2023 Ic Bus EV
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2023 Ic Bus EV. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2023 Ic Bus EV. Newest first.
Navistar, Inc. (Navistar) is recalling certain 2022-2024 IC Bus CE, 2022-2023 IC CE SBus, IC RE, and 2023 EV school buses. The roof panel may have been manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Risk and remedy
Risk
A school bus roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Remedy
Dealers will add additional fasteners to secure the joints, free of charge. Owner notification letters are expected to be mailed April 3, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23501.
Navistar, Inc. (Navistar) is recalling certain 2023 IC RE, IC EV, and 2023-2024 IC CE school buses. The fasteners that connect the transverse torque arm to the rear axle housing may have been tightened incorrectly, which can allow the rear axle to shift side to side.
Risk and remedy
Risk
A rear axle that moves side to side can cause a loss of handling and control, increasing the risk of a crash. In addition, a loose rear axle may cause vehicle instability during an evacuation in an emergency, increasing the risk of injury.
Remedy
Dealers will replace and tighten the fasteners, free of charge. Owner notification letters are expected to be mailed February 6, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 22527.
Navistar, Inc. (Navistar) is recalling certain 2023 IC CE, EV, and RE vehicles. The hex flange lock nuts, used in the suspension and steering joints, were improperly heat treated and may lose tension over time.
Risk and remedy
Risk
A loss of tension in the steering and suspension joints may lead to steering instability and increase the risk of a crash.
Remedy
Dealers will replace the hex flange lock nuts as necessary, free of charge. Owner notification letters are expected to be mailed January 20, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 22525.
Navistar, Inc. is recalling certain 2022-2023 IC EV school buses. The high voltage positive cables that connect the battery packs to the manual service disconnects (MSD) may have been mislabeled.
Risk and remedy
Risk
A misidentified electrical cable may be mistaken for a de-energized cable by a technician or first responder, increasing the risk of electrical shock and injury.
Remedy
Dealers will reinstall the battery cables and replace the associated warning labels, free of charge. Interim owner notification letters were mailed January 13, 2023. Remedy parts are expected to become available in the 1st Quarter of 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 22523.
Navistar, Inc. is recalling certain 2022-2023 IC CE, IC RE, and 2023 IC EV school buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.
Risk and remedy
Risk
A loose or detached steering wheel increases the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters were mailed on May 25, 2022. Owners may contact Navistar, Inc. customer service at (331) 332-1590. Navistar's number for this recall is 22511.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008338Certain IC Bus Electric CE Series buses may have incorrect coolant hose routing for the cabin heat which may cause coolant to leak from the cabin heat surge tank overflow hose
- 11000879This document AC circuit overcurrent causing Level 2 AC charger failires
- 10251418CE EV and eMV Calibration Release information
- 10246236EV CE Bus Electric Heater Fuse Inspection and Heater Control Adjustment
- 10246235Cabin Heat Coolant Over Boil with fault SPN 5574 FMI 7
- 10246234Servicing Air Conditioning Systems on Electric Vehicles
- 10246231J1939 Data Link Source Address Information
- 10243605Bus seat back foam inspection guidelines
- 10243596General Wheel Speed Sensor Troubleshooting
- 10243595Diagnosis of chassis wander complaints.
- 10241561SDS EV Battery Health Session
- 10241560Luggage rack upholstery repair; only busses equipped with luggage rack.
- 10241555J1939 Data Link Source Address Information
- 10241554J1939 Data Link Troubleshooting
- 10241553These certain buses may have roof water leaks resulting from incorrect assembly described in Roof Joint Recalls 23501 and 23502.
- 10241552Certain International eMV Series trucks and IC Bus Electric CE Series school buses may have been built without charge port warning label, high-voltage warning label, and 12 volt disconnect warning label.
- 10240200SDS EV OCI charging session instructions
- 10240198SDS EV Signal Monitor CAN logging session instructions
- 10238864Power Electronics and Cabin Heat Cooling system Fitting Leaks
- 10238863Air Conditioning Shuts Off During Full Throttle
- 10237479N2 telematics module not communicating with OCC systems. Only models built with feature codes 10ADT, 10AEY, 10AEU, 10AEZ, 10AGB, or 10AGC built from 04/04/2019 through 11/01/2022.
- 10236049Electric Vehicle high voltage battery diagnostics
- 10234026Electric Vehicle Coolant Pipe Contact CE EV buses only
- 10234024Electric Vehicle Windshield Fogging CE EV Buses only
- 10227455J1939 Data link source address information
- 10227425Certain electric buses may have been built without the Level 2 Manual Service Disconnects (MSDs). This document will walk the user through installing the Level 2 MSDs and high-voltage circuits needed.
- 10227423Certain EV Series vehicles may have been built with incorrect MSD removal instruction labels.
- 10222490Pico Scope CCOS (Crankcase Separator Test)
- 10219332Electric Vehicle Charging Concerns
- 10219330PicoScope Test One Channel RCT
- 10213198The steering wheel retaining nut may not have been torqued properly during assembly and may allow the steering wheel to loosen, and possibly separate from the steering column shaft.
Every Ic Bus EV model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.