely alert showed on my dashboard with the red light. I was on a bridge and could not stop in the middle, this was very terrifying and dangerous as I was loosing acceleration and speed and it felt like the car was about to totally turn off, i was losing control, I was pressing on the brake and i felt it was not braking at which I point luckily I was at the end of the bridge and pulled aside, and turned it off. I waited 15 minutes before turning it back on and drove it back home. As I was driving it I can see the battery level rising. I plugged the charger that night to charge it and it started charging but then suddenly stopped and would not charge. Since then I tried charging it again and it charges for an hour and stops. I took it the dealer at the earliest appointment I can get and they ran diagnostics and no code came up. They said that it had to do with the coolant and they put in a new coolant and that should hopefully solve the charging issue. I tried again to charge it at home and again it charged for an hour and then it stopped and will not charge again. I am scared to drive it far now and especially on brides.
- Lane departure › Assist · Lane departure › Blind spot detection · Steering
I was driving on a road approaching a right turn to enter into my neighborhood that has a 3 way intersection where only cars exiting the neighborhood have a stop sign. I turned my right turn signal on as I began to slow down and approach the turn (without stopping as there is no stop sign for my…
I was driving on a road approaching a right turn to enter into my neighborhood that has a 3 way intersection where only cars exiting the neighborhood have a stop sign. I turned my right turn signal on as I began to slow down and approach the turn (without stopping as there is no stop sign for my path). As I was about 1/4 way into the turn, an alert for either lane keep assist or driver assistance warning appeared and the steering wheel suddenly could not turn and I was forced to drive straight. Luckily, there was no car waiting at the stop sign or I would have hit them. I hit the brakes and was on the wrong side of the road pointed towards the curb. I saw multiple error messages for lane keep assist and drivers assisted warning but could still not turn the wheel. I slowly drove the car forward, wrestling the wheel to turn enough so I could park on the wrong side of the road. I tried putting the car in park and then drive again but it did not help. I turned the car off and on and the errors cleared and I could turn the wheels again. I then proceeded to slowly start driving home and less than 1/4 mile later as I was rounding a gentle curve (I did not use any turn signals), the same error occurred and I suddenly could not turn the wheel so I slammed the brakes and stopped in the middle of the road. I again turned the car off and on to reset and proceeded to drive the remaining 1/4 mile home and park in my driveway. I immediately contacted the Hyundai dealer and was recommended to have the car towed to the local dealer as it was unsafe to drive. Upon towing the car to the closest dealer, I was able to back the car off the tow truck and park it. While parking, the steering locked up again and I took the attached pictures of the error messages and showed the technician. The dealers in the area all indicated they were so backed up they could not diagnose the car immediately. I called Hyundai to open a case. It has been 2 weeks and they still have not diagnosed the car.
- Air bags
During the accident, the airbag in the steering wheel, barely deployed and threw sparks in the air. Passenger door airbag ruptured. I have pictures of the torn airbag. The cab of the vehicle filled with smoke and sparks came out around the steering wheel. Driver felt like their pants are on fire. To the best of my knowledge, there has been no inspection of the airbag system.
- Forward collision avoidance › Automatic emergency braking · Power train
The accident took place on February 13 at approximately 7:40 a.m. My wife (the primary driver of the vehicle) had just dropped my son off at school and was pulling the vehicle into our garage as she has done at least four times a day since we purchased it in February 2022 for use as our primary…
The accident took place on February 13 at approximately 7:40 a.m. My wife (the primary driver of the vehicle) had just dropped my son off at school and was pulling the vehicle into our garage as she has done at least four times a day since we purchased it in February 2022 for use as our primary family vehicle. She pulled into the garage, came to a complete stop, pressed the “Park” button and confirmed that the vehicle was in park, and removed her foot from the brake. The vehicle then lurched forward and collided with a storage cube adjacent to our garage wall, causing extensive damage to both the front end of the vehicle and the garage/dining room wall. Within minutes of the accident, I contacted Temecula Hyundai (our local dealership and service center), informed the Service Manager of what had just happened, and asked them how they wanted me to proceed given the fact that the malfunction was a warranty issue. They directed me to handle the accident through my insurance company. I specifically asked whether the vehicle needed to be preserved in place and not driven in order to maintain the scene and/or vehicle for investigation, and they said no. Nevertheless, we brought the vehicle to Hyundai that day to have it inspected and computer diagnostics run, since I suspected both might be necessary. They said the computer likely wouldn't capture this type of issue. We waited several weeks for our assigned Hyundai Case Manage (Tracy) to contact us with further instructions (which never happened, despite several requests for her and/or a supervisor to contact me), but eventually followed our insurance company’s instructions to take the vehicle to Caliber Collision to proceed with repairs, which were completed on March 30. We are still waiting for Hyundai corporate to address the issue.
- Electrical system
My car has been in the shop 4 times for my blinkers not working. It has been there for almost a month in total. Most recently the dealership gave it back saying they cannot replicate the problem so they cannot fix it. However, everyone I drive my car the blinkers says its not working so I don't…
My car has been in the shop 4 times for my blinkers not working. It has been there for almost a month in total. Most recently the dealership gave it back saying they cannot replicate the problem so they cannot fix it. However, everyone I drive my car the blinkers says its not working so I don't know how it cannot be replicated. I sent photos of the light indicating it was broken. When I reached out to hyundai they are refusing to call me back or address this issue. My case manager closed it stating the dealership said there was nothing wrong. It feels unsafe that my blinkers only work 50% of the time and hyundai is refusing to address it. It was in the shop for weeks so obviously something was going on.
- Lane departure › Assist
When Lane Follow Assist(LFA) is engaged, the vehicle is expected to steer itself following lane markings. eg: in freeways. Even when engaged, at certain times, the vehicle disengages this feature possibly to due to failure to detect lanes or due to any other issues. This disengagement happens…
When Lane Follow Assist(LFA) is engaged, the vehicle is expected to steer itself following lane markings. eg: in freeways. Even when engaged, at certain times, the vehicle disengages this feature possibly to due to failure to detect lanes or due to any other issues. This disengagement happens without any audible notice to the driver. All that happens is a very small icon in the console turning white from green. This can be easily missed as it can be easily hidden behind the steering wheel. Moreover, it's not safe to keep looking into the console when the driver is supposed to watch the road ahead. As heard, this issue is present in many Hyundai vehicles. An audible warning and bigger icon notification are most important for these safety critical situations. A driver may never know that the LFA is disengaged and probably can be in a collision before the driver realizes it. This is an important safety issue.
- Electrical system · Lane departure › Assist · Steering
Car's power steering has suddenly stopped working twice while I was driving. -- First time occurred on 7/24/2022. I was driving approximately 30 mph at the time. I was able to retain control of car and safely park. When steering stopped working, steering light illuminated red. I also got warnings…
Car's power steering has suddenly stopped working twice while I was driving. -- First time occurred on 7/24/2022. I was driving approximately 30 mph at the time. I was able to retain control of car and safely park. When steering stopped working, steering light illuminated red. I also got warnings about lane-keeping assist and blind spot detection features. According to Hyundai customer portal, car recorded the following DTCs (diagnostic trouble codes): -- * C168886 (System: CHASSIS; Sub-System: LKAS) * C240162 (System: CHASSIS; Sub-System: EPS) -- After I turned car off and back on twice, warnings cleared and power steering started working again. -- I had car transported to nearest dealership. -- Dealership's service department investigated and indicated the following: -- SCANNED SYSTEM FOR CODES FOUND HISTORY CODES C240162 MOTOR CIRUIT C16886 MDPS C168881 MDPS SIGNAL C168808 MDPS SIGNAL HISTORY. -- Their corrective action was as follows: -- CHECKED GROUND CONNECTION FOR MDPS. GOOD. FOUND LOOSE CONNECTION AT DRIVER'S LEFT FOOT KICK PANEL LOOSE. CLEARED CODES AND TEST DROVE VEHICLE 3 MILES OPERATING NORMALLY -- However, when I picked up car on 7/29/2022, immediately after exiting dealership's parking lot (while driving at low speed), power steering suddenly stopped working a second time. There were similar warnings (probably about lane-keeping assist and blind spot detection features again), but Hyundai customer portal shows no DTCs this time. -- I returned car to dealership's service department for them to investigate further. -- Sidebar: A coolant line in car's engine compartment was replaced in June 2022 due to rodent damage. When dealership was first looking at this steering issue, I reminded them of that occurrence and requested that they consider possible rodent damage to electrical system as a cause of the steering issue. They did not notice any such damage.
- Fuel/propulsion system
Hybrid system failure while driving. Driving car, acceleration stopped dangerously, then dash warning prompt to stop driving immediately. Dealer was unable to diagnose and resolve.
- Electrical system · Engine
Upon starting the vehicle, the gear shift went into Drive mode but did not engage the engine or electric motor when depressing the accelerator. Then it would not allow me to change gear to Park, Neutral or Reverse. It would also not allow me to turn off the car, the electric motor was still running but not moving the vehicle.
- Hybrid propulsion system
The contact owns a 2022 Hyundai Santa Fe. The contact stated while driving approximately 70 MPH, the vehicle started jerking. The contact was driving uphill when the jerking occurred. The vehicle functionality of switching from the electric hybrid mode to the engine failed, and the vehicle lost…
The contact owns a 2022 Hyundai Santa Fe. The contact stated while driving approximately 70 MPH, the vehicle started jerking. The contact was driving uphill when the jerking occurred. The vehicle functionality of switching from the electric hybrid mode to the engine failed, and the vehicle lost motive and electrical power. The contact was able to glide down the hill safely. The hybrid system warning light was illuminated. The vehicle was towed to a local mechanic. The mechanic diagnosed a failure with the hybrid switching over the engine. The vehicle was being repaired. The manufacturer was notified of the failure. The approximate failure mileage was 4,000.
- Fuel/propulsion system
My Vehicle Hyundai Santafe Plugin hybrid 2022 is not showing an accurate gas miles range. It is giving incorrect information especially when traveling long drives. This is giving me anxiety about the loss of gas in the vehicle. It is also does not giving approximate mileage as described by the company on the sticker.
- Engine
2022 santa fe PHEV Pebble or road debris punctured inverter cooling radiator causing to leak out. Quality or design flaw ? If happens and driver is unaware until too late, entire inverter system could be ruined or possible battery fire. Took to dealer for repair. ~1600.00$ Non covered repair cost. Warning light went on, who's to say caught it in time to prevent worse damage to inverter / battery pack
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008008A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 11007485A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 11002708A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10241887The Shift-By-Wire (SBW) buttons have been made available as separate service parts for the SBW lever. If replacement of the SBW button is required due to one or more button plating peeling, replace the button(s) with a new one. Do not replace the complete SBW lever.
- 10240087This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundais Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous version. As a countermeasure, an update with a frame skip logic has been added to resolve the data congestion with Google Maps.
- 10238393This bulletin provides information related to the cleaning of the cooling system and coolant change to address the following problem: Refill Inverter Coolant warning light displayed on the cluster No DTCs present Normal level of coolant in Inverter Reservoir Tank Measured EWP Speed > 2,800 RPM
- 10238351This bulletin provides information related to the cleaning of the cooling system and coolant change to address the following problem: Refill Inverter Coolant warning light displayed on the cluster No DTCs present Normal level of coolant in Inverter Reservoir Tank Measured EWP Speed > 2,800 RPM The cause of the warning light is due to increased EWP Speed due to poor flow of coolant inside the cooling circuit. The coolant in the system will be discharged and any foreign substances in the circuit will be flushed out with new coolant added in the end.
- 10238348This bulletin provides information related to the replacement of the Owners Manual with a new version which contains correct information regarding the coolant used in the cooling system.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10235560This bulletin provides information related to the Engine Control Module (ECM) software update for Santa Fe Plug-in Hybrid (TM PHEV) vehicles to add CARB recommended OBD display items & improve the following DTC and symptoms:
- 10233557This bulletin provides information related to the Hybrid Control Unit (HCU) software update for Santa Fe Plug-in Hybrid (TM PHEV) vehicles to improve the following symptom: 1. Oil Dilution: Some vehicles may experience increased oil consumption and white smoke due to the diluting of engine oil with fuel because of the frequent transition between EV Engine mode during the winter season a. Modify fuel injection strategy below 10 and add oil heating function based on the driving pattern.
- 10233480This bulletin describes the procedure to reset the steering system torque value to balance uneven steering feel when steering left vs right on some Palisade (LX2), Santa Fe Hybrid (TM HEV), and Santa Fe Plug-In Hybrid (TM PHEV) vehicles.
- 10230909This bulletin describes the procedure to diagnose and repair tire pressure monitoring system (TPMS) DTC(s) on some 19MY and newer Santa Fe (TMA), 2021MY and newer Santa Fe Hybrid (TM HEV), 2022MY and newer Santa Fe Plug-In Hybrid (TM PHEV), and 2019MY and newer Palisade (LX2) vehicles equipped with surround view monitoring (SVM) system.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10218649If you are servicing an applicable vehicle with a Check Engine light on and one or more of the DTC listed below, follow the Service Procedure and replace the valve body internal harness and the input/output speed sensor.
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10215602If you are servicing an applicable vehicle with a Check Engine light on and one or more of the DTC listed below, follow the Service Procedure and replace the related solenoid and harness.
- 10215600This bulletin provides information related to the Engine Control Module (ECM) software update for Santa Fe Hybrid (TM HEV) / Santa Fe Plug-In Hybrid (TM PHEV) and Tucson Hybrid (NX4 HEV) / Tucson Plug-In Hybrid (NX4 PHEV) vehicles to revise the following DTC logic: P1441(PCSV rear and hose missing) P1A77(HSG Belt slip) P00B7(Excessive ITM motor operating current) P2118 (ETC target position failure) P0401 (EGR gas flow insufficient) P0236 (Turbocharger boost sensor range abnormal) P0299 (Turbocharger boost pressure too low)
Every Hyundai Santa Fe Plug-In Hybrid model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.