2009 Scion XD
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2009 Scion XD. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2009 Scion XD. Newest first.
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window…
Risk and remedy
Risk
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Toyota is recalling certain model year 2006-2010 Yaris vehicles manufactured August 22, 2005, through May 12, 2010, and 2008-2010 Scion xD vehicles manufactured April 4, 2007, through May 12, 2010. In the affected vehicles, the springs used for the seat rails on the driver's seat and the seat rails of the front passenger seat of three-door models may break.
Risk and remedy
Risk
If the spring breaks, the seat may not lock in position. In the event of a vehicle crash, the seat could move increasing the risk of injury to the seat occupant.
Remedy
Toyota will notify owners, and dealers will inspect the seat rail, and replace it with a new one, if necessary, free of charge. The recall began on July 3, 2014. Owners may contact Toyota at 1-800-331-4331.
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the…
Risk and remedy
Risk
If the switch overheats, it may melt, possibly resulting in a fire.
Remedy
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Gulf states toyota IS recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Risk and remedy
Risk
This does not meet the standard requirements.
Remedy
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. the safety recall began on may 27, 2010. owners may contact gulf states toyota at 713-580-3300.
Southeast toyota IS recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Risk and remedy
Risk
A driver may overload a vehicle which may increase the risk of a crash.
Remedy
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.
Toyota IS recalling certain model year 2008-2009 scion xd and my 2009-2010 corolla, and corolla matrix vehicles equipped with 1.8L engine and originally sold in or currently registered in the states of alaska, colorado, idaho, illinois, iowa, kansas, maine, michigan, minnesota, montana, nebraska, nevada, new hampshire, new york, north dakota, south dakota…
Risk and remedy
Risk
This could lead to an increase in vehicle stopping distance and a crash could occur.
Remedy
Dealers will install a newly designed intake air connector which will relocate the brake system vacuum port. this service will be performed free of charge. the recall began on september 21, 2009. owners may contact toyota at 1-800-331-4331.
Owner complaints
23 complaints3 involved a crash1 involved a fire4 injuries
What owners report most
Latest complaints
- Suspension · Unknown or other · Wheels
Drove car and heard loud noise issuing from the passenger side rear. Upon viewing the wheel was angled in at the top. After removing the wheel I found the rear crossmember subframe axle had a complete break in the weld holding the angle from the straight part of the beam to the wheel and suspension…
Drove car and heard loud noise issuing from the passenger side rear. Upon viewing the wheel was angled in at the top. After removing the wheel I found the rear crossmember subframe axle had a complete break in the weld holding the angle from the straight part of the beam to the wheel and suspension plate. After going online to see if similar issues happen on the same side of the vehicle, I found many reports of weld failures on the same side at the same joint. This is an EXTREMELY dangerous weld failure--if it had happened during highway travel the potential for catastrophic injury or death is high, in my opinion. Please investigate other reports to the NTSB about this make and model, and please search model years on or about 2007-2012 as other scion owners have had the same issue. This is a one owner car, we purchased it new in 2009. The opposite weld is also showing signs of stress, but not broken or cracked.
- Suspension
A major safety structural defect has developed in the rear axle beam. About 50 percent of the welds failed where the passenger side swing arm attaches to the rest of the axle. The lack of support ended up creating about a three inch stress crack across the width of the swing arm tube. This could…
A major safety structural defect has developed in the rear axle beam. About 50 percent of the welds failed where the passenger side swing arm attaches to the rest of the axle. The lack of support ended up creating about a three inch stress crack across the width of the swing arm tube. This could have led to a complete failure of the swing arm, had I not found the problem. Had this failure occurred on the highway, it might have caused a serious accident. A month prior I started hearing a pop from the rear of the car each time I would back out of the driveway and the first time I went forward. I crawled under the car within about two weeks and checked things over but found nothing. I thought it might have been a coil spring shifting in its seat or a shock absorber with an internal problem. The noise continued and was getting a bit louder each time it occurred. I ended up lifting the back of the car and pulling the rear wheels. I first found the stress crack across the swing arm tube. Upon further inspection, I realized a portion of the welds had failed. The car is 14 years old and has 159k miles. There is rust that is contributing to the deterioration of the connection, yet the design of the swing arm and its connections seem as though they are barely sufficient when it was new. The design of the swing arm connections does not appear sufficient to be exposed to normal wear and tear of winter driving. In searching for a replacement part, this same exact swing arm is also used on the Toyota Prius C and a Yaris model. So this issue could be occurring on those models as well.
