2006 Isuzu I-280
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Isuzu › I-280 › 2006
These records cover every 2006 Isuzu I-280. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2006 Isuzu I-280. Newest first.
Gm IS recalling 185,903 model year 2004-2009 colorado, GMC model year 2009-2004 canyon, model year 2006 I-280, I-350, model year 2007-2008 I-290, and I-370, passenger vehicles originally sold in or currently registered in the states of alabama, arizona, florida, georgia, hawaii, louisiana, mississippi, nevada, new mexico, puerto rico, south carolina, texas…
Risk and remedy
Risk
This condition could cause the simultaneous loss of all brake lamps or cause all of the brake lamps to stay on continuously. Both of these conditions could fail to warn others of the driver's intentions and could lead to a vehicle crash.
Remedy
Dealers will inspect and replace the necessary components as specified in the recall bulletin free of charge. gm anticipates that parts will be available by june 2010. A special coverage for vehicles registered in all other states will be implemented in the same time frame. In the interim, owners who experience the failure can obtain a free repair, however they will be required to return when the new design part becomes available. owners may contact chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, isuzu at 1-800-255-6727 or at www.gmownercenter.com.
Certain pickup trucks may experience the permanent loss of brake lamp function or brake lamps that are illuminated at all times. the center high-mounted stop lamp (chmsl) IS affected in both instances. also, if equipped, the cruise control will become inoperative. any trailer brake lamps which are connected to the vehicle's brake lamp wiring will mimic…
Risk and remedy
Risk
A following driver may not know when the brakes have been applied, and a rear-end crash could occur without prior warning.
Remedy
Dealers will replace the brake lamp switch assembly. the recall began on december 5, 2006. owners may contact chevrolet at 1-800-630-2438; GMC at 1-866-996-9463 or isuzu at 1-800-255-6727.
Owner complaints
11 complaints
What owners report most
Latest complaints
- Exterior lighting · Unknown or other
Couple of wks. Ago I had to replace front left hub wheel assembly which affected drive shaft, ABS, emer. Brake. That was fixed . Now tonight driving from a friends I hear a clicking noise sounds like underneath gear box or behind heater what IS it. Also interior lights turn control & have to hit…
Couple of wks. Ago I had to replace front left hub wheel assembly which affected drive shaft, ABS, emer. Brake. That was fixed . Now tonight driving from a friends I hear a clicking noise sounds like underneath gear box or behind heater what IS it. Also interior lights turn control & have to hit around light for it to turn on, and around facing of heater to illuminate heater controls! What's going on? This only happened in gear not in neutral.highway & city.
- Fuel/propulsion system
Strong odor of gasoline coming from truck. Leak appears to be coming from the top of the tank. There are many complaints of the same issue with the chevy colorado pickups and a few of the same issue with the isuzu I280. I did replace the gas cap, but that did not solve the problem. my next…
Strong odor of gasoline coming from truck. Leak appears to be coming from the top of the tank. There are many complaints of the same issue with the chevy colorado pickups and a few of the same issue with the isuzu I280. I did replace the gas cap, but that did not solve the problem. my next step will be removing the tank and repairing the faulty part (leaking gasoline). With all the online complaints of the same issue, I would think that there should've been a recall issued. I did contact isuzu, but they report no such recall. I then contacted chevy to see if they had a recall on the colorado (same truck, different badge) but they wouldn't tell me if there was a recall for that problem. Chevy informed me that they can only trace recalls through a vin number and despite the fact that my I280 IS a gm product, their list of recalls couldn't be searched using my vin number. the gasoline odor IS quite strong, but will dissipate when the vehicle IS left sitting (not running) for a couple of days. The odor can still be detected after several days of not using the vehicle - it's just faint. I believe this issue IS quite dangerous and possibly due to either faulty parts or a faulty design. The fact that there are numerous complaints, regarding the exact same issue, suggests that the problem IS widespread and due to a faulty part or design.
- Exterior lighting
TL* the contact owns a 2006 isuzu I-280. The contact stated that the brake lights failed without warning. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 196,000. The vin was not available.
- Air bags · Electrical system · Seat belts
Drivers side air bag warning light has turned on and remains on permanently. Questionable if airbags will deploy. No accidents in vehicle or any other incident that might in some way lead to damage to air bags, electrical system, seat belt connections, etc. *tr
- Electrical system
TL* the contact owns a 2006 isuzu I-280. The contact stated that the vehicle failed to start and the security pass lock warning indicator illuminated on the instrument panel. After waiting ten minutes, the engine resumed normally. The failure recurred numerous times. The vehicle was taken to an…
TL* the contact owns a 2006 isuzu I-280. The contact stated that the vehicle failed to start and the security pass lock warning indicator illuminated on the instrument panel. After waiting ten minutes, the engine resumed normally. The failure recurred numerous times. The vehicle was taken to an authorized dealer for diagnosis however, the diagnostic computer was unable to generate a failure code. The vehicle was not repaired. The manufacturer was notified of the defect. The approximate failure mileage was 50,000.
