2018 KIA Redundant Niro

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10238225TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR - ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
• 10237607PITSTOP: SHARING KIA CONNECT CREDENTIALS WITH THIRD-PARTY APPS AND POTENTIAL IMPACT TO 12V BATTERY IN EVS - Kia is aware of reports of unexpected drainage of the 12-volt battery in some Kia electric vehicles (EVs). While Kias investigation is ongoing, a possible cause of the issue may be third-party applications used by the customer that are causing excessive Kia Connect connections to the customers EV.
• 10237139TECHNICAL SERVICE BULLETIN: OVERHEAD CONSOLE SUNGLASS DOOR-LATCH REPAIR - This bulletin provides information to repair the overhead console lamp assembly and sunglass door latch on some 2012-2023MY model vehicles listed in the table below, which may encounter the sunglass case of the overhead console lamp not closing properly.
• 10226555TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
• 10202227TECHNICAL SERVICE BULLETIN: REPLACEMENT OF MOBIS C-MDPS SMALL BEARING - This bulletin provides the procedure to replace the small bearing of the Column Motor Driven Power Steering (C-MDPS) unit on the vehicles listed below, which may exhibit an abnormal noise when steering left and right. This may be caused by foreign substances in the MDPS worm shaft small bearing. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Small Bearing and does not affect the steering effort.
• 10202226TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
• 10201529TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
• 10200550TECHNICAL SERVICE BULLETIN: FRONT VIEW CAMERA REPLACEMENT FOR DTC C160449 & C160649 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on the inspection and replacement of the front camera on some vehicles. Due to an internal control chip concern inside the camera, the vehicle may exhibit a Forward Collision Avoidance Assist Warning Lamp (A) and/or Master Warning Lamp (B) with C160449 and/or C160649 codes. Certain systems may become temporarily disabled during occurrences: Smart Cruise Control (SCC), Lane Keep Assistance (LKA), Lane Departure Warning (LDW), Forward Collision-Avoidance Assist (FCA), Forward Collision Warning (FCW) and/or Driver Attention Warning (DAW).
• 10200525PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
• 10195049PIT STOP: A/C DYE FOR E-COMPRESSOR EQUIPPED VEHICLES - This bulletin provides information on the proper non-conductive A/C system leak detection dye to be used in all EV, HEV, and PHEV models equipped with an electric A/C compressor.
• 10185035TECHNICAL SERVICE BULLETIN: 6-SPEED DOUBLE CLUTCH OR DCT REPLACEMENT - This bulletin provides the procedure to replace the Double Clutch set or Double Clutch Transmission (DCT) assembly on some 2018-2019MY Niro (DE HEV, DE PHEV) vehicles, equipped with the 6-Speed DCT, which may exhibit an abnormal Grrrr and/or grinding noise when down shifting from 4th to 3rd gear.
• 10179256TECHNICAL SERVICE BULLETIN: IBAU SYSTEM REPAIR FOR NOISE AND AIR BLEEDING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the repair procedure for the Integrated Brake Actuation Unit (iBAU) system on some 2014-2019MY EV/Hybrid/Plug-In Hybrid vehicles listed (see table), which may exhibit a "honking" (Hissing) noise due to air remaining in the brake fluid system.
• 10179232TECHNICAL SERVICE BULLETIN SERVICE ACTION: IN-CABLE CONTROL BOX PROTECTION COVER INSTALLATION (SA425) - This bulletin provides information on the installation of the In-Cable Control Box (ICCB) / Level 1 Charge Cord protection cover on some Niro (PHEV/EV) vehicles listed below, in order to protect the ICCB from impact which can easily cause damage.