2005 Prevost XL2-45
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Prevost › XL2-45 › 2005
These records cover every 2005 Prevost XL2-45. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2005 Prevost XL2-45. Newest first.
On certain motor coaches and motor homes, cracks were found in the material used to make suspension radius rod pins.
Risk and remedy
Risk
Broken rod pins can cause a loss of control of the vehicle, which could result in a crash.
Remedy
Dealers will inspect all parts and, if necessary, replace the rod pins. the recall IS expected to begin during september 2004. customers may also contact prevost at 1-418-831-5432.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10248275Sway bar collars improvement
- 10231093STEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139
- 10228667Air Tanks Draining Sequence. Revision: B - General Update
- 10226928Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location.
- 10226927Air Tanks Draining Sequence
- 10214935Central hvac merv filters installation
- 10199007STORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage. Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends following the guidelines in this document during times when: The coach can be operated on a regular/weekly basis while in storage. The coach will be in storage for an extended period without any operation. The coach will return to service following an extended period of downtime.
- 10189728TIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles. The new tie rod will be adjusted to the length of the original; however, a steering alignment needs to be performed after replacement.
- 10186398Rev A: Mention added concerning DDC Series 60 engine SCA requirement
- 10184354Introducing a new engine coolant into service
- 10179434STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
- 10177808JERKY, NOISY OR HARD TO TURN STEERING GEARBOX. HYDRAULIC END LIMITER ADJUSTMENT. All models equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
- 10176961STORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed 611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
- 10174680Prevost vehicle disinfection procedure
- 10174679Storage and startup guidelines - all prevost vehicles & volvo 9700
- 10173171Added: Power cables for L.H. side alternator & fan drive breaker box
- 10011989Copper piping and connector replacement at water pump inlet. Prevost.