2005 Itasca Suncruiser
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Itasca › Suncruiser › 2005
These records cover every 2005 Itasca Suncruiser. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2005 Itasca Suncruiser. Newest first.
Winnebago IS recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor…
Risk and remedy
Risk
The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Remedy
Winnebago IS working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall began during december 2010. owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Winnebago IS recalling 2,331 my 2002-2004 brave and itasca sunrise my 2005 2006 winnebago voyage, adventurer, itasca sunrise and suncruiser motor homes. the propane tank mounting bracket may have an incomplete or improper weld.
Risk and remedy
Risk
Should the weld fail, the propane tank can tip or fall, possibly releasing propane which has the potential to ignitea fire, resulting in personal injury and/or vehicle and property damage.
Remedy
Dealers will inspect and properly weld the bracket free of charge. the recall IS expected to begin during may 2009. owners may contact winnebago at 800-537-1885.
On certain motor homes, the roof vent for the optional 4-door refrigerator was incorrectly located.
Risk and remedy
Risk
This can allow excessive heat buildup which has the potential to ignite surrounding materials, resulting in personal injury and/oi vehicle and property damage.
Remedy
Dealers will relocate the roof vent. the recall began on september 9, 2005. owners may contact winnebago at 1-641-585-6939.
Certain motor homes built on 24,000-lb gross vehicle weight rating (gvwr)workhorse chassis with 235/80r22.5g xrv tires fail to comply with the requirements of federal motor vehicle safety standard no. 120, 'tire selection and rims for motor vehicles other than passenger cars.' the motor homes were inadvertently equipped with an incorrect load range tire…
Risk and remedy
Risk
Failure to follow proper vehicle loading specifications and tire inflation recommendations can result in tire damage and vehicle instability, which could result in a crash.
Remedy
Owners will be mailed supplementary tire labels containing the correct tire inflation information. if an owner desires, their dealer can install the label for them. the recall began on march 24, 2005. Owners may contact winnebago at 641-585-6939.
On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
Risk and remedy
Risk
Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. the fuel line will be inspected and, if necessary, replaced. the recall began january 7, 2005. owners should contact winnebago at 1-800-537-1885.
Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Risk and remedy
Risk
The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
Remedy
Dealers will replace the buckles. the recall began on november 12, 2004. owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.
Owner complaints
5 complaints
What owners report most
Latest complaints
- Service brakes
While driving my itasca suncruiser motorhome to cobb & son rv repair I noticed I was unable to maintain normal speed. Arrived at cobb and explained to ritchie cobb the problem I was having. Ritchie had a tech measure the heat at the brakes and they were at 900 degrees. Informed recall from…
While driving my itasca suncruiser motorhome to cobb & son rv repair I noticed I was unable to maintain normal speed. Arrived at cobb and explained to ritchie cobb the problem I was having. Ritchie had a tech measure the heat at the brakes and they were at 900 degrees. Informed recall from workhorse regarding a brake issue and that the vehicle would have to be driven to an authorized workhorse dealer for repair (100 miles away). Ritchie explained this could not be done as the vehicle was unsafe to drive and there would be serious risk of injury and even further damage as the pads were worn and crystallized, calipers bad, and the brake failure have created serious grooves in the rotors. Additionally the brakes had already gone into locking up mode. Ritchie said the remedy was replacement of all this parts on all 4 brakes because of damage caused by the recall issue. Astounded that workhorse said I would have to drive the vehicle to their dealer facility(100 miles away), I personally called workhorse. I got the same answer from customer service, then the head of customer service, then thirdly from carl dahl their regional manager. I refused to risk driving the vehicle and had to have it towed at my expense as workhorse refused to do so. My next surprise was that workhorse would not replace rotors, pad, etc., even though their recall issue caused all the damage. A policy to tell someone to drive an unsafe vehicle and then they would tow it when I break down on the side of the road IS insane and irresponsible. Further they are ignoring their responsibility to repair all the damage that was caused by their recall. I have now had to pay over $1,100 to restore my brakes, pay for towing, and drive 200 miles to pick up my motorhome. I need your assistance to persuade workhorse to do the ethical and honorable thing and reimburse all the money I have spent. *js
- Service brakes, hydraulic
On november 10, 2011 I was having recall #51101-c completed on my motor home. the mechanic had the brakes apart to replace the bosch brake calipers and he discovered all four rotors had 2 -3 cracks on the outside plate. the cracks started on the outside edge and radiated in about 2 inches. the…
On november 10, 2011 I was having recall #51101-c completed on my motor home. the mechanic had the brakes apart to replace the bosch brake calipers and he discovered all four rotors had 2 -3 cracks on the outside plate. the cracks started on the outside edge and radiated in about 2 inches. the cracks were completely through the plate. workhorse refused to admit the cracked rotors might have something to do with the bad calipers or a manufacturing defect. they suggested the cracks were caused by driver error. for example, riding the brakes down a mountain or towing a car without auxiliary brakes. *tr
- Engine and engine cooling › Engine › Gasoline › Belts and associated pulleys
Driving on route 281 from brownsville tx. To san antonio tx. In my 2005 itasca suncruiser. At about 65 mph my vehicle started to drift on the road. Trying to correct it I found I had no steering...i put on my brakes and found I had no brakes. I was scared and did not know what to do. The dash…
Driving on route 281 from brownsville tx. To san antonio tx. In my 2005 itasca suncruiser. At about 65 mph my vehicle started to drift on the road. Trying to correct it I found I had no steering...i put on my brakes and found I had no brakes. I was scared and did not know what to do. The dash instruments showed alternator problems. Engine problems..etc...i felt death was near...i took my foot of the gas to let it slow down and stop...praying nothing would get in front of me as I had no control...water and steam blew out over the window and things seemed to be getting worse. I stopped after an eternity. I had the rv towed off the road and was told that my engine belt broke....i am amazed that the rv had no back up system for steering or braking or anything...i am happy that I killed no one or caused a tragic accident. A new belt was put on the engine and I was told it probably wouldn't happen again..i ask about the safety of my 2005 itasca suncruiser ( 30000 lbs gw ) and was amazed no one thought anything of it....no one killed or maimed so who cares...maybe when someone IS injured someone will do something. updated ivoq 12/01/10 *tr
- Fuel system, gasoline › Storage › Tank assembly
Gas tank leaking. *jb
- Electrical system
Dt*: the contact stated there was a smell of something overheating in a reclining couch within the coach. the vehicle had a switch used to disconnect the power to the living area of the motor home. the switch was tripped, and the contact reached in to the motor area of the seat. the motor was…
Dt*: the contact stated there was a smell of something overheating in a reclining couch within the coach. the vehicle had a switch used to disconnect the power to the living area of the motor home. the switch was tripped, and the contact reached in to the motor area of the seat. the motor was exceedingly hot, so the contact allowed it to cool. 2 months later, the motor was removed and examined to find melted wiring and melted brushes. a service dealer was contacted, who was unable to determine the problem. the frame of the couch was manufactured by shrock manufacturing incorporated. updated 2/12/2007 - the problem was traced to sticking switch installed by winnebago industries. the switch occasionally became stuck in the retract position. shrock, manufacturer of the coach frame, replaced motor but cautioned that the switch IS a problem. *nm
Every Itasca Suncruiser model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.