2016 Nissan Redundant NV200

Recalls

1 recall names the 2016 Nissan Redundant NV200. Newest first.

• Air bags › Sensor › Occupant classification

  Apr 26, 2016NHTSA 16V2440003,296,947 vehicles

  Nissan North America, Inc. (Nissan) is recalling certain model year 2016-2017 Nissan Maxima, 2013-2016 Nissan Altima, NV200, LEAF, Sentra, and Pathfinder, 2014-2016 Nissan NV200 Taxi, Infiniti QX60, QX60 Hybrid, and Q50 Hybrid, 2014-2017 Nissan Rogue and Infiniti Q50, 2015-2016 Nissan Murano, Murano Hybrid, and Chevrolet City Express, 2014-2015 Nissan…

  Risk and remedy

  Risk

  If the passenger frontal air bag does not deploy as intended in the event of a crash, the passenger is at an increased risk of injury.

  Remedy

  Nissan will notify their owners. Chevrolet City Express owners will be notified by General Motors. Dealers will reprogram the Air Bag Control Unit (ACU) and OCS Electronic Control Unit (ECU) in Altima, Maxima, Murano, Rogue, and Sentra vehicles, and replace the OCS ECU in LEAF, NV200, NV200 Taxi, Pathfinder, Infiniti Q50, JX35, and QX60 and Chevrolet City Express vehicles, free of charge. Interim notices were sent to owners on May 31, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Nissan customer service at 1-800-867-7669, Infiniti customer service at 1-888-833-3216 or Chevrolet customer service at 1-800-222-1020.

  Full recall details →

Owner complaints

Latest complaints

• Nov 17, 2016CA3,200 miCrash1 injury
  Air bags
  TL* the contact owns a 2016 nissan nv200. While driving approximately 50 mph and attempting to avoid running over a coyote, the contact crashed into a large rock on the side of the road. The air bags failed to deploy. The contact sustained knee injuries, but did not require medical attention. A…