- Electrical system
A reca for my power switch master control was issued on sept 15TH 2015 and a fix for this still has not been established. This defect could cause a fire in my vehicle.
- Electrical system
2009 toyota scion. Consumer writes in regards to problem with electrical system. *Ld the consumer stated while driving, the radio independently turned on and of and the dash lights flashed. The vehicle shut down. The consumer was advised the alternator failed. *Js
- Unknown or other
Fix for window lubricant issue that could cause fire has not been issued, even though recall IS now 2 years old.
- Vehicle speed control
TL* the contact owns a 2009 scion xd. On several occasions, while driving 60 mph, the cruise control indicator illuminated independently. The vehicle was taken to a dealer, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was 49,500.
- Electrical system · Seats
The dealer that would be able to perform the repair only does recall work during the week I unfortunately work monday through friday during normal business hours. Which I can not take time off for as they say it might take all day and I depend on my car for business I asked to speak with the…
The dealer that would be able to perform the repair only does recall work during the week I unfortunately work monday through friday during normal business hours. Which I can not take time off for as they say it might take all day and I depend on my car for business I asked to speak with the manager at autonation toyota in fort myers florida but was told that IS the only option. This IS completely unacceptable as there are 2 safety recalls one involving my seats and the other involving a window switch that could catch fire. I originally tried in november to schedule this but to no avail. *tr
- Electrical system · Engine · Visibility/wiper
TL* the contact owns a 2009 scion xd. While driving approximately 55 mph, the vehicle stalled without warning and failed to start intermittently. The vehicle was taken to the dealer where it was serviced under an unknown recall, but the failure recurred. In addition, the front passenger side window…
TL* the contact owns a 2009 scion xd. While driving approximately 55 mph, the vehicle stalled without warning and failed to start intermittently. The vehicle was taken to the dealer where it was serviced under an unknown recall, but the failure recurred. In addition, the front passenger side window switch operated intermittently. The vehicle was taken to the dealer where it was diagnosed that the passenger side window switch needed to be replaced. The vehicle was repaired, but the failure recurred. The contact received notification of nhtsa campaign number: 15v689000 (visibility); however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was 113,283. Parts distribution disconnect. ...Updated 09/12/16 *bf consumer stated motor shut down, its located in the gas line/ fuel line with having more than 1 motor and not be told. Power windows on passenger side window just stopped working in the glove compartment IS where the 2ND air filter and can't find the right air filter that fits. car sound system would stop working at times. Updated 6/13/18*jb
- Electrical system · Visibility › Power window devices and controls
When I tried to roll the passenger window down, a plume of smoke came out of the master control panel. At first, I thought I was imagining it, but the button froze into place. I took my scion into a dealership for 2 recall notice repairs (driver's seat railing and intake manifold assembly) and…
When I tried to roll the passenger window down, a plume of smoke came out of the master control panel. At first, I thought I was imagining it, but the button froze into place. I took my scion into a dealership for 2 recall notice repairs (driver's seat railing and intake manifold assembly) and mentioned the window control panel problem and my concern as to whether or not there was a risk of a fire. the service tech said that my car was not part of the recall? I am concerned as to whether or not my car IS going to catch on fire and am curious to know if this has been an ongoing problem with the newer model scion xds? *tr
- Electrical system · Visibility
While car running on the local road, approx. 40 mph, rear window from driver side rolled down itself and a lot of smoke started coming out from power window master switch controls and from driver side window, inside. Two of four switches from master switch control then melted and pushed all the way…
While car running on the local road, approx. 40 mph, rear window from driver side rolled down itself and a lot of smoke started coming out from power window master switch controls and from driver side window, inside. Two of four switches from master switch control then melted and pushed all the way down, seems like the bottom part of those switches caught fires or something, however, no fire was visible from the exterior. Was then pulled to the business parking lot and turned off the engine. The smoke then slowly stopped. car towed to and parked at local toyota/ scion dealer side way, service consultant checked my vin and informed that there was no recall for this particular vin. (Visibility: power window devices and controls recall date: 10/10/2012 does not include this particular vin) was then contacted scion recall same day and they started a fire case for investigation, 3 days later case manager letting me know that to complete their investigation of the causes could take up to a month? They wanted to hold my car at the dealer until investigation IS completed, without an estimate of completion date and they offered no loaner car or rental reimbursement? why nhtsa campaign number: 12v491000 -- affected -- toyota scion xd 2008-2009 -- then why this vin with the same defective was not part of the recall? *tr
- Visibility › Power window devices and controls
TL* the contact owns a 2009 scion xd. the contact stated that after pushing the driver's side power window button, the window opened and failed to close. the contact attempted to close the window but failed after numerous attempts. The failure occurred on numerous occasions. The dealer informed…
TL* the contact owns a 2009 scion xd. the contact stated that after pushing the driver's side power window button, the window opened and failed to close. the contact attempted to close the window but failed after numerous attempts. The failure occurred on numerous occasions. The dealer informed the contact that the vehicle was not included in nhtsa campaign number: 12v491000 (visibility). The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 36,000.
