2021 Thomas Built Buses Saf-T-Liner Efx
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Thomas Built Buses › Saf-T-Liner Efx › 2021
These records cover every 2021 Thomas Built Buses Saf-T-Liner Efx. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2021 Thomas Built Buses Saf-T-Liner Efx. Newest first.
Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2019-2022 Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, Minotour DRW, 2020-2022 Saf-T-Liner C2 Jouley, and Minotour SRW school buses. The Emergency Exit Label lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements…
Risk and remedy
Risk
Emergency exit labels that are difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Remedy
Dealers will correct the lettering, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL918.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2011-2023 Thomas Built EFX and HDX school buses. The exterior roof panel was manufactured with insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."
Risk and remedy
Risk
A school bus exterior roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.
Remedy
Dealers will add additional mechanical fasteners to secure the joints, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL957.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2014-23 Thomas Built Buses HDX and 2014-22 EFX school buses equipped with 39-inch S3C seat frames and 3-point flex seatbelts. The passenger seat frames may crack and rotate from fatigue.
Risk and remedy
Risk
Cracked passenger seat frames may not adequately secure passengers in the event of a crash, increasing the risk of injury.
Remedy
Dealers will secure the seat frames with brackets, free of charge. Owner notification letters were mail December 4, 2023. Owners may contact DTNA's customer service at 1-800-547-0712. DTNA's number for this recall is FL946.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Thomas Built Buses Saf-T-Liner EFX School Buses. The passenger seat mounting bolts may break due to improperly placed mounting that allows contact with the chassis cross member bolts. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety…
Risk and remedy
Risk
A seat with broken mounting bolts may not properly restrain an occupant in a crash, increasing their risk of injury.
Remedy
Dealers will add a spacer to provide proper clearance between the passenger seat mounting and chassis cross member bolts, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-921.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2022 Thomas Built EFX and HDX school buses. The nut for the power cable stud on the alternator may not have been tightened properly, which can cause a loose cable connection.
Risk and remedy
Risk
A loose power cable connection may cause electrical arcing, which can increase the risk of a fire.
Remedy
Dealers will inspect the alternator power cable connection and tighten it if necessary, free of charge. Owner notification letters were mailed on December 17, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL904.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner EFX, and Saf-T-Liner HDX school buses. The steering arm and tie rod bolts may have a defective seam that can fracture.
Risk and remedy
Risk
A fractured bolt may cause a loss of steering, increasing the risk of a crash.
Remedy
DTNA will notify owners, and dealers will replace the tie rod arm bolts and steering arm, free of charge. The recall began on June 10, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-884.
Daimler Trucks North America, LLC (DTNA) is recalling certain 2021 Thomas Built Buses Saf-T-Liner HDX and EFX school buses. On certain vehicles, one of the six brake caliper mounting bolts on the driver side steer axle may have been incorrectly tightened.
Risk and remedy
Risk
The loose bolt could result in the other caliper bolts to loosen. Insufficiently tightened bