2002 Hyundai XG350
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › XG350 › 2002
These records cover every 2002 Hyundai XG350. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 2002 Hyundai XG350. Newest first.
Hyundai IS recalling 188,282 my 2001-2004 sonata and my 2001-2004 xg300 and xg350 vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia…
Risk and remedy
Risk
If that happens, the vehicle may lose drive power to the wheels, and the front wheel may make contact with the fender or wheel well, thereby increasing the risk of a crash.
Remedy
Dealers will measure the thickness of the front sub-frame and inspect the front sub-frame for corrosion damage and, if necessary, the front sub-frame will be replaced with a new sub-frame that incorporates additional holes in the upper and lower panels. if the front sub-frame does not require replacement, the dealer will add drainage holes to the sub-frame and will treat the sub-frame with rust-proofing material to stop the corrosion process. this procedure will be performed free of charge. the recall IS expected to begin during april 2009. owners may contact the hyundai customer assistance center at 1-800-633-5151.
Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 301, "fuel system integrity" a valve on the fuel tank assembly may not close properly. if a vehicle rolls over and the fuel tank assembly valve IS not properly closed, fuel spillage may occur.
Risk and remedy
Risk
Fuel spillage in the presence of an ignition source may result in a fire.
Remedy
Dealers will install an additional fuel tank assembly valve. the recall began on october 5, 2004. owners should contact hyundai de puerto rico at 1-800-981-0188.
Some passenger vehicles contain a fuel tank assembly valve that may not close properly. if a vehicle with a fuel tank assembly valve that IS not properly closed were to roll over, fuel spillage may occur.
Risk and remedy
Risk
Fuel spillage in the presence of an ignition source may result in a fire.
Remedy
Dealers will install an additional fuel tank assembly valve. owner notification began on june 30, 2004. owners should contact hyundai at 1-800-633-5151.
Owner complaints
60 complaints8 involved a crash3 involved a fire5 injuries
What owners report most
Latest complaints
- Suspension
TL* the contact owns a 2002 hyundai xg350. The contact stated that the driver's side rear upper control arm detached from the frame due to corrosion. The contact also stated that he noticed the driver's side rear tire leaning. The contact also stated that the frame was corroded. The vehicle was not…
TL* the contact owns a 2002 hyundai xg350. The contact stated that the driver's side rear upper control arm detached from the frame due to corrosion. The contact also stated that he noticed the driver's side rear tire leaning. The contact also stated that the frame was corroded. The vehicle was not yet taken to a dealer or an independent mechanic for diagnostic testing. The contact called mccarthy blue springs hyundai (3000 nw s outer rd, blue springs, mo 64015) and informed them of the failure and schedule an appointment. The manufacturer was not made aware of the failure. The failure mileage was approximately 224,000.
- Power train
The torque converter & transmission fluid pump are known to be defective in this transmission, the f5a51 mitsubishi/hyundai transmission. Mine started going out recently, at 75K miles! This problem/defect IS also very well known to hyundai/kia/mitsubishi and they choose to ignore the issue &…
The torque converter & transmission fluid pump are known to be defective in this transmission, the f5a51 mitsubishi/hyundai transmission. Mine started going out recently, at 75K miles! This problem/defect IS also very well known to hyundai/kia/mitsubishi and they choose to ignore the issue & instead try to blame the owners & claim that we've been neglectful or abusive to the transmission which IS simply not the case. I'll say that again, hyundai & mitsubishi know of the manufacturing defects in these parts as well as defects with the crankshaft in the engine but choose to ignore it and claim that they are not responsible for these problems. There are known defects throughout the whole car, luckily mine IS only having issues with those two parts in the transmission so far. Please help all of the other owners of the vehicles that have that transmission & engine with even greater problems than my own.
- Engine
TL* the contact owns a 2002 hyundai xg350. While driving 40 mph, a burning odor was detected inside the vehicle and the check engine indicator illuminated. The contact was not sure of the origin of the odor. The vehicle was not taken to a dealer or independent mechanic for diagnostic testing or repairs. The manufacturer was not notified of the failure. The failure mileage was approximately 139,000.
- Engine
My hyundai xg 350 2002 had a little over 100,000 miles on it. on 2/12/2018, while driving on a route 17 south in mahwah, nj, I hear a high pitch cracking sound with a smoke coming out of the car and soon the car became disabled on the side of highway route 17 s leaking a engine oils all over the…
My hyundai xg 350 2002 had a little over 100,000 miles on it. on 2/12/2018, while driving on a route 17 south in mahwah, nj, I hear a high pitch cracking sound with a smoke coming out of the car and soon the car became disabled on the side of highway route 17 s leaking a engine oils all over the place. At the body shop, they found out that the the bottom part of the engine got cracked with a adult-fist size hole leaking engine oils all over the place. the owner of the body shop mentioned that it IS his first time to see the engine got cracked with such a big hole. it appears that the engine has a major defect and could have caused a major problem unless the driver quickly moved the car to the road side before it became completely disabled. I feel so lucky that it didn't happen while my wife or my daughters were driving, and it happened to me, while I was driving. only slightly over 100,000 miles and the engines got cracked, unbelievable.
- Suspension
TL* the contact owns a 2002 hyundai xg350. The contact stated that the vehicle was taken to the dealer to be repaired under nhtsa campaign number: 09v124000 (suspension); however, the dealer failed to repair the vehicle. The contact was given a buy back offer from the manufacturer, but declined the offer. The manufacturer was made aware of the issue. The contact had not experienced a failure. updated 03/15/16.*jb
- Fuel/propulsion system
TL* the contact owns a 2002 hyundai xg350. The contact received notification of nhtsa campaign number: 14v178000 (fuel system, gasoline). The contact stated that the recall remedy failed to repair the vehicle. The vehicle was taken back the dealer, who informed the contact that the recall remedy…
TL* the contact owns a 2002 hyundai xg350. The contact received notification of nhtsa campaign number: 14v178000 (fuel system, gasoline). The contact stated that the recall remedy failed to repair the vehicle. The vehicle was taken back the dealer, who informed the contact that the recall remedy was not performed on the vehicle. The specific on the failure were not available. The manufacturer was notified of the failure. The approximate failure mileage was 122,554.
- Air bags
In 2007, with a little over 50,000 miles on my car, the airbag light came on. I went in to the dealer and they said it was a loose wire and reset it. Since that time, I've had six other incidents up through 2014 with the airbag light coming back on and every time they've reset it, it has come back…
In 2007, with a little over 50,000 miles on my car, the airbag light came on. I went in to the dealer and they said it was a loose wire and reset it. Since that time, I've had six other incidents up through 2014 with the airbag light coming back on and every time they've reset it, it has come back on. I have even had a module replaced but it did no good. The last time I went in, they wanted to replace the pad assembly for $1,000 but wouldn't guarantee it would work. They also said it might be the harness but that part couldn't be obtained. They also said they couldn't guarantee that the airbags would work!!! I have looked at other complaints from several websites and see that there are dozens of other people with the same problem. This IS a serious defect and should be recalled. I have no airbags. My car has been in a minor traffic incident where the airbag probably should have deployed when the car hit the curb but didn't. This IS very dangerous. *tr
- Service brakes · Structure › Frame and members › Underbody shields · Suspension
Rear sub frame severe corrosion in critical suspension & frame mounting & attaching areas . And partial loss of braking system due to rupture of rear brake tube due to severe corrosion in rear frame area. *tr
- Air bags
Air bag warning light stays on. at first the light turned off but after a week it turned on and has remained on. repair shop said the air bags may deploy in an accident but not certain. *tr
- Electrical system · Engine
Driving on freeway on july 13, odometer drops to zero or bounces around, can't determine speed while driving, warning engine light turns on. 7/15/2013 dealer replaced sensors shopping on july 28, odometer drops to zero and warning engine light turns on 7/28/2013 dealer replaced sensors…
Driving on freeway on july 13, odometer drops to zero or bounces around, can't determine speed while driving, warning engine light turns on. 7/15/2013 dealer replaced sensors shopping on july 28, odometer drops to zero and warning engine light turns on 7/28/2013 dealer replaced sensors driving on freeway on october 6, odometer drops to zero 10/8/2013 dealer replaced odometer (mileage was 108,700) diving on freeway on november 2, odometer drops to zero, warning light turns on haven't decided what to do with car. *tr
- Fuel/propulsion system
Egr valve IS defective. After reading several forums, this part IS replaced a lot. *tr
- Fuel system, gasoline
TL* the contact owns a 2002 hyundai xg350. The contact stated that while attempting to refuel, the fuel spewed back out of the filler neck. The vehicle was taken to the dealer who diagnosed that the fuel valve was clogged with charcoal drops and as a result, the valves would need to be replaced and…
TL* the contact owns a 2002 hyundai xg350. The contact stated that while attempting to refuel, the fuel spewed back out of the filler neck. The vehicle was taken to the dealer who diagnosed that the fuel valve was clogged with charcoal drops and as a result, the valves would need to be replaced and the lines would need to be cleaned. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was out of warranty. The vehicle was repaired. The failure mileage was 82,000 and the current mileage was 83,718. updated 12/20/11*lj the dealer found the vent valve clogged with charcoal. They dropped the tank and cleaned the lines and replaced the fuel vent valve. Updated 03/12/12
- Tires
TL* the contact owns a 2002 hyundai xg350 equipped with bridgestone potenza G019 grid tires, size p205/60/r16. dot number wbxz190. The contact stated the vehicle was parked when she noticed that the sidewalls on all of the tires was cracking and the tread was worn. The vehicle was not taken to the…
TL* the contact owns a 2002 hyundai xg350 equipped with bridgestone potenza G019 grid tires, size p205/60/r16. dot number wbxz190. The contact stated the vehicle was parked when she noticed that the sidewalls on all of the tires was cracking and the tread was worn. The vehicle was not taken to the dealer to have the failure diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
- Air bags › Frontal · Air bags › Side/window
Hyundai motor corporation air bag wiring harness connector defect. numerous hyundai motor cars, xg350, sonata, etc. Have faulty connectors which prevent the airbag system from working. More than one dealer has stated in written service reports(available for review) the problems lie in a faulty…
Hyundai motor corporation air bag wiring harness connector defect. numerous hyundai motor cars, xg350, sonata, etc. Have faulty connectors which prevent the airbag system from working. More than one dealer has stated in written service reports(available for review) the problems lie in a faulty airbag wiring connector in the wiring harness. They reseat the plugs in the front seats and then they reset the 'computer' and the airbag warning light goes out, however it comes back on again after a short interval. This 'defect' applies to numerous models of hyundai cars. It IS dubious the system will work properly in the event it IS needed in an emergency. *tr
- Electrical system · Engine and engine cooling · Fuel system, gasoline
TL* the contact owns a 2002 hyundai xg350. The contact stated that the check engine light began to illuminate on the instrument panel while going through an automated car wash. The vehicle was taken to an authorized dealer where the contact was informed that the fuel tank canister needed to be…
TL* the contact owns a 2002 hyundai xg350. The contact stated that the check engine light began to illuminate on the instrument panel while going through an automated car wash. The vehicle was taken to an authorized dealer where the contact was informed that the fuel tank canister needed to be replaced. The vehicle was repaired. The failure had since recurred twice. The vehicle was taken back to the dealer on each occasion where it was repaired. The manufacturer was made aware of the failure, but offered no assistance. The failure mileage was unknown. Updated 08/31/11*lj the dealer replaced several components to rectify the engine light problem, but to no avail. The consumer also stated the ABS, tcb and air bag lights illuminated. The engine light IS still on. updated 09/09/11
- Structure › Frame and members
Deteriorated frame. *Tr
- Engine and engine cooling › Engine
2002 hyundai xg350 sudden acceleration when starting off from a stop. Car starts off slow then suddenly accelerates causing the car to lunge forward. Also, car will run smooth then start cutting out and can't get the car to go any faster than 40mph. Dealer has replaced several computer modules but did not cure the symptoms. *Tr
- Air bags · Suspension
TL* the contact owns a 2002 hyundai xg350. The contact stated when turning a corner at various speeds, the vehicle would lose traction. The vehicle was previously involved in a crash as a result of the failure. The contact had all four tires replaced in an attempt to correct the failure but to no…
TL* the contact owns a 2002 hyundai xg350. The contact stated when turning a corner at various speeds, the vehicle would lose traction. The vehicle was previously involved in a crash as a result of the failure. The contact had all four tires replaced in an attempt to correct the failure but to no avail. Most recently, the air bag warning light illuminated on the instrument panel. The dealer advised there was a shortage in the system. The vehicle was taken to a different dealer for a second opinion and was advised that the air bag possibly was not present in the vehicle. The failure mileage was 83,000 and the current mileage was 119,000.
- Steering
My 2003 hyundai power steering stops working properly anytime there IS standing water on the road and I drive thru the water, be it a puddle on the road or water that IS running on the road and cannot be avoided. The steering becomes very hard to control and at slow speeds can cause the motor to…
My 2003 hyundai power steering stops working properly anytime there IS standing water on the road and I drive thru the water, be it a puddle on the road or water that IS running on the road and cannot be avoided. The steering becomes very hard to control and at slow speeds can cause the motor to stall. I have had to replace the power steering pump and the problem IS not occurring but there have not been any substantial rains in the area to make a determination of that corrected the problem. I have written to hyundai motors with no reply. *Tr
- Service brakes, hydraulic · Vehicle speed control
Vehicle: 2002 hyundai xg350 sedan, equipped with ABS system and anti-skid device. events leading up to failure: since 2003, on three occasions the following happened- while driving at less than 5 mph, upon depressing the brake pedal the car accelerated. On the fist two occasions no damage…
Vehicle: 2002 hyundai xg350 sedan, equipped with ABS system and anti-skid device. events leading up to failure: since 2003, on three occasions the following happened- while driving at less than 5 mph, upon depressing the brake pedal the car accelerated. On the fist two occasions no damage occurred. The car stopped on hitting the car ahead. on the third occasion,in september 2009, there was extensive damage to the car and others. On this last occasion I have the impressing that my right foot was firmly depressing the brake pedal, not the accelerator. in speaking with computer specialists, I was informed that there may be a feedback problem in the computer control system. as far as I know the body damage to all cars has been repaired. *Tr
- Air bags
TL* the contact owns a 2002 hyundai xg350. the air bag warning light illuminates on the instrument control panel; which indicates that the air bags are inoperative. A technician from the dealer advised her to bring the vehicle to the dealer for diagnostic testing. She was in the process of having the vehicle inspected. The failure mileage was 92,000.
- Suspension
TL* the contact owns a 2002 hyundai xg350. during routine vehicle inspection the technician replaced defective stabilized bushings and tie rods. Also the sub-frame was replaced according to recall campaign ID number 09v124000 (suspension). The manufacturer was contacted in reference to…
TL* the contact owns a 2002 hyundai xg350. during routine vehicle inspection the technician replaced defective stabilized bushings and tie rods. Also the sub-frame was replaced according to recall campaign ID number 09v124000 (suspension). The manufacturer was contacted in reference to reimbursement. the manufacturer refused financial responsibility for the repair cost associated with the recall. The failure mileage was 50. the current mileage was 90,000. the vehicle identification number was unavailable.
- Air bags
Air bag light came on my 2002 hyundai xg350. Contacted the dealer I bought it from, and they checked it out for me and found... "Found code b1378 side airbag resistance too high, need to replace driver seat back." was told this was their 3RD from this dealer that needed replaced, and found out…
Air bag light came on my 2002 hyundai xg350. Contacted the dealer I bought it from, and they checked it out for me and found... "Found code b1378 side airbag resistance too high, need to replace driver seat back." was told this was their 3RD from this dealer that needed replaced, and found out from others that they have had the same situation. Was told due to the defect, could potentially cause the airbags to not deploy when in an accident. the light IS still on as the problem has not been fixed yet. I still have the seat, and looking at replacing it soon. *Tr
- Fuel system, gasoline
When attempting to fill fuel tank reading empty on gauge, tank keeps stopping like the tank IS full of gasoline, hyundai new port richey admits there IS an issue with the charcol canister and that charcol floats up the fill vent breather hose causing this issue and suggests that the canister be replaced. This start happening at 50K miles. *Tr
- Suspension › Rear
Left rear drivers side "thumping" noise as car neared the 60,000. Mile mark, it seems that this IS reported b y hyundai as a worn shock bushing which wear out naturally (hyundai's wording) and needs replacing, other friends having hyundais have gone well past 60K and have not had this issue, but we…
Left rear drivers side "thumping" noise as car neared the 60,000. Mile mark, it seems that this IS reported b y hyundai as a worn shock bushing which wear out naturally (hyundai's wording) and needs replacing, other friends having hyundais have gone well past 60K and have not had this issue, but we certainly will never purchase or recommend a hyundai to anyone, since everything seems to be the buyers issue according to hyundai. *Tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10196546Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicles owners manual. Use of other ATF may result in improper shift quality or other drivability conditions. Use of other DCT and IVT gear oil may result in reduced durability. Hyundai does not approve the use of any aftermarket ATF or gear oil additives.
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190038This bulletin provides best practice recommendations when performing brake service procedures.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10183963This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10178175This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes, or during normal driving operation.
- 10176182This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
- 10176178This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
- 10174808This bulletin provides information on identifying dealer stock vehicles with either: A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
- 10174807The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
- 10173546This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
- 10172142This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.
- 10170883This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bulletin provides physical differences between the USB 2.0 port and USB 3.0 port.
- 10169370The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the BSD/BCW zone and turns on the BSD/BCW warning lamp for the driver. The warning lamp starts blinking, along with an audible sound, when the driver turns on the turn signal lamp to enter the lane where another vehicle is driving.
- 10167253This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number.
- 10059631Summary to be provided on a future date.
- 10032908Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. Incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated; transaxle held in 3RD gear fail safe.
- 10030984Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). An improperly adjusted or improperly operating range switch may result in the above mentioned conditions. Malfunction indicator light (mil) illuminated; impossible engine start in p or n.
- 10020912Automatic transaxle diagnostic trouble codes (dtc) list.
- 10020878Exhaust gas recirculation (egr) system diagnosis.
- 10019638Oil leak at reduction brake piston cover.
- 10018734Reprograms are available for automatic transaxle driveability issues. Technet times. Hyundai.
- 10018184Automatic transaxle diagnostic trouble codes list.
- 10017993Diagnosing dtc p1159 ( variable intake target position).
- 10016301Electronic throttle system (ets) diagnostic trouble codes (dtc) update.
- 10015866Automatic transaxle diagnostic trouble codes list.
- 10014323Fd46xg poly alkylen glycol (pag) oil specifications for air conditioning component replacement.
- 100117982001-2005 xg300/350 p0171, p0174 (system too lean bank 1/bank 2).
- 10011790Diagnostic trouble code (dtc) p1178 -electronic throttle system (ets) motor power-open and p1118 (ets) motor.
- 10009777Fd46xg pag oil specifications for air conditioning component replacement.
- 10009152Unstable idle (simple diagnosis procedure for intermittently stuck closed egr solenoid valve).
- 100061762002-03 xg350 shudder or vibration during acceleration.*mr
- 10004614Battery cover information.
Every Hyundai XG350 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.