  TL* the contact owns a 2016 nissan nv200. While driving approximately 50 mph and attempting to avoid running over a coyote, the contact crashed into a large rock on the side of the road. The air bags failed to deploy. The contact sustained knee injuries, but did not require medical attention. A police report was not filed. The vehicle was towed to the contact's residence. The vehicle was not diagnosed or repaired. The vin was included in nhtsa campaign number: 16v244000 (air bags). The manufacturer was not made aware of the failure. The failure mileage was approximately 3,200.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10165785TRANSMISSION RANGE SWITCH SERVICE INFORMATION SERVICE INFORMATION The transmission range switch of the APPLIED VEHICLES listed above is now available as a separate service part. If the transmission range switch of an APPLIED VEHICLE is being replaced for any reason, it must be adjusted after its replacement. Refer to SERVICE PROCEDURE on page 3 for transmission range switch removal, installation, and adjustment.
• 10165784DTC B00A0-00 STORED IF YOU CONFIRM DTC B00A0-00 (OCCUPANT DETECTION SENSOR UNIT) is stored And OCS zero point reset cannot be performed (continued on the next page) And The following screen displays: ACTION 1. Check the Occupant Classification System (OCS) control unit using the ODS Analysis tool software. Refer to SERVICE PROCEDURE on page 5. HINT: OCS may also be referred to as ODS. 2. Perform 75-zero RESET.
• 101646582015-2018 NV200 AND 2014-2017 TAXI; DTC P17F0, P17F1, P0776, P2813, P1715, AND/OR P0841 STORED IF YOU CONFIRM One or more of the following DTCs are stored: P0776, P2813, P0841, P17F0, P17F1, P1715 IMPORTANT: If DTCs other than those listed above are stored, this bulletin does not apply. If the customer states the engine stalled while going from 'P' or 'N' range to 'R' or 'D' range, this bulletin does not apply. If DTC P17F0 and/or P17F1 are the only DTCs stored and there is no customer complaint of judder, this bulletin does not apply. If DTC P1715 is the only code stored, this bulletin does not apply. ACTION See Repair Flow Chart on page 2 to confirm if this bulletin applies.
• 10158427CVT / TCM CALIBRATION DATA ?WRITE? PROCEDURE This bulletin applies only to vehicles equipped with a Continuously Variable Transmission (CVT). This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
• 10158426CVT / TCM CALIBRATION DATA ?WRITE? PROCEDURE This bulletin applies only to vehicles equipped with a Continuously Variable Transmission (CVT). This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
• 10153007NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING This bulletin does NOT apply to LEAF vehicles and Titan XD vehicles with V8 diesel engine. This bulletin has been amended. See Amendment History on the last page. Please discard previous versions of this bulletin.
• 10153003NV200 AND TAXI; MIL ON WITH DTC P0101 This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
• 10152998ALL MODEL YEAR 2012 AND NEWER NISSAN VEHICLES; EVAP LEAK DTC P0442, P0455, P0456 INFORMATION This bulletin does NOT apply to LEAF vehicles and Titan XD vehicles with V8 diesel engine. This bulletin has been amended. See Amendment History on the last page. Please discard previous versions of this bulletin.
• 10152524AIR BAG WARNING LIGHT FLASHING INDICATING SYSTEM DIAGNOSTIC MODE IF YOU CONFIRM The air bag warning light is flashing slowly (repeating 2 seconds ON, 2 seconds OFF). NOTE: If this should occur, the Air Bag Diagnosis Sensor Unit is in Diagnostic Mode and needs to be returned to User Mode. ACTION 1. Use CONSULT-III plus to check for Air Bag DTCs and perform repairs as needed. 2. Return the Air Bag Diagnosis Sensor Unit to User Mode.
• 10152521MIL ON WITH DTC P0776, P1715 AND MAY HAVE HESITATION AND/OR LACK OF POWER This bulletin applies only to vehicles equipped with a CVT (Continuously Variable Transmission). IF YOU CONFIRM The MIL is ON with DTC P0776 (PC SOLENOID B ? Pressure Control Solenoid ?B? Performance/Stuck OFF) stored. NOTE: - If P0744, P0746, P0841, P0965, P2813, or P17F0 are stored this bulletin does not apply. Refer to ASIST for diagnostic assistance. - With this incident, if it should occur, P1715 (INPUT SPEED SENSOR) may be stored with DTC P0776. The vehicle may also hesitate and/or have reduced power. ACTION 1. Refer to the Repair Flow Chart on page 2 for mechanical CVT repair. 2. If needed, reprogram the TCM. - Refer to step 30 in the TCM Reprogram section (page 21) of the SERVICE PROCEDURE to confirm if reprogramming is needed. 3. Perform Additional Service (page 19).
• 10152515OBD II EVAP Tube Warranty Enhancement The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make regional and dealer personnel aware that we are re-notifying customers at this time.
• 10152514NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make regional and dealer personnel aware that we are re-notifying customers at this time.
• 10152511NISSAN CONNECT NAVIGATION SYSTEM SOFTWARE UPDATE This bulletin applies only to vehicles equipped with a navigation system. This bulletin has been amended. See AMENDMENT HISTORY on page 9. Please discard previous versions of this bulletin.
• 10152510CVT / TCM CALIBRATION DATA ?WRITE? PROCEDURE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
• 10145551REVISED WHEEL ALIGNMENT SPECIFICATIONS This bulletin has been amended to add 2018-2019 Kicks. Please discard previous versions of this bulletin.
• 10144513NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. This bulletin has been amended. Changes have been made throughout. It is necessary for you to read this revised procedure to properly perform this action. Please discard previous versions of this bulletin.
