2010 Hyundai Veracruz
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Veracruz › 2010
These records cover every 2010 Hyundai Veracruz. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2010 Hyundai Veracruz. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally…
Risk and remedy
Risk
An engine compartment fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Hyundai Motor America (Hyundai) is recalling certain 2007-2012 Veracruz vehicles that were previously recalled under recall number 14V-415. Oil may leak from the front cylinder bank cover gasket, potentially dripping onto the alternator and causing the charging system to become inoperative.
Risk and remedy
Risk
An inoperative charging system can result in an engine stall, increasing the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will inspect the valve cover gasket and repair it as necessary, free of charge. Owner letters were mailed September 7, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 197.
Hyundai Motor Company (Hyundai) is recalling certain model year 2007-2012 Veracruz vehicles manufactured from December 26, 2006, through July 24, 2012. The affected vehicles may experience an oil leak from the front cylinder bank valve cover gasket. If there is a sufficient amount of oil dropped onto the alternator, the alternator will be damaged causing…
Risk and remedy
Risk
If the alternator is damaged, the charging system warning lamp in the instrument cluster will illuminate, and the engine will lose power and the vehicle will eventually stop operating while being driven. An unexpected failure of motive power while driving increases the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will inspect/repair or replace the alternator and the front valve cover gasket, free of charge. Hyundai sent out an interim letter to owners on September 3, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 121.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled…
Risk and remedy
Risk
Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Curt manufacturing IS recalling certain tow package wiring harnesses, part number 56024, that connect tow vehicle lighting circuits to trailer lighting circuits sold for use on certain model year 2009 through 2011 hyundai veracruz and KIA sorento vehicles. the units are not water-tight and moisture can seep into the converter module and defeat the module's…
Risk and remedy
Risk
Without the circuit protection, the module can overheat possibly resulting in a fire.
Remedy
Curt manufacturing will notify owners and replace the tow package wiring harness. the remedy will be performed free of charge. the safety recall began on october 17, 2011. owners may contact curt manufacturing at 1-715 831-8713.
Owner complaints
91 complaints1 involved a crash5 involved a fire
What owners report most
Latest complaints
- Electrical system · Engine
Valve covers leaking oil onto to the alternator. Engine may shut off while driving and cause serious accident. The problem has been confirmed, inspected, and diagnosed by Hyundai Dealership. The instrument panel , radio, and climate control lights flashing and flickering when lights are turned on.…
Valve covers leaking oil onto to the alternator. Engine may shut off while driving and cause serious accident. The problem has been confirmed, inspected, and diagnosed by Hyundai Dealership. The instrument panel , radio, and climate control lights flashing and flickering when lights are turned on. September 07, 2026 is when it first appeared. Recall was done by dealership but did not remedy permanent repair. Called Hyundai customer care and both dealership and customer care stating no longer under warranty due to mileage and time. Therefore stating that customer responsible for any cost to this repair.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling); however, the repair failed to prevent a failure. The contact stated that upon further inspection, there was an engine oil leak that was leaking onto the alternator. The local dealer was contacted. The failure mileage was approximately 205,670.
- Electrical system · Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that after starting the engine and shifting into drive(D), the engine immediately shut off. The vehicle could not be restarted, and the battery failed. The manufacturer and local dealer were notified of the failure. The cause of the…
The contact owns a 2010 Hyundai Veracruz. The contact stated that after starting the engine and shifting into drive(D), the engine immediately shut off. The vehicle could not be restarted, and the battery failed. The manufacturer and local dealer were notified of the failure. The cause of the failure was not determined. The contact stated that the vehicle had previously experienced the same failure and was serviced under the NHTSA Campaign Number: 14V415000(ENGINE AND ENGINE COOLING). The failure mileage was 114,000.
- Electrical system · Service brakes · Unknown or other
on 1/31/26 I replaced battery that was only a little over a year old. on 2/1/26 while driving myself and 2 of my kids to there grandparents we lost power and lights on dash started flickering. I was able to pull over the side barely. I was told by family after explaing what happend that it could be…
on 1/31/26 I replaced battery that was only a little over a year old. on 2/1/26 while driving myself and 2 of my kids to there grandparents we lost power and lights on dash started flickering. I was able to pull over the side barely. I was told by family after explaing what happend that it could be related to the recall. I called Larry H Miller Hyundai Albuquerque and they verified the recall and we set up appointment for 2/5/26. I was able to tow vehicle to the dealership on 2/3/26. I received a call later that day from Martin on why my vehicle was there I explained the issue of loss of power and lights and door locks flickering and I believed it to be related to the recall. I received a text/email with the dealership making recommedations. I refuse them as they were not urgent and not why my vehicle was there. I received a text message 2/4/26 that my vehicle was ready to be picked up and they had ordered the recall parts and was a week out but I was able to pick up. I called mutiple times for 2 weeks to find out more and was never called back. on 2/14/26 I drove to the dealer ship to find out what was going on. I was told they still were waiting for part and when I asked what part they ordered and why I never got a call back I was only told they ordered a "valve kit" which Martin had to call the parts dept becuse my vehicle was not in there current service since they were waiting on parts. I asked what about the alternator and they said since I denied any repairs out side of the recall and the battery was an item I declined they did not test the alternator. I asked why they could not charge it as I expressed to them several times it was a new battery. they never answered me. but they told be they had to charge it to get it in to look at it. I said well doesn't that mean the alternator is bad and it needs to be replaced under the recall. after going back and fourth I ended up taking my vehicle and ended up agian on the side of the road with my daughter.
- Engine
They should not have closed/completed the prior recall that was open regarding the valve cover gasket leak - oil leaks onto the alternator when can cause the alternator to fail. I went to the dealership last year to get it fixed and even per the dealership, they told me this valve cover leak is…
They should not have closed/completed the prior recall that was open regarding the valve cover gasket leak - oil leaks onto the alternator when can cause the alternator to fail. I went to the dealership last year to get it fixed and even per the dealership, they told me this valve cover leak is going to still be a problem even if fixed. It will leak again - and they are right. It is currently leaking again and possibly causing the alternator to fail.....again. Just this weekend my battery and alternator are failing when I just got them replaced within this past year!
- Visibility/wiper
My vehicle IS experiencing an issue with the winshield wiper motor the motor has failed and the wipers do not work therw IS a recall I seen for 2000-2012 hyundai vehicles unfortunately my vin number IS not included I spoke with hyundai and they told my vin IS not a recall defect that it IS a just…
My vehicle IS experiencing an issue with the winshield wiper motor the motor has failed and the wipers do not work therw IS a recall I seen for 2000-2012 hyundai vehicles unfortunately my vin number IS not included I spoke with hyundai and they told my vin IS not a recall defect that it IS a just regular problem that needs repaired. I am very hard pressed to believe that my year make and model has this recall just not my vin
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that there was a hard knocking sound coming from the engine. While driving 45 MPH, the vehicle lost motive power. The battery power was low. The vehicle was previously taken to the local dealer for TSB Number: 21-01-047H-2. The contact…
The contact owns a 2010 Hyundai Veracruz. The contact stated that there was a hard knocking sound coming from the engine. While driving 45 MPH, the vehicle lost motive power. The battery power was low. The vehicle was previously taken to the local dealer for TSB Number: 21-01-047H-2. The contact stated that the failure was related to NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) and 14V415000 (Engine and Engine Cooling). The alternator was replaced; however, the failure recurred. The vehicle was taken back to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 117,674.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated while driving at approximately 35 MPH, there was an abnormal odor inside the vehicle. The contact stated that the odor was burning oil. The contact stated that the check engine warning light was illuminated. The contact had taken the…
The contact owns a 2010 Hyundai Veracruz. The contact stated while driving at approximately 35 MPH, there was an abnormal odor inside the vehicle. The contact stated that the odor was burning oil. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was an oil leak from the T-Joint and that the repair was covered under Manufacturer Recall Number: 197 - Oil Leak on Alternator (Engine and Engine Cooling). The vehicle was repaired; however, the leak recently reoccurred. The contact took the vehicle back to the same dealer who diagnosed the failure and informed the contact that there was oil leaking onto the alternator. The contact was informed that the vehicle was no longer covered under the manufacturer’s recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.
- Engine
Driving at approximately 35 mph Check Engine Light came on P0331 Knock Sensor - light was cleared drove 14 miles CEL was back on. Called Hyundai about the code & knock sensor in reference to all the Hyundai models being recalled for the same problem and a warranty extension being granted. Hyundai…
Driving at approximately 35 mph Check Engine Light came on P0331 Knock Sensor - light was cleared drove 14 miles CEL was back on. Called Hyundai about the code & knock sensor in reference to all the Hyundai models being recalled for the same problem and a warranty extension being granted. Hyundai advised me to take it to a local dealer for diagnosis and pay the fee of course. I did just that. The dealer clear the codes and sent me home. CEL was on again. Car was back at dealer confirmed knock sensor replacement needed. I inquired about extension of warranty on my car. I was told it's not on the list. Called Hyundai back advised of the confirmation of diagnosis just to be informed that my car isn't covered under the extension warranty. We established that already. I asked to be escalated & was given a supervisor who suggested while the problem is being investigated I could ask the dealer to request Goodwill from Hyundai. Denied. Called Hyundai to follow up on my claim, I was advised claim closed my car isn't covered under the extension warranty for the same problem as other models and out of original warranty. Which I already knew. I was trying to find out if my car should be added to the list covered. I was told once the claim is closed it is closed. Hyundai needs to protect the owners of all Hyundai vehicles not just the popular ones. Since they closed my claim that fast. I would love an explanation as to why I was advised to take it to the dealer pay the fee and 25x the price for repair vs an independent shop. This is the 3rd time I've been without my car while it sits at the dealer waiting on parts. I'm left with a large bill, an unsafe engine and no vehicle. Hyundai needs to be held accountable. We shouldn't fear for our safety while driving. Bought in 2011 & it currently has 106,350 miles. Still within the 15 year, 150,000 mile warranty extended to other Hyundai owners whether original or not. I'm the original owner. My vehicle needs to be safe to drive.
- Service brakes, hydraulic
The contact owns a 2010 Hyundai Veracruz. The contact stated that while the vehicle was parked, she observed that the vehicle was leaking brake fluid. The ABS warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After…
The contact owns a 2010 Hyundai Veracruz. The contact stated that while the vehicle was parked, she observed that the vehicle was leaking brake fluid. The ABS warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown. Parts distribution disconnect.
- Engine
The contact owns a 2010 Hyundai Veracruz. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with knock sensor failure. The vehicle was repaired; however, the failure…
The contact owns a 2010 Hyundai Veracruz. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with knock sensor failure. The vehicle was repaired; however, the failure recurred shortly afterwards. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.
- Service brakes
I received a notice of a recall (23V-651) in September of last year, and Hyundai has not yet fixed the issue. This is the second possibly life-threatening recall on this car since I have owned it, and each time it has taken over six months for a remedy. In addition to risking my life and those of…
I received a notice of a recall (23V-651) in September of last year, and Hyundai has not yet fixed the issue. This is the second possibly life-threatening recall on this car since I have owned it, and each time it has taken over six months for a remedy. In addition to risking my life and those of my passengers on a daily basis, because I have been instructed to park outside I have to park the car on the street and risk having it damaged or stolen. Is there any time limit to how long a car manufacturer can neglect fixing a problem like this? 7 months and counting seems excessive.
- Electrical system · Exterior lighting
On the dashboard and stereo there are no lights when I turn on the cars automatic lights. It seems to be an electrical short. I brought it up to Hyundai because of the recall and they were very unhelpful. I called 15 different Hyundai dealerships in the Los Angeles area asking for a loaner vehicle…
On the dashboard and stereo there are no lights when I turn on the cars automatic lights. It seems to be an electrical short. I brought it up to Hyundai because of the recall and they were very unhelpful. I called 15 different Hyundai dealerships in the Los Angeles area asking for a loaner vehicle which none of them were able to provide for me. After I stated I already have an electrical short, they insisted that my car was not effected by the recall. And they would even write a letter to my insurance company stating that my car was not effected by the recall. They told me to continue driving my car like normal. I feel extremely unsafe and not taken care of by the Hyundai team. They continued to push off my concerns. The dealership has confirmed that the recall does effect my VIN number. However, they said there is no way to find out if the electrical short is from the recall or not. So they want to bill me $225 for a diagnosis. They have no inspected it because they will not do so without charging me the $225 which I refuse to pay for because of their recall. The electrical short problem has been an issue since I purchased the car. I asked the dealer I bought it from and he did not know what it was from. Months later I receive this letter in the mail stating there is an important safety recall on my car and Hyundai won’t do anything about it.
- Electrical system › Alternator/generator/regulator · Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that his wife was unable to start the vehicle. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the alternator to be replaced. The vehicle was repaired but experienced…
The contact owns a 2010 Hyundai Veracruz. The contact stated that his wife was unable to start the vehicle. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the alternator to be replaced. The vehicle was repaired but experienced the same failure three years later. The contact took the vehicle back to the local dealer, where it was diagnosed and determined that the alternator needed to be replaced a second time. The vehicle was repaired but experienced the same failure three years later. The contact took the vehicle to another local dealer: Southtowne Hyundai of Newnan (800 Bullsboro Dr, Newnan, GA 30263:(770) 253-1407), where it was diagnosed with needing the alternator to be replaced a third time. The vehicle was repaired for a third time. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.
- Electrical system
I have had the same thing happen to me3 TIMES with this Hyundai. It is a 2010 Veracruz. Twice before. it was repaired under the warranty, and then the recall. This time, it left me ON THE ROAD>> DEAD>> WITH NO POWER and NO WARNING. This was EXTREMELY DANGEROUS, and I could have been killed if it…
I have had the same thing happen to me3 TIMES with this Hyundai. It is a 2010 Veracruz. Twice before. it was repaired under the warranty, and then the recall. This time, it left me ON THE ROAD>> DEAD>> WITH NO POWER and NO WARNING. This was EXTREMELY DANGEROUS, and I could have been killed if it had failed while I was turning. I was, thankfully, in a turning lane. I had it towed AGAIN to Hyundai, where they "repaired it" after having my car for 8 days. We traded it BACK to them, because it is too dangerous for me to drive anymore. As I mentioned , it was supposed to have been fixed TWICE before.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that the vehicle had experienced an engine oil leak. The contact stated that the engine oil leaked onto the alternator and caused the alternator to fail. The vehicle was taken to the dealer and repaired under NHTSA Campaign Number…
The contact owns a 2010 Hyundai Veracruz. The contact stated that the vehicle had experienced an engine oil leak. The contact stated that the engine oil leaked onto the alternator and caused the alternator to fail. The vehicle was taken to the dealer and repaired under NHTSA Campaign Number: 14V415000 (Engine and Engine Cooling); however, the failure reoccurred. The vehicle was taken back to the dealer, who informed the contact that recall repairs were completed one-time free of charge. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.
- Electrical system · Engine · Fuel/propulsion system
Our ESC light comes on occasionally, many times when making a left turn. Then the throttle quits and the car slows down. We had it in the shop 6 times with no repair.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall…
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure and the vehicle was no longer drivable. Parts distribution disconnect.
- Unknown or other
2010 hyundai veracruz. Consumer writes in regard to safety recall not being completed due to lack of parts.
- Seat belts · Unknown or other
The driver's door handle does not work. The buckle assembly for the driver's seat belt has a stuck button and no longer works properly.
- Engine
The contact owns a 2010 Hyundai Veracruz. The contact received NHTSA Campaign Number 20V705000 (Engine and Engine Cooling).The contact stated that while driving, the battery warning light was illuminated. There was an abnormal smoke odor and also a burning rubber odor. The vehicle was taken to an…
The contact owns a 2010 Hyundai Veracruz. The contact received NHTSA Campaign Number 20V705000 (Engine and Engine Cooling).The contact stated that while driving, the battery warning light was illuminated. There was an abnormal smoke odor and also a burning rubber odor. The vehicle was taken to an independent mechanic who informed him that oil was leaking into the engine and onto the alternator. The contact called the local dealer and was informed that the mechanic was unable to repair the vehicle until May 2022. The manufacturer was not contacted and informed of the failure. The approximate failure mileage was 148,000.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) which stated that vehicle owners would receive another letter when parts were available. After several months, the vehicle was taken for an oil change and the…
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) which stated that vehicle owners would receive another letter when parts were available. After several months, the vehicle was taken for an oil change and the mechanic informed her that oil had leaked all over the engine compartment and the alternator. The contact was able to drive back to the residence and then the vehicle was taken to the local dealer to be diagnosed. The contact was informed that the alternator needed to be replaced; however, the part was not yet available. The vehicle was not repaired. Several days later while driving at an undisclosed speed, several unknown warning lights illuminated and the vehicle lost motive power and stalled. The contact was unable to restart the vehicle and the vehicle was towed to the local dealer. The contact was informed that parts were still not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000. The VIN was not available. Consumer stated no one had a solution car actually broke down while driving on Tuesday, February 15. Corporate had no solution. Consumer was told by National Consumer Affairs to work with dealer and see if they can possibly some aftermarket parts.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the…
The contact owns a 2010 Hyundai Veracruz. The contact received notification of NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the valve cover gasket was leaking oil. The approximate failure mileage was 140,000. Parts distribution disconnect.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that while operating the vehicle, the engine suddenly started to fail while the vehicle jerked and hesitated. The vehicle was able to be driven to the local dealer who indicated that engine oil had leaked onto the alternator and the…
The contact owns a 2010 Hyundai Veracruz. The contact stated that while operating the vehicle, the engine suddenly started to fail while the vehicle jerked and hesitated. The vehicle was able to be driven to the local dealer who indicated that engine oil had leaked onto the alternator and the alternator needed to be replaced. The vehicle was repaired however, the failure later recurred. The contact indicated that the vehicle was later serviced under NHTSA Campaign Number: 14V415000 (Engine and Engine Cooling). The manufacturer was also notified of the failure. The failure mileage was 131,000.
- Engine and engine cooling
The contact owns a 2010 Hyundai Veracruz. The contact stated that the front valve cover gasket was replaced by the dealer under NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, four months later, he noticed that oil was leaking underneath the vehicle. The vehicle was taken to…
The contact owns a 2010 Hyundai Veracruz. The contact stated that the front valve cover gasket was replaced by the dealer under NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, four months later, he noticed that oil was leaking underneath the vehicle. The vehicle was taken to the dealer, where it was diagnosed that oil was leaking from the rear valve cover gasket. The dealer informed the contact that the recall was specifically for the front valve cover gasket replacement and he would be responsible for the cost of the repair of the rear valve cover gasket. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 127,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by…
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10196577The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use, whichever occurs first. This warranty coverage applies to both the original and subsequent owners. Refer to the warranty and service parts information outlined in this bulletin whenever clock spring replacement is required.
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190038This bulletin provides best practice recommendations when performing brake service procedures.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10183963This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10178175This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes, or during normal driving operation.
- 10177599These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10177598These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10176182This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
- 10176178This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
- 10174808This bulletin provides information on identifying dealer stock vehicles with either: A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
- 10174807The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
- 10173546This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
- 10172142This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.
- 10170883This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bulletin provides physical differences between the USB 2.0 port and USB 3.0 port.
- 10169370The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the BSD/BCW zone and turns on the BSD/BCW warning lamp for the driver. The warning lamp starts blinking, along with an audible sound, when the driver turns on the turn signal lamp to enter the lane where another vehicle is driving.
- 10167253This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number.
- 10163866This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). The rear wheel speed sensor is available as a separate service part from the rear wheel hub assembly. When appropriate, it is recommended to replace only the rear wheel speed sensor instead of the full assembly.
- 10163288This bulletin provides information on the rear wheel speed sensor for Santa Fe (CM), Santa Fe / XL (NC), Santa Fe Sport (AN), and Veracruz (EN) vehicles equipped with front wheel drive (FWD). The rear wheel speed sensor is available as a separate service part from the rear wheel hub assembly. When appropriate, it is recommended to replace only the rear wheel speed sensor instead of the full assembly.
- 10160098This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot be removed or overwritten.
- 10158803This bulletin provides information on the serviceable parts for the outside mirror assembly. When diagnosing and repairing the outside mirror, do not replace the entire assembly. Refer to page 2 of this TSB for replacement of individual parts.
- 10082455"The pcm or tcm contains logic to adjust solenoid duty and line pressure as needed to compensate for normal clutch wear over the life of the transaxle. This bulletin provides the procedures necessary to reset (erase) and relearn the pcm/tcm adaptive values. After the following repairs have been completed, the pcm/tcm adaptive values must be reset in order to provide optimum shift quality. If the procedure IS not performed, the transmission may experience a shift flare or harsh shift. H replace automatic transaxle or pcm/tcm h reprogram or exchange a pcm/tcm from another vehicle"
- 10081115The following vehicles are equipped with a 6-speed automatic transmission. The atf level must be checked by the following procedure.
- 10038212Hyundai: a revised procedure for replacing the timing chain tensioners.
- 10034204Hyundai: label requirements for vehicle loading to comply with fmvss 110. Effective 6/2/08, fmvss 110 (fmvss 110) sets a threshold for correcting load capacity information indicated on tire placards when vehicle weight has been increased before retail sale. All models included after 6/2/08.
- 10032596Hyundai: overhead console lamp assembly replacement. Some vehicles may have been built with overhead console sunglass holders that stick closed at times.
Every Hyundai Veracruz model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.