- Electrical system
Tl*the contact owns a 2006 isuzu I280. The contact stated that the anti theft lock device would not allow the contact to start the vehicle. the contact had to wait over 20 minutes for the engine to operate, which caused the interior lights to dim. the dealer was notified of the issue who offered…
Tl*the contact owns a 2006 isuzu I280. The contact stated that the anti theft lock device would not allow the contact to start the vehicle. the contact had to wait over 20 minutes for the engine to operate, which caused the interior lights to dim. the dealer was notified of the issue who offered no assistance. The manufacturer was also notified who advised the contact that the vehicle was outside of warranty and provided no assistance. the failure mileage was 49,600 and the current mileage was 54,000. updated 8/8/12 *cn the consumer stated in read in the owners manual, where the passlock anti-theft device could cut off the fuel and not allow the engine to start, as something was tripping it. After a month of constant problems, he discovered his wife's car key to her new vehicle that he was carrying in his pocket was tripping it. He stated he stopped carrying the key and noticed the problem lessened.
- Electrical system · Exterior lighting · Unknown or other
Complete loss of brake lights / cruise control / keeps blowing fuses. learned of recall ID # 52989 dated 7/29/2009 - so I took vehicle to dealer ( courtesy GMC - 205.836.2000 ) their service manager sent me away - said truck had recall #06030 performed on 11/27/2006. I had a trusted mechanic I…
Complete loss of brake lights / cruise control / keeps blowing fuses. learned of recall ID # 52989 dated 7/29/2009 - so I took vehicle to dealer ( courtesy GMC - 205.836.2000 ) their service manager sent me away - said truck had recall #06030 performed on 11/27/2006. I had a trusted mechanic I know check brake light switch ( which checked out ok ) replaced it anyway with new one purchased at dealer. Brake lights worked 5 minutes then blew fuse again. my mechanic told me that the brake light switch wiring from previous recall was a bad job - not done by a pro.
- Exterior lighting · Service brakes, hydraulic
TL* the contact owns a 2006 isuzu I280. While driving approximately 25 mph, the ABS warning indicator illuminated and a message displayed faulty brakes on the instrument panel. In addition, the brakes would make a grinding noise when depressed. There was a recall related to the defect under nhtsa…
TL* the contact owns a 2006 isuzu I280. While driving approximately 25 mph, the ABS warning indicator illuminated and a message displayed faulty brakes on the instrument panel. In addition, the brakes would make a grinding noise when depressed. There was a recall related to the defect under nhtsa campaign ID number 06v139000 (exterior lighting: brake lights: switch); however, the vin was not included in the recall defect. The contact was in the process of notifying the manufacturer. The failure mileage was unavailable.
- Engine and engine cooling
Tl*the contact owns a 2006 isuzu I-280. while driving 25 mph, the vehicle shut off in the middle of traffic. after a few minutes, the engine restarted. in addition, the vehicle idled roughly. the contact took vehicle to auto zone for diagnostic testing and was informed that the exhaust…
Tl*the contact owns a 2006 isuzu I-280. while driving 25 mph, the vehicle shut off in the middle of traffic. after a few minutes, the engine restarted. in addition, the vehicle idled roughly. the contact took vehicle to auto zone for diagnostic testing and was informed that the exhaust crankshaft position caused the engine to shut off while driving. the dealer advised the contact to replace the engine because it was faulty. the contact feels that the manufacturer should pay for the repair. the current mileage was 114,000 and failure mileage was 80,000.
- Tires
(1) side wall / tread wear (2) & (3) tire rotation of unworn tires, unworn tires also began to wear after rotation. *Jb
- Suspension › Front
Dt*: the contact stated while driving 40 mph, the vehicle became hard to steer. it was taken to the dealer who found the front passenger tire was worn on the inside and determined the factory specifications were off. *Ak
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Brake lamp switch malfunction
On july 28,2009, gm initiated a regional recall campaign on certain model year (my) 2004-2009 chevrolet colorado and GMC canyon vehicles and my2006-2008 isuzu i-series vehicles.the states and u.s. Territories involved are al, az, fl, ga, hi, la, ms, NV, nm, pr, sc, tx, vi and ut.a total of 185,903 vehicles will be…
On july 28,2009, gm initiated a regional recall campaign on certain model year (my) 2004-2009 chevrolet colorado and GMC canyon vehicles and my2006-2008 isuzu i-series vehicles.the states and u.s. Territories involved are al, az, fl, ga, hi, la, ms, NV, nm, pr, sc, tx, vi and ut.a total of 185,903 vehicles will be recalled with 92,272 vehicles within the scope of this investigation.in addition, a special coverage/extended warranty program will be initiated forvehicles registered in all other states. Gm determined that brake lamp switch failures are more likely to occur in vehicles in which customers used interior cleaners containing silicon and that reside in hot geographical locations.brake lamp switch contamination failure can cause loss of the brake lamps or the brake lamps to stay on continuously, increasing the risk of rear-end crashes.gm has reported no crashes or injuries due to the failure of the brake lamp switch.odi initially reported one crash incident, but later downgraded the report due to the absence of actual property damage or cost incurred when the vehicle was lightly tapped from behind at low speed.this investigation IS closed (see recall campaign 09v0310).
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10237146This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.
- 10218932Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form
- 10218927Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.
- 10217004The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.
- 10217001The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.
- 10177599These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10177598These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10041246Isuzu service campaign: see document search button for owner letter. 2006-2008 I series. Loss of brake lights or continuous illumination. There could be contamination of the brake light switch.
- 10025184Wipers cycle several times, then park in the middle of the windshield.
- 10022634Information on 2-3 up-shift or 3-2 downshift clunk noise IS heard.
- 10021659Safety belt locking conditions.
- 10021585Prndl display reduced visibility for approximately one minute.
- 10021356Various driveability symptoms due to clogged fuel injectors, mil dtc's p0171, p0172, p0174, p0300, p1174, and p1175. Updated 08-03-07.
- 10021354Malfunction indicator lamp (mil) on, diagnostic trouble code (dtc) p0894, harsh 1-2 shift with 4l60-e auto transmission.
- 10021196Reduced engine power mil illuminated.
- 10021012Diagnostic trouble code (dtc) p0757 set, malfunction indicator lamp (mil) illuminated, poor performance of transmission, transmission slipping.
- 10021008Distortion in outer surface of vehicle glass.
- 10021007Passenger occupant sensing system concerns with custom upholstery, accesory seat heaters or other comfort enhancing devices.
- 10021006Tire characteristics of original equipment tires.
- 100205374L60-e automatic transmission fluid leak from oil pump or bell housing area.
- 10020344Revised pressure relief valve replacement (service manual revision).
- 10020343Information regarding automatic transmission shift lock control function.
- 10020162Info on close-coupled converter, engine breakdown or non-function due to severe overheat or lack of oil causing engine failure.
- 10019792Diagnostic tips for automatic transmission dtc p0756.
- 10019775Availability of pickup box reinforcements to accommodate aftermarket accessory tool box installation.
- 10019627Door latch freezing in cold temperatures.
- 10019158Eliminating unwanted odors in vehicles.
- 10019116Revised park brake fastener tightening specification (service manual revision).
- 10018842Diagnostic trouble code (dtc) p0757 set, malfunction indicator lamp (mil) illuminated, poor performance of transmission, transmission slipping.
- 10018714I/m readiness as part oe emission inspection and maintenance program for obd II vehicles. To include isuzu I-280 and I-350 2003 - 2005.
- 10018686Malfunction indicator lamp (mil) on, transmission stuck in second or third gear, instrument cluster inoperative (verify and repair source of voltage loss in transmission solenoid power supply circuit.
- 100186824L60 automatic transmission diagnostic information on harsh 1-2 upshift.
- 10018649Malfunction indicator lamp (mil) on, transmission stuck in second or third gear, instrument cluster inoperative (verify and repair source of voltage loss in transmission solenoid power supply circuit).
- 10018590Information on use of kent moore bolt extractor tool kit en-47702 for removing cylinder head or main bearing cap bolts on inline engines.
- 10017621Engagement time of electronically controlled 4l60-e transmissions.
- 10016407Passenger seat belt buckle hard to move past stitching and/or finish knot IS fraying.
- 10014789Diagnosis of crack or broken transmission case.
- 10009723Diagnostic information on diagnostic trouble code p0894 and p1870.
- 10008409Diagnostic tips for diagnostic trouble code (dtc) p0756 2-3 shift valve performance.
- 10006653Information on 2-3 up-shift or 3-2 downshift clunk sound.
Every Isuzu I-280 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.