- Engine · Service brakes
I have a 2009 scion xd with only 26,000 and a clean title. The vehicle would not accelerate over 40 mph which nearly got me in a major accident on the freeway. Turns out the water pump was the culprit and scion would not acknowledge the faulty pump despite countless complaints against it. After…
I have a 2009 scion xd with only 26,000 and a clean title. The vehicle would not accelerate over 40 mph which nearly got me in a major accident on the freeway. Turns out the water pump was the culprit and scion would not acknowledge the faulty pump despite countless complaints against it. After paying for a new water pump to be installed, I noticed something from the undercarriage hitting the road while driving at 40 mph. The noise got worse and worse and a something came out and flew off the car, nearly hitting the vehicle driving behind me and caused them to swerve. I immediately pulled over. Plastic and rubber parts from near the wheel well were mangled and falling off the vehicle. I took it to a mechanic who said the cheap plastic and fasteners were poorly constructed and attached to close to the brakes which cause them to become destroyed every time I made sharp turns. In addition to this, after solving the problem, it happened again on the freeway the very next day, except on the passenger side. Scion will not take responsibility for poor construction and cheap parts that could have gotten someone killed. *js
- Electrical system · Latches/locks/linkages
About a year after I bought the car (at concord toyota, concord, ca), my power locks started malfunctioning one by one. They fixed it because I was still on the factory warranty, but a year later, the front locks stopped working again. They were fixed. In 2013, the two front locks stopped working…
About a year after I bought the car (at concord toyota, concord, ca), my power locks started malfunctioning one by one. They fixed it because I was still on the factory warranty, but a year later, the front locks stopped working again. They were fixed. In 2013, the two front locks stopped working again. The problem IS, now I don't have any warranty coverage and they want to charge me around $500 to fix each lock. Not only IS it not fair because it's been something that's been happening continuously for years, but now the back door locks stop and start working at random all the time. I would appreciate it if you could help me with this issue. *js
- Engine
Leaking water pump. the pump starting leaking around 31,000 miles. it was a minor weep from the drain hole at the bottom of the pump at that time. at 40071 miles the pump needed to be replaced. warranty on the xd had lapsed by four months. toyota would not reimburse for repair. *tr
- Vehicle speed control
When passing another vehicle I stepped on the gas pedal too quickly, down shift to passing speed and the gas pedal stuck to the floor. I had to shift into neutral and pull the pedal back up with my toe. this has happened about 4 times in the past, each time when stepping on gas pedal quickly to pass. fortunately, I do not need to speed up quickly to pass often.
