2020 KIA Sorento

Recalls

1 recall names the 2020 KIA Sorento. Newest first.

• Trailer hitches

  Sep 19, 2022NHTSA 22V70300070,887 vehicles

  Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module…

  Risk and remedy

  Risk

  A fire while parked or driving can increase the risk of injury.

  Remedy

  Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

  Full recall details →

Owner complaints

What owners report most

1. Engine67
2. Unknown or other26
3. Electrical system20
4. Power train18
5. Fuel/propulsion system10
6. Trailer hitches9
7. Forward collision avoidance6
8. Exterior lighting5
9. Service brakes5
10. Vehicle speed control5

Latest complaints

• Oct 24, 2026MOCrash
  Unknown or other · Vehicle speed control
  **Suspected Sudden Unintended Acceleration – 2020 Kia Sorento EX V6** On October 24, 2026, the driver of a 2020 Kia Sorento EX V6 experienced two episodes of suspected sudden unintended acceleration. The vehicle reportedly accelerated unexpectedly while in Reverse (R), causing it to collide with…

  **Suspected Sudden Unintended Acceleration – 2020 Kia Sorento EX V6** On October 24, 2026, the driver of a 2020 Kia Sorento EX V6 experienced two episodes of suspected sudden unintended acceleration. The vehicle reportedly accelerated unexpectedly while in Reverse (R), causing it to collide with an apartment building. Following the initial collision, the driver shifted the transmission into Drive (D), at which point the vehicle reportedly accelerated forward unexpectedly. According to the driver, both incidents occurred so quickly that she was unable to apply the brakes. The collision caused significant damage to the apartment building, including structural damage requiring reinforcement, and damaged two other vehicles. The airbags did not deploy. No injuries to the driver have been reported. The driver also recalls receiving a previous recall notice for a vehicle component that was not repaired. The specific recall has not yet been identified. The vehicle has been towed and is being preserved for a potential independent investigation, including examination of the Event Data Recorder (EDR). We request that NHTSA review this incident as a possible vehicle safety defect. The cause of the unexpected acceleration has not yet been determined.

• Oct 22, 2026TX
  Engine
  I bought a used 2020 Kia Sorento LX 2.4L in 2022. It had 15,000 miles on it. AT 50,000 miles I noticed it was consuming oil. I have been changing the oil at 5,000 mile intervals even though the manual calls out to do it every 7,500 miles. I have records of the maintenance for every oil change done…

  I bought a used 2020 Kia Sorento LX 2.4L in 2022. It had 15,000 miles on it. AT 50,000 miles I noticed it was consuming oil. I have been changing the oil at 5,000 mile intervals even though the manual calls out to do it every 7,500 miles. I have records of the maintenance for every oil change done on this vehicle. I kept a log and now at 54,740 miles it is consuming 1 quart every 500 miles or so. I took it to the dealer on 10/19/2026 and was told that since I was not the original owner there was no warranty coverage on it. So that nullified the 10 year/100,000 mile warranty. I was told they could do a chamber cleaning for $800.00 and if that failed I would need to replace the engine at an out of pocket cost to me of $9,000.00 to $10,000.00 I have to monitor the oil level constantly to avoid the engine seizing and breaking down in traffic . This auto is used by my spouse to drive my grand kids to and from school. There are no warnings or messages on the oil level so it is driven with uncertainty .

• Oct 17, 2026NJ
  Unknown or other · Visibility/wiper
  This incident occurred on 10/03/26 at approx. 11:45 AM. Location: Squankum-Yellowbrook Rd. (524A) Howell NJ. Temp: 73 F. Road condition: 2 lane rural clear and dry. Description of incident: While driving @ approx. 40 MPH with no on-coming or traffic ahead or behind, the entire right rear…

  This incident occurred on 10/03/26 at approx. 11:45 AM. Location: Squankum-Yellowbrook Rd. (524A) Howell NJ. Temp: 73 F. Road condition: 2 lane rural clear and dry. Description of incident: While driving @ approx. 40 MPH with no on-coming or traffic ahead or behind, the entire right rear passenger window spontaneously imploded, explosively showering the entire rear seat with glass shards. Upon immediately pulling off the road and upon my own examination (and shortly thereafter by responding police) no impact object that could have caused the glass breakage was found. Had there been rear seat passenger(s) at that time undoubtedly that person(s) would have sustained head/face or eye injuries.

• Oct 7, 2026OH34,000 mi
  Engine
  The contact owns a 2020 Kia Sorento. The contact stated that while driving, there was an abnormal banging sound coming from under the hood of the vehicle and the vehicle shuddered abnormally. The contact stated that the Forward Collision Avoidance warning light was temporarily illuminated. The…

  The contact owns a 2020 Kia Sorento. The contact stated that while driving, there was an abnormal banging sound coming from under the hood of the vehicle and the vehicle shuddered abnormally. The contact stated that the Forward Collision Avoidance warning light was temporarily illuminated. The vehicle was taken to a local dealer where it was diagnosed; however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure. The failure mileage was approximately 34,000.

• Sep 26, 2026MAFire
  Electrical system · Engine · Fuel/propulsion system
  Driving at highway speed, the vehicle began to make a loud rattling noise that came from under the vehicle. A passerby pulled even with my car and began frantically gesturing. After a few seconds of confusion, me daughter said the she thought the man was saying "it's on fire." We pulled over to the…

  Driving at highway speed, the vehicle began to make a loud rattling noise that came from under the vehicle. A passerby pulled even with my car and began frantically gesturing. After a few seconds of confusion, me daughter said the she thought the man was saying "it's on fire." We pulled over to the shoulder of the road, exited quickly and realized there was fire visible in the engine area, seen through the grill. A good samaritan attempted to suppress the fire with an exstinguisher but moments later, it was fully engulfed.

• Sep 18, 2026CA35,000 miCrash
  Vehicle speed control
  The contact owns a 2020 Kia Sorento. The contact stated that upon starting the vehicle and shifting into gear with the brake pedal depressed, the vehicle unexpectedly jerked back and forth, accelerated unintendedly, and crashed into the corner plaster wall of a friend's garage, causing plaster to…

  The contact owns a 2020 Kia Sorento. The contact stated that upon starting the vehicle and shifting into gear with the brake pedal depressed, the vehicle unexpectedly jerked back and forth, accelerated unintendedly, and crashed into the corner plaster wall of a friend's garage, causing plaster to fall onto the front of the vehicle. The vehicle was towed to Caliber Collision to be repaired. The dealer was notified of the failure. Police officers responded to the scene, inspected the vehicle, and filed a report. The failure mileage was approximately 35,000.

• Sep 1, 2026OH1 injury
  Unknown or other
  While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered…

  While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered, and there were no warning lights, messages, noises, cracks, or other indications that the glass was about to fail. Because I was traveling at freeway speed when this occurred, the sudden explosion/shattering of the glass was extremely distracting and created a serious safety concern. I was frightened by the unexpected loud noise and could have lost control of the vehicle. Broken glass from a panoramic sunroof also presents a risk to the occupants of the vehicle and to other motorists. The component that failed was the panoramic sunroof glass. To my knowledge, the failure has not yet been reproduced or confirmed by a Kia dealer or independent repair facility, and the vehicle has not yet been inspected by Kia for the cause of the failure. I am reporting this incident because the sunroof appeared to shatter suddenly during normal highway driving without any prior warning, and I am concerned that this may represent a safety defect.

• Aug 31, 2026WI9,000 mi
  Air bags
  The contact owns a 2020 Kia Sorento. The contact stated that the front passenger’s side air bag warning light remained illuminated while an occupant was seated in the front passenger’s seat. The dealer was notified of the failure and informed the contact that there were no recalls or warranty…

  The contact owns a 2020 Kia Sorento. The contact stated that the front passenger’s side air bag warning light remained illuminated while an occupant was seated in the front passenger’s seat. The dealer was notified of the failure and informed the contact that there were no recalls or warranty associated with the vehicle failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 9,000.

• Aug 18, 2026NC
  Engine
  My 2020 Kia Sorento stalled and shut off while driving and eventually stopped working completely, requiring it to be towed to a Kia dealership. The dealership first replaced the starter and then the high-pressure fuel pump, but the vehicle still would not operate. After further diagnosis, I was…

  My 2020 Kia Sorento stalled and shut off while driving and eventually stopped working completely, requiring it to be towed to a Kia dealership. The dealership first replaced the starter and then the high-pressure fuel pump, but the vehicle still would not operate. After further diagnosis, I was informed that the timing chain had failed/broken and the engine needed to be replaced, with a new engine quoted at approximately $12,000. I am concerned that this type of sudden engine failure and shutdown could create a serious safety hazard, especially if it occurs while driving in traffic or at highway speeds. I am requesting that NHTSA document and review this incident for similar failures involving 2020 Kia Sorento vehicles.

• Jul 29, 2026IA
  Power train
  The contact called on behalf of his daughter who owns 2020 Kia Sorento. The contact stated that the vehicle was taken to a dealer for a routine oil change when the contact was informed that there was an unknown issue with the vehicle however, the vehicle was not diagnosed or repaired. The vehicle…

  The contact called on behalf of his daughter who owns 2020 Kia Sorento. The contact stated that the vehicle was taken to a dealer for a routine oil change when the contact was informed that there was an unknown issue with the vehicle however, the vehicle was not diagnosed or repaired. The vehicle was taken to a different dealer where it was diagnosed that the transmission fluid was leaking and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

• Jul 12, 2026MD
  Air bags · Electrical system · Forward collision avoidance › Adaptive cruise control
  Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all…

  Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.

• Jul 9, 2026FL19,000 mi
  Steering
  The contact owns a 2020 Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the…

  The contact owns a 2020 Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but the repair was delayed because the manufacturer required information from the dealer, while the dealer claimed to be waiting for a response from the manufacturer. The failure mileage was 19,000.

• Jun 2, 2026CA
  Engine · Fuel/propulsion system · Power train
  The vehicle suffered a sudden, severe engine malfunction/misfire while in operation, presenting a serious safety hazard on the road. Following the incident, the vehicle was taken to an authorized dealership service center (Repair Order #XXX), where technicians verbally confirmed that the engine…

  The vehicle suffered a sudden, severe engine malfunction/misfire while in operation, presenting a serious safety hazard on the road. Following the incident, the vehicle was taken to an authorized dealership service center (Repair Order #XXX), where technicians verbally confirmed that the engine requires a complete replacement due to internal mechanical failure. The catastrophic mechanical failure of the engine directly caused consequential damage to the emissions system, entirely clogging the catalytic converter with unburned fuel/debris. Despite the clear link to the known, systemic defects inherent to the Theta II engine line—which is subject to active federal consent orders, safety recalls, and lifetime warranty extensions—both the dealership and Kia Corporate are refusing to honor the 8-year/80,000-mile Federal Emissions Defect Warranty. The manufacturer is attempting to use the catastrophic failure of their own defective, recalled engine line to evade their legal environmental and safety warranty obligations, leaving the consumer stranded without alternative transportation. This represents a systemic effort by the manufacturer to deflect liability for documented powertrain safety failures onto individual consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• May 19, 2026MI
  Engine

  Engine is burning oil at a significant rate, when I get my oil changed at the dealers recommendation it is extremely low. I have to replace the oil regularly between oil changes, and there is an exhaust smell. Also lagging when I hit the gas.

• May 15, 2026PA
  Engine

  Car is 6 years old less then 100k miles and losing oil and motor problems Went through entire oil change in 1 month Kia unable or willing to assist with any coats I was told by a private garage that the motor in my car should be part of a recall that was already listed for 2021 through 2026 but they’re saying it’s not covered

• Apr 26, 2026MD
  Engine
  2020 Kia Sorento consuming 1.5 or more quarts of oil every 1,000 miles. Completing oil consumption testing with Kia dealer, which requires I take the car back to the dealer every 1k miles, times, so they can verify the oil levels. Last check, when issue was discovered, vehicle was down to only 1qt…

  2020 Kia Sorento consuming 1.5 or more quarts of oil every 1,000 miles. Completing oil consumption testing with Kia dealer, which requires I take the car back to the dealer every 1k miles, times, so they can verify the oil levels. Last check, when issue was discovered, vehicle was down to only 1qt of oil after driving only 2k miles from previous oil change. Note: the lambda engine was initially included in the latest Kia class action settlement but was dismissed per the plaintiff’s attorney in that case. However there are numerous reports from a large number of 2020 Kia Sorento owners now with the same issue and running into complete roadblocks in terms of recourse as for most the issue does not begin until they exceed the powertrain warranty. Especially if they’re secondary owners and not the original owner.

• Apr 23, 2026GA
  Seat belts

  Driver seatbelts randomly unlatches itself while operating vehicle.

• Apr 13, 2026UT
  Engine · Power train · Unknown or other

  Oil pressure light would come on and off, dealer said was probably the sensor got it replaced. Came back on the night I picked it back up.

• Mar 26, 2026IL
  Engine
  I own a 2020 Kia Sorento. There is currently a class action lawsuit settlement ongoing. I have been informed that my 2020 Kia Sorento is not eligible while the settlement clearly states the 2020 Kia Sorento is included as part of the settlement. My Kia’s engine did not fail until after the…

  I own a 2020 Kia Sorento. There is currently a class action lawsuit settlement ongoing. I have been informed that my 2020 Kia Sorento is not eligible while the settlement clearly states the 2020 Kia Sorento is included as part of the settlement. My Kia’s engine did not fail until after the settlement was finalized because I don’t drive a lot anymore and my mileage was just over a 100,000 miles when it started showing problems. It seems to be a new timeline for new claims and I’m still not allowed to file a claim for the same reason. I bought my car new in 2020. If you need additional information, please advise.

• Mar 20, 2026FL
  Electrical system · Engine

  My Oil Pressure Switch is diagnosed as faulty by independent service center as well as Kia. Kia is denying coverage. I have found information that it should be covered. My check engine light shows an oil can light.

• Mar 17, 2026CA
  Engine
  Office of Defects Investigation National Highway Traffic Safety Administration (NHTSA) 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Safety Complaint – Premature Engine Failure Risk Due to Excessive Oil Consumption and Confirmed Cylinder Scoring – 2020 Kia Sorento Dear Sir or Madam, I…

  Office of Defects Investigation National Highway Traffic Safety Administration (NHTSA) 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Safety Complaint – Premature Engine Failure Risk Due to Excessive Oil Consumption and Confirmed Cylinder Scoring – 2020 Kia Sorento Dear Sir or Madam, I am submitting a formal safety complaint regarding a 2020 Kia Sorento that is experiencing severe and abnormal engine oil consumption along with confirmed cylinder wall scoring. These conditions indicate progressive internal engine damage and present a significant risk of premature engine failure. The vehicle has been regularly maintained in accordance with manufacturer service recommendations. Despite proper maintenance, the engine began consuming excessive amounts of oil between normal service intervals. During inspection by the servicing dealership, visible cylinder wall scoring was identified within the engine. Cylinder scoring is a clear indication of internal engine wear and deterioration and can lead to rapid progression toward engine failure. Despite the confirmed presence of internal engine damage, the manufacturer has refused to authorize an engine replacement under the extended warranty program unless the engine experiences complete mechanical failure. The dealership has indicated that the vehicle must continue to be operated and monitored until catastrophic breakdown occurs before replacement will be approved. Requiring the continued operation of a vehicle with confirmed cylinder wall damage and abnormal oil consumption raises serious safety concerns. Progressive internal engine damage can lead to sudden engine seizure, stalling, or loss of power while driving, which creates a potential hazard for the driver, passengers, and surrounding traffic. Given the confirmed cylinder scoring and ongoing excessive oil consumption, I respectfully request that the National Highway Traffic Safety Administration investigate.

• Mar 15, 2026GA
  Engine

  Oil is leaking from my car. The dealership said I would need to replace the engine. The car is only 6 years old.

• Feb 24, 2026FL
  Engine · Fuel/propulsion system · Unknown or other
  Component/System Affected: UNKNOWN – suspected fuel system or related component due to strong gasoline odor. Vehicle is available for inspection upon request. What Happened: There is a strong gasoline odor specifically at the front driver’s side wheel well/tire area. The odor is also noticeable…

  Component/System Affected: UNKNOWN – suspected fuel system or related component due to strong gasoline odor. Vehicle is available for inspection upon request. What Happened: There is a strong gasoline odor specifically at the front driver’s side wheel well/tire area. The odor is also noticeable under the hood. The smell is present while the vehicle is parked (I had to move it out of the garage) and after driving. No visible fuel leaks or puddles have been observed under the vehicle. Safety Risk: Gasoline fumes create a potential fire hazard and pose a risk of accident. The odor is now also noticeable inside the vehicle, which increases concern for occupant safety. Confirmation by Service Centers: The problem has been reproduced and confirmed by independent service centers. Two separate auto mechanic shops inspected the vehicle and both confirmed smelling gasoline, but neither could identify the source of the odor or any mechanical defect. Inspections by Others: The vehicle has been inspected by two independent mechanics only. It has not yet been inspected by the manufacturer, police, or insurance representatives. Warning Lamps or Symptoms: No warning lights or dashboard messages have appeared. The only symptom is a persistent gasoline odor. Timeline: The odor was first noticed on 02/19/2026 and has continued since that date. Vehicle Information: 2020 Kia Sorento VIN: [XXX] Mileage: approximately 87,438 miles Used for local commuting to work and school. Vehicle is garage-kept and receives regular maintenance at certified auto mechanic shops. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• Feb 20, 2026MN
  Engine
  The engine is burning oil despite all maintenance being up to date and having fewer than 80k miles. Kia of Duluth Service Center checked the oil and said levels were good on 12/31/25. Fewer than 30 miles were driven and it was brought back to the dealership service center on 1/2/26 and diagnosed…

  The engine is burning oil despite all maintenance being up to date and having fewer than 80k miles. Kia of Duluth Service Center checked the oil and said levels were good on 12/31/25. Fewer than 30 miles were driven and it was brought back to the dealership service center on 1/2/26 and diagnosed with total engine loss due to oil starvation. The extended warranty company (JM&A) are denying coverage because the engine failure is due to lack of oil. They have inspected the vehicle. No warning lights ever came on and this is the second time that this issue has been addressed by Kia of Duluth. The engine could have easily overheated and caught on fire or lost power on the road.

• Feb 18, 2026FLFire
  Electrical system · Fuel/propulsion system · Unknown or other
  To the Office of Defects Investigation, I am submitting this formal complaint regarding NHTSA Recall 22V703000 (Kia Recall SC249) involving my 2020 Kia Sorento (VIN: [XXX] ). This recall identifies a fire risk due to a potential electrical short in the tow hitch harness module. The recall notice…

  To the Office of Defects Investigation, I am submitting this formal complaint regarding NHTSA Recall 22V703000 (Kia Recall SC249) involving my 2020 Kia Sorento (VIN: [XXX] ). This recall identifies a fire risk due to a potential electrical short in the tow hitch harness module. The recall notice specifically warns that a vehicle fire may occur while parked or driving. After receiving the recall notification, we made multiple attempts to schedule the required repair with Pompano Kia, the authorized dealership in our area. Despite repeated efforts, we were not provided with a confirmed repair appointment, and the recall remained incomplete. On [1-19-2026], before the recall remedy was performed, the vehicle caught fire while being driven on a highway in Florida. The vehicle became fully engulfed and was declared a total loss. Law enforcement and/or fire services responded. The incident appears consistent with the fire risk described in the recall. Following the incident, we visited the dealership to report the fire and the unresolved recall. We were told the matter would be reviewed and that we would receive a follow-up call. No follow-up was received. Attempts to contact the dealership through publicly listed email addresses resulted in delivery failure notices. According to NHTSA records, this recall affects tens of thousands of vehicles nationwide. We are concerned about: • Timeliness and availability of recall repairs • Dealership accessibility and communication • Risk to consumers when recall remedies are not completed before failure occurs We also attempted to consult several attorneys regarding this incident. We were advised that due to the volume of recall-related fire cases involving this manufacturer, representation may not be feasible unless severe bodily injury is involved. This further raises concern about the scale and seriousness of the issue. We respectfully request that NHTSA review: • Whether recall 22V703000 is being remedied INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Defect investigations

NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.

• Loss of Motive Power

  DP22003Opened Sep 12, 2022Closed Dec 12, 2023
  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles…

  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11008051TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: HIGH-PRESSURE FUEL PUMP REPLACEMENT (WTY034) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the Warranty Extension Program (WTY034) to diagnose the Malfunction Indicator Lamp (MIL) accompanied by DTC P0088 and, if necessary, replace the high-pressure fuel pump on 2019-2021 MY Sedona vehicles manufactured from February 13, 2018 through July 8, 2020, 2017-2020 MY Cadenza vehicles manufactured from June 2, 2016 through October 15, 2020, and 2019-2020 MY Sorento vehicles equipped with 3.3L V6 Engines manufactured from January 24, 2018 through October 15, 2020.
• 11001595TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 13, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
• 11000787This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
• 11000356TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: HIGH-PRESSURE FUEL PUMP REPLACEMENT (WTY034) - his bulletin provides information associated with the Warranty Extension Program (WTY034) to diagnose the Malfunction Indicator Lamp (MIL) accompanied by DTC P0088 and, if necessary, replace the high-pressure fuel pump on 2019-2021 MY Sedona vehicles manufactured from February 13, 2018 through July 8, 2020, 2017-2020 MY Cadenza vehicles manufactured from June 2, 2016 through October 15, 2020, and 2019-2020 MY Sorento vehicles equipped with 3.3L V6 Engines manufactured from January 24, 2018 through October 15, 2020.
• 11000354WARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY034) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension program launch.
• 11000349WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY034) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for the high-pressure fuel pump in certain 2019-2020 MY Sorento vehicles equipped with 3.3L V6 Engines from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
• 11000310WARRANTY EXTENSION CAMPAIGN: QUESTION AND ANSWER (WTY034) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension Campaign WTY034.
• 11000309WARRANTY EXTENSION CAMPAIGN: DEALER PARTS & SERVICE MANAGERS MEMO (WTY034) - This document is the announcement to the dealer Parts and Service Managers that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the high-pressure fuel pump for eligible vehicles from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the high-pressure fuel pump condition on 2019-2021 MY Sedona vehicles manufactured from February 13, 2018 through July 8, 2020, 2017-2020 MY Cadenza vehicles manufactured from June 2, 2016 through October 15, 2020, and 2019-2020 MY Sorento vehicles equipped with 3.3L V6 Engines manufactured from January 24, 2018 through October 15, 2020.
• 11000308WARRANTY EXTENSION CAMPAIGN: DEALER PRINCIPAL MEMO (WTY034) - This document is the announcement to the dealer principals that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the high-pressure fuel pump for eligible vehicles from 5 years / 60,000 miles to 15 years / 180,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address the high-pressure fuel pump condition on the following vehicles: 2019-2021 MY Sedona vehicles manufactured from February 13, 2018 through July 8, 2020, 2017-2020 MY Cadenza vehicles manufactured from June 2, 2016 through October 15, 2020, and 2019-2020 MY Sorento vehicles equipped with 3.3L V6 Engines manufactured from January 24, 2018 through October 15, 2020.
• 10253007TECHNICAL SERVICE BULLETIN: 4WD COUPLING NOISE INSPECTION AND SNAP RING REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect for a knocking/clicking noise present in the rear of the vehicle during low-speed driving (25MPH or less) on some 2020-2022MY Kia vehicles equipped with All Wheel Drive (AWD). The 4WD coupling snap ring may have excessive play between the drive gear set shaft and coupling flange.
• 10250517TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
• 10245266TECHNICAL SERVICE BULLETIN: 4WD COUPLING NOISE INSPECTION AND SNAP RING REPLACEMENT - This bulletin provides information to inspect for a knocking/clicking noise present in the rear of the vehicle during low-speed driving (25MPH or less) on some 2020-2022MY Kia vehicles equipped with All Wheel Drive (AWD). The 4WD coupling snap ring may have excessive play between the drive gear set shaft and coupling flange.
• 10243924TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10242982This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
• 10242913PITSTOP: AWD SYSTEM CONCERN DUE TO TIRE CIRCUMFERENCE - This Pitstop provides information regarding potential concerns with the All-Wheel-Drive (AWD) system due to tire sizes of differing circumference. Some customers may complain of a chatter sensation felt in the drivetrain of the vehicle and/or the failure of drivetrain component(s). A difference in tire size (width, aspect ratio, construction, rim diameter etc.) may be the cause.
• 10240563TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 7. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
• 10240558TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10240267CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
• 10239714TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10239108TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 6. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
• 10236650TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10236078TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10235104PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
• 10233638TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 2011-2015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2022MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
• 10233314TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2304) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM), or Intelligent Integrated Platform Module (IPM) system on certain 20132015MY Sorento (XMa), 2016-2020MY Sorento (UMa), and 2021-2023MY Sorento (MQ4a) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
• 10233309CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
• 10226555TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
• 10220346TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
• 10217892TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."
• 10216508TECHNICAL SERVICE BULLETIN: TRAILER HITCH ACCESSORY FUSE REQUIREMENT - This bulletin provides information regarding the trailer hitch accessory installation on some 2016-2020MY Sorento (UMa) vehicles. Note that the Kia trailer hitch accessory kit requires the use of a 15 Amp fuse rating to be used. The manufacturer of the trailer hitch accessory specifies a fuse size based on development and design of their components including pin terminal, number of circuits, and module design. Always confirm the model of the hitch installed and use the recommended fuse rating required by the manufacturer.
• 10209455PITSTOP: INSTRUMENT CLUSTER REPLACEMENT AND MILEAGE SETTING WITH KDS - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This pitstop provides the KDS service procedure for mileage setting on the models listed below with newly replaced instrument clusters. Certain models allow for mileage setting with the KDS, which prevents the need to send out the instrument cluster to a 3rd party for mileage adjustment (refer to PS264). After a new cluster is installed, cluster (variant) coding may also need to be conducted using the KDS. Make sure the KDS software is also updated to the latest version. Mileage setting should be performed by using the KDS only, as described in this bulletin.
• 10209438TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10206642TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10205426TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10202227TECHNICAL SERVICE BULLETIN: REPLACEMENT OF MOBIS C-MDPS SMALL BEARING - This bulletin provides the procedure to replace the small bearing of the Column Motor Driven Power Steering (C-MDPS) unit on the vehicles listed below, which may exhibit an abnormal noise when steering left and right. This may be caused by foreign substances in the MDPS worm shaft small bearing. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Small Bearing and does not affect the steering effort.
• 10202226TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
• 10201529TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
• 10200525PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
• 10200422TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF THE DUAL PINION MOTOR DRIVER POWER STEERING SYSTEM - This bulletin provides information regarding the availability of partial repair (depending on faulty components) of the Dual Pinion Motor Driven Power Steering (DP-MDPS) system on some 2016-2021MY~ Kia vehicles (refer to the table below) in order to enhance customer satisfaction by promoting a cost-effective repair/replacement of a faulty related part, instead of replacement of the complete DP-MDPS assembly.
• 10196825PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.

Every KIA Sorento model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.