2001 International Harvester 1000
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › International Harvester › 1000 › 2001
These records cover every 2001 International Harvester 1000. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2001 International Harvester 1000. Newest first.
Certain heavy duty trucks, truck tractors, and buses equipped with 195/75r22.5 tires mounted on 7.5 inch wide wheels fail to comply with requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." these tires and rims do not match.
Risk and remedy
Risk
Tires mounted on rims that are too narrow could experience a decrease in sidewall durability, and could also experience higher treadwear for tires mounted on the steering axle.
Remedy
Dealers will install new rims of an acceptable width (8.25 - 9 9inches) for the 295/75r22.5 tire size. owner notification began august 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10057203Iknowbase: maxxforce dt,9&10 electric fuel pump& system tips: these engines use a fuel module that provides differnet features. Updated 8/14/15.
- 10057202Iknowbase:big bore 13L hp turbocharger center section replacement procedure: instructions provided on replacing the hp turbo charger. If performing repairs please ref. Ik1201073.
- 10057201Iknowledge base: turbo charger oil supply tube retrofit REV2: the new turbo charger line has routing & clipping in which could interfer with the ccolant hoses.
- 10057200Iknowledge base: turbocharger oil supply tube retrofit: to resolve oiling concerns a new turbocharger supply tube has been developed. The old turbocharger supply IS removed.
- 10057199Iknowledge base: experiencing low pressure fuel system failure applies to emissions maxxforce 11,13, 15L 2013 N13 with scr. Updated 8/14/15. Updated 9/15/15
- 10057198Iknowledge base: big bore intake air temperature/ cacot sensor damaged: prostar+trucks with 2010 emissions maxx force have interference issues with the charge air cooler.
- 10057197Iknowledge base: spn3055 troubleshooting: signal from the fuel rail pressure sensor will set the fault code. When step by step IS taken. Updated 09/01/2015 updated 9/16/15 updated 02/19/2016
- 10057196Iknowledge base: software : complaints and concerns of hard start/ no start and rough idle with cpa tool. Updated 7/20/15 updated 9/16/15 updated 2/22/16
- 10057195Iknow: medium duty(i6) high pressure turbo center replacement procedure: the replacement of the turbo charger assembly can be time consuming, a new procedure have been developed in which applies to 2010 and newer medium duty I6 engines.
- 10057192Iknow international: charge air cooler: a leak test IS required for the charge air cooler when a complaint has been made regarding the low engine. Updated 9/14/15
- 10057191Iknow international: instructions are provided for replacing the HD94 bearing cap seal on sheppard steering gears. Leaking appears of the HD94 gears & the main body & bearing cap.
- 10044292International: after lining condition and wear, fastener torque, component lubrication have been verified on the brakes because of the chatter or squealing on the trucks, a procedure will be performed. No model or model years are listed. Updated 12/20/13.
- 10044291International: procedure information to resolve issue of overheating and smoking of low mileage, single wheel end brake. Updated 11/4/14. Updated 1/27/15. Updated 1/30/15.
Every International Harvester 1000 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.