- Fuel/propulsion system · Vehicle speed control
Major loss of vehicle power on the highway about 20 times the past few weeks. luckily, each time, I managed to get into the breakdown lane without an accident occurring. turning off and on the vehicle sometimes returned it to normal operation. some times, the enginewas 'racing' when the car was…
Major loss of vehicle power on the highway about 20 times the past few weeks. luckily, each time, I managed to get into the breakdown lane without an accident occurring. turning off and on the vehicle sometimes returned it to normal operation. some times, the enginewas 'racing' when the car was turned back on. and other times, I had to performmultiple off-on cycling of the engine before normal behavoir was restored. the check engine light was illuminated when the problem occurred. this behavior also occurred a few times last yearbut since the check engine light did not remain on, I wasn't sure that the dealer would be able to reproduce or diagnose the problem. I'm not sure whether or not the recent hot weather was associated with the problem to occurring more frequently. I made an appointment with acton toyota for 7/20/2013. they diagnosed the problem as being caused by a failed throttle body and parts are on order. they said that the repair would be $1300. So, I'm now researching whether this defective part should be replaced under the customer service program of the toyota economic loss settlement that received final approval by the federal court on 7/19/2013. it IS unacceptable for a throttle body to fail on a vehicle with only 36K miles and 4 years old. *tr
- Fuel/propulsion system · Structure › Body · Vehicle speed control
On nov 11, 2012 I was backing into my driveway when I felt something under my foot accelerate. my scion surged backwards out of control. by the time I got it stopped I had run over and destroyed my picnic table also doing damage to the back of my vehicle. when I got a postcard a couple days ago regarding sudden acceleration I realized was toyota was having a problem with acceleration and I should report it. *tr
- Air bags
TL* the contact owns a 2009 toyota scion xd. While driving approximately 45 mph, the contact struck an animal in the middle of the road and immediately swayed off of the road over an embankment. The vehicle went airborne and landed at an 90 degree angle where the front end crashed towards the…
TL* the contact owns a 2009 toyota scion xd. While driving approximately 45 mph, the contact struck an animal in the middle of the road and immediately swayed off of the road over an embankment. The vehicle went airborne and landed at an 90 degree angle where the front end crashed towards the ground. The driver suffered from a broken nose and sustained bruises to the face. The air bag failed to deploy. The vehicle was towed to a collision center. The manufacturer scheduled an appointment for an engineer to perform an investigation related to the defective air bags. The vehicle had not been repaired. The approximate failure mileage was 60,000. ... Updated 02/28/13 *bf the vehicle was totaled. Updated 03/11/13
- Service brakes, hydraulic
My brakes on my 2009 scion xd started make noise at about 25,000 miles , brought to dealer . Was told that brakes go bad all the time at 25,000 miles.well that's a red flag to start with. then I was told that I must ride my brakes . I only have one leg so that would be very hard to do. they…
My brakes on my 2009 scion xd started make noise at about 25,000 miles , brought to dealer . Was told that brakes go bad all the time at 25,000 miles.well that's a red flag to start with. then I was told that I must ride my brakes . I only have one leg so that would be very hard to do. they pulled my brakes off and found that I still had about 5MM of pad and my rotors needed turning and I needed new pads . Well I still had pads left but the rotors still needed turning. so I think that there IS something wrong with the rotors to fail that fast and I was told that this happens all the time. I had the work done at avondale toyota 10005 w papago freeway avondale, 85323 . It cost me 245.21 to fix something that wore out way to soon invoice # [xxx] maybe there should be a recall on this before someone gets killed. information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *tr
- Tires
Frequent loss of air pressure in tire. local tire company checks tire and reported that it IS defective. replaced tire. *Tr
- Vehicle speed control
My sister's toyota scions xd was involved in a multi cars accident on sept. 9, 2010 around 6:00 pm. the scions was first involved into 1 sudden and right afterward the car suddenly accelerated closed to 100 mph and it went about quarter mile before it hit another car. it finally stopped when the car hit a road guide. *tr
- Tires
Tl*the contact owns a 2009 toyota scion equipped with dunlop tires , size 195/16/60r, dot# 3mdr4409. While the contact was driving 40 mph the tire pressure light appeared on the dashboard and within in minutes, the contact noticed that the front passenger side tire was flat. The vehicle was taken to the dealer who stated that the replacement tires were not available. The current and failure mileages were 6500.
- Service brakes, hydraulic › Power assist › Vacuum
Tl*the contact owns a 2009 toyota scion xd which was purchased in 2009 in the state of florida. He reviewed recalls on the internet for his year make and model pertaining to those sold in or currently registered in the "salt states." he stated that he drives the vehicle to new york often, which IS…
Tl*the contact owns a 2009 toyota scion xd which was purchased in 2009 in the state of florida. He reviewed recalls on the internet for his year make and model pertaining to those sold in or currently registered in the "salt states." he stated that he drives the vehicle to new york often, which IS one of the states listed in the recall. He was concerned with his safety because when driving under certain unique conditions in extremely low ambient temperatures, the intake manifold suction port for the brake vacuum could become blocked due to the freezing of condensation resulting from positive crankcase ventilation. He felt the recall should be extended to all states, keeping in mind that people travel and relocate to other states that are listed in the recall. There were no failures. The vin was not accepted. The current mileages was 15,000.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10253223This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.
- 10200383Automatic/Continuously Variable Transmission Replacement Precautions
- 10200379Immobilizer and Smart Key Reset
- 10185779TT: HVAC drain tube is found to be blocked/clogged.
- 10152156TSB: REVISION NOTICE August 23, 2017 Rev1: ? Applicability has been updated to include 2015 model year xB vehicles, 2015 ? 2016 model year tC vehicles, and 2016 model year iM vehicles. ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Introduction. Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX Tip.
- 10134472SB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
- 10133921Scion vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not perform as expected, please follow the steps in the recommendations section below.
- 10133907Some 2008 ? 2012 Scion xD vehicles may exhibit a condition where water from the HVAC case leaks on the carpet if the HVAC evaporator drain is becoming blocked with debris. A new cowl panel has been made available to help prevent debris from entering the HVAC unit. Follow the procedure listed in this bulletin to remove and replace the cowl panel.
- 10133905Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprograming process and outlines use of the TIS and the CUW.
- 10133902When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the rick of further damage to electrical components.
- 10133759Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part.
- 10133702Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX Tip) is now available to help minimize future occurrences of this environmental condition. For some models, a new drain hose is required to properly fit the ARINIX Tip. Follow the procedures in this bulletin for proper handling and installation of this optional service part.
- 10132900TSB: REVISION NOTICE November 10, 2016 Rev1: ? Applicability has been updated to include 2015 model year xB vehicles, 2016 model year iM vehicles, and 2015 ? 2016 tC vehicles. ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2008 ? 2016 model year Scion vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
- 10132774TSB: OBSOLETE NOTICE-June 6, 2014: This bulletin is now obsolete.
- 10132773TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
- 10132725TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
- 10132722TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to reset a vehicle Immobilizer or Smart Key system.
- 10132574SB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
- 10132298If a creak, tick, or rattle noise is heard at the top of the windshield, the source of the noise may be the two windshield stoppers bonded to the top of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield area.
- 10132272Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.
- 10132271Certain service publications, Technical Service Bulletins, Service Campaign Technical Instructions and Service & Parts Operation Communication Bulletins may reference specifically required adhesives and sealants
- 10132270Prior to tire rotation use the quick reference chart below to verify the size of the lug nut and the lug nut torque specifications. The quick reference chart is applicable to current generation vehicles only.
- 10132174Some 2008 ? 2016 model year Scion vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
- 10132165To receive satellite radio functions after the initial trial period has expired, the customer must enter into a contract with XM Satellite Radio Inc. After entering into a contract, registration of an 8-digit XM Radio ID is required. This 8-digit XM Radio ID is found by turning to channel ?0? of the satellite radio.
- 10132141The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
- 10132105The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly.
- 10132070All Scion models may include side airbags as optional equipment. Scion does NOT recommend replacement of original seat covers with non-Scion leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Scion may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Scion leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury.
- 10132050Please refer to the following recommendations for the best practices for vehicle tire rotations.
- 10131996The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
- 10131962Scion vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
- 10111570SSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.
- 10111395SSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the risk of further damage to electrical components.
- 10111375DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had recall campaign repairs completed. We request your dealer's assistance in completing the applicable recall campaign repairs as owners receive the Safety Recall Follow-Up Notices and contact them. Please note the follow-up activity may cause an increase in current recall campaign owner appointments. Toyota will continue with additional follow-up activities in the months to come.
- 10111371RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates.
- 10111360SSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. These wrinkles sometimes trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces, such as the hood, roof, and trunk. Stains can be removed by heating the stained surface to remove the trapped moisture.
- 10111224SSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. These wrinkles sometimes trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces, such as the hood, roof, and trunk. Stains can be removed by heating the stained surface to remove the trapped moisture.
- 10111202SSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the risk of further damage to electrical components.
- 10111187SSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.
- 10111109DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had recall campaign repairs completed. We request your dealer's assistance in completing the applicable recall campaign repairs as owners receive the Safety Recall Follow-Up Notices and contact them. Please note the follow-up activity may cause an increase in current recall campaign owner appointments. Toyota will continue with additional follow-up activities in the months to come.
- 10111105RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates.
Every Scion XD model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.