2021 Mack LR Electric
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Mack › LR Electric › 2021
These records cover every 2021 Mack LR Electric. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2021 Mack LR Electric. Newest first.
Mack Trucks, Inc. (Mack) is recalling one 2021 truck. The coolant line in the high voltage battery pack may not be fully seated and locked, which can result in the loss of coolant and an electrical short circuit.
Risk and remedy
Risk
A battery short circuit increases the risk of a fire.
Remedy
Mack will inspect the battery packs, and replace them as necessary, free of charge. The affected vehicle was within the manufacturer's control, has been repaired, and therefore no owner letters were mailed. Owners may contact Mack's customer service at 1-800-866-1177.
Mack Trucks, Inc. (Mack) is recalling certain 2023 LR Battery Electric trucks. During certain driving maneuvers, the power steering system may lose pressure, causing a loss of power steering assist.
Risk and remedy
Risk
Loss of power steering assist increases the risk of a crash.
Remedy
Dealers replace the higher ratio steering gear and power steering pump software for higher RPM's on the steering pump, free of charge. Owner notification letters were mailed on May 24, 2022. Owners may contact Mack's customer service at 1-800-866-1177. Mack's number for this recall is SC0434.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10253818CBR: Battery Electric Vehicle (BEV) DTC P108664 - Charging Switch Unit B, Voltage Supply, Signal Plausibility Failure
- 10251332CBR - BEV Fault Code C102571 - Hybrid/EV System, Cooling Heater Relays - Actuator Stuck
- 10249554CBR: Battery Electric Vehicle (BEV) 3-WayValve Calibration Failure
- 10249553CBR: TGW Will Not Connect After SIM Card Replacement
- 10241946TSB: Barksdale Leveling Valve, Leak Test
- 10241915CBR: Battery Electric Vehicle (BEV) - Vehicle Will Not "Start", Limited Speed, Instrument Cluster Showing Neutral After Gear Selected
- 10240233CBR: Battery Electric Vehicle (BEV) - Hybrid Powertrain Control Unit (HPCU) Programing
- 10240232CBR: Battery Electric Vehicle (BEV) - Diagnostic Trouble Code (DTC) Troubleshooting Ending In No Fault Found
- 10240209Service Campaign: Phase 1 Heater Relay Monitoring Accessory Kit
- 10237376CBR: Battery Electric Vehicle (BEV) Sub Hardware Programming
- 10237374Service Literature Published and Released in May, 2023
- 10237342CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- 10235493TSB: Hub Cap, Leaking
- 10235358CBR: Battery Electric Vehicle (BEV) Cab Heater Diagnostics
- 10233522New TSB- Hub cap leaking
- 10232601Battery Electric Vehicle (BEV) - Charging Issues Worksheet For eService
- 10232600Battery Electric Vehicle (BEV) - Charging Issues Worksheet For eService
- 10227186Mack Chassis - P05E662 Park brake Sensor/Switch Circuit Range/Performance, Signal Compare failure - Diagnostic Instructions - US21+OBD21 Emissions
- 10222608TSB-Charge Air Cooler t-clamp install.
- 10219423USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
- 10215318Back Office Mack Chassis - Secondary Gauge Set Up - Model Year 2018 and Newer.
- 10215316DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer.
- 10215315Programming Failure - Chassis With Cummins Engine And An Allison Transmission
- 10215314NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
- 10215312(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
- 10215309Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions.
- 10215307Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions.
- 10215305DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions.
- 10215296Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
- 10215295Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And N.
- 1021529411L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
- 10215291Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
- 10215290(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) - US17 And Newer Emissions (Common Rail Fuel System).
- 10215289Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault Codes P1058 - 21 Or MID 130 PID 161 FMI 1
- 10215287US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
- 10215286Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer.
- 10213658Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
- 10213651Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors) - US07 And Newer Emissions, Model Year 2008 And Newer
- 10213644Premium Tech Tool ( PTT ) Training Materials And Support Tools
- 10213642No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
Every Mack LR Electric model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.