• 10144508NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. This bulletin has been amended. Changes have been made throughout. It is necessary for you to read this revised procedure to properly perform this action. Please discard previous versions of this bulletin.
• 10134841WHEEL BALANCING SERVICE INFORMATION This bulletin has been amended. The publication date has been revised to include the latest models and model years. No other changes have been made. Please discard previous versions of this bulletin.
• 101305002013-2016 NV200 AND 2014-2016 TAXI; OCCUPANT CLASSIFICATION RETROFIT SERVICE INFORMATION The information in this bulletin is provided for customers who have concerns with their Occupant Classification System (OCS) operation after all campaigns have been completed. Follow the steps in this bulletin to determine if this OCS retrofit procedure is applicable to the vehicle you are working on. DETERMINE IF OCS RETROFIT APPLIES 1. Check Service COMM to confirm if OCS reprogramming campaign has been completed (R1607 / NTB16-054). Completed: - Write on the repair order the date it was completed and by which dealer. - Go to step 2. Not Completed: - Complete campaign R1607 / NTB16-054. - No further action needed. OCS retrofit does NOT apply.
• 10125187REVISED WHEEL ALIGNMENT SPECIFICATIONS This bulletin has been amended to add 2018 Versa Sedan and 2018 Versa Note. No other changes have been made. Please discard previous versions of this bulletin.
• 10120586CVT FLUID LEVEL CHECK SERVICE INFORMATION This bulletin has been amended. The APPLIED VEHICLES section has been revised. No other changes have been made. Please discard all previous versions of this bulletin.
• 10120566NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING IF YOU CONFIRM The MIL is ON in an APPLIED VEHICLE with DTC P0456 (EVAP VERY SML LEAK) AND - DTC P0456 is not caused by a loose fuel fill cap (refer to NTB13-097). - An EVAP leak has been detected where the vent control valve mounts to the canister. - The vent control valve O-ring seal is determined to be the cause. ACTION 1. DO NOT REPLACE the vent control valve. 2. Replace the vent control valve O-ring seal (O-ring). - Refer to SERVICE PROCEDURE on page 2.
• 10120556REVISED WHEEL ALIGNMENT SPECIFICATIONS SERVICE INFORMATION For the Applied Vehicles, some wheel alignment specifications listed in the Front Suspension (FSU) and Rear Suspension (RSU) sections of the Electronic Service Manual (ESM) have been revised. Updated ESMs will be distributed to the field as quickly as possible. Until the updated ESMs are made available, please use the corrected specifications listed in this bulletin.
• 10119282NISSAN; DIAGNOSIS INFORMATION FOR ABS DTC C1130 SERVICE INFORMATION When diagnosing for DTC C1130 (ENGINE SIGNAL): ECM related DTCs (P-codes) must be diagnosed, repaired, and DTCs erased first. - DTC C1130 is an ABS DTC that indicates an output signal of the ECM is not recognized. - Absent or incorrect ECM signals, that are indicated by corresponding P-codes, may trigger C1130 in the ABS control unit. - Some vehicle features that can be affected by absent or incorrect ECM signals are: - Forward Emergency Braking (FEB) - Intelligent Cruise Control (ICC) - VDC/ABS/TCS
• 10119249NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING This bulletin has been amended. The APPLIED VEHICLES and CLAIMS INFORMATION sections have been revised. No other changes have been made. Please discard previous versions of this bulletin.
• 10118691WHEEL BALANCING SERVICE INFORMATION This bulletin has been amended. The publication date has been revised to include the latest models and model years. No other changes have been made. Please discard previous versions of this bulletin.
• 10116292CLICKING NOISE FROM FRONT OR REAR AXLE DURING TAKE-OFF/ACCELERATION This bulletin has been amended. The APPLIED VEHICLES section has been revised. No other changes have been made. Please discard previous versions of this bulletin.
• 10109225Air Bag Control Unit (ACU) Liquid Intrusion Voluntary Service Campaign ***** Campaign Summary***** Nissan is conducting a voluntary service campaign on specific MY2013-2017 Nissan NV200 (M20) and MY2013-2016 NY Taxi (M30) to remedy a potential liquid intrusion issue. The Air bag Control Unit (ACU) is located under the center console. Liquids spilled on or around the center console area or power washing the floor may contact ACU connections and the ACU circuit board. This may lead to corrosion of the ACU, which may result in illumination of the air bag warning lamp and deactivation of front air bags. In January, 2016, Nissan had dealers to install a console tag and owner's manual card in each affected vehicle in their inventory. Console tags and owner notification cards were mailed to dealers. Nissan also mailed letters affected retail customers with the same information. Nissan is now requesting Dealers to verify the air bag warning lamp is operating correctly and install foam to the center console. If the air bag warning light is not operating correctly, dealers will replace the ACU, in addition to installing the foam on the center console. Nissan expects a small amount (< 1%) of vehicles to require ACU replacement.
• 10109214NISSAN; FUEL TANK IS SLOW OR DIFFICULT TO FILL IF YOU CONFIRM The fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). IMPORTANT: Make sure this incident has been duplicated at a gas station by dealer service staff. ACTION Perform the Service Procedure in this bulletin, starting on the next page.
• 10109213VOLUNTARY SERVICE CAMPAIGN 2014-2017 TAXI AND 2013-2017 NV200 CENTER CONSOLE INSULATOR INTRODUCTION Nissan is conducting a voluntary service campaign on certain specific 2014-2017 Taxi and 2013-2017 NV200 vehicles to install a center console insulator. This service will be performed at no charge to owners for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification number PM674 to this campaign. This number must appear on all communications and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY Dealers are to repair vehicles falling within range of this campaign that enter the service department. This includes vehicles purchased from private parties, vehicles presented by transient (tourists) owners, and vehicles in a dealer's inventory.
• 10109211BALL JOINT AXIAL END PLAY PROCEDURE SERVICE INFORMATION When working on the front suspension, use the updated service information in this bulletin along with the Electronic Service Manual (ESM). The updated information in this bulletin is a correction and a supplement to the ESM.
• 10109165Airbag Control Unit (ACU) Liquid Intrusion Voluntary Service Campaign ** Campaign Summary** Nissan is conducting a voluntary service campaign on specific MY2013-2017 Nissan NV200 (M20) and MY2013-2016 NY Taxi (M30) to notify owners of a proper vehicle usage to prevent a potential liquid intrusion issue. The Airbag Control Unit (ACU) is located under the center console. Liquids spilled on or around the center console area or power washing the floor may contact ACU connections and the ACU circuit board. This may lead to corrosion of the ACU, which may result in illumination of the airbag warning lamp and deactivation of front air bags. Nissan is requesting dealers to install a console tag and owner's manual card in each affected vehicle in their inventory. Console tags and owner notification cards have already been mailed to dealers. Nissan has mailed a letter to each affected retail customer with the same information. Additional actions to address the potentially affected vehicles will be communicated at a later date. *** What Dealers Should Do *** 1. Verify if vehicles are affected by this Voluntary Service Campaign using Service Comm I.D. PM664. NOTE: Only dealer inventory units are active in Service Comm at this time. If a retailed vehicle is identified in Service Comm, no action is necessary at this time as owners were mailed the notification letter included with this announcement. - Beginning January 28, 2017, affected dealer inventory can be identified using DCS (Sales->Vehicle Inventory, and filter by Open Campaign) o Refer to NPSB 15-460 for additional information. Dealers may provide customer with campaign details outlined in this announcement and request a manual campaign closure by emailing campaign_manual_closure@nissan-usa.com and providing the following information: - Customer's VIN - Dealer Number - Campaign ID 2. Follow the procedure included in this announcement to place console tags in any affected vehicles currently in dealer invent
• 10109114PLASTIC INTERIOR TRIM PROTECTIVE COVERING REMOVAL SERVICE INFORMATION Vehicles are delivered with plastic interior trim protective covering on the front and rear seats, front and rear door panel finishers, steering wheel, and sun visors (see examples on page 2). When removing the protective covering, care must be used to avoid scuffs, scrapes, cuts, and other abrasive contact to interior trim components. DO NOT use sharp objects like razor blades, box cutters, knives, etc. when removing the plastic interior trim protective covering. IMPORTANT All soft trim described in this bulletin is on automatic return to NNA. Any trim found damaged in the way described in this bulletin will be charged back to the dealer.
• 10091608"Nissan; doors difficult to close with temperature below freezing if you confirm: the following incident, or the customer reports this incident: - the vehicle has been setting (not running) in temperatures below 14F (-10C) for an extended period (such as overnight). Then - a side door IS opened. Then - the door IS difficult to close/latch, will not close/latch with normal pressure; requires additional effort to close/latch, or the door may only latch half way. Then - the door will close/latch normally when the vehicle has warmed up (vehicle left in the sun, moved indoors, or driven for several minutes). Note: o the above incident does not apply to sliding side doors or a rear hatch (back door). O the above incident, if it should occur, could be confirmed or reported for one or more side doors. Action replace the door lock for the affected door. - do not replace all side door locks automatically. Replace only the door lock of the door(s) with the incident as described under if you confirm. - refer to the electronic service manual (esm), section dlk door & lock for replacement procedure."
• 10091503"All model year 2012 and newer nissan vehicles; evap leak dtc p0442, p0455, p0456 information this bulletin has been amended. The title has been revised, and the bulletin now includes vehicles in production as of the date of this update. No other changes have been made. Please discard all previous versions of this bulletin."
• 10075221OCCUPANT CLASSIFICATION SYSTEM LIGHT OPERATION LOGIC CHANGE SERVICE INFORMATION Nissan is issuing this Technical Service Bulletin to clarify that a change has been made for the logic that controls the Occupant Classification System (OCS) and passenger airbag indicator (PABI), as described in the Owners Manual. This TSB applies only to vehicles using the 2-sensor OCS. Those changes are: PABI light is ON with an empty front passenger seat.

Every Nissan Redundant NV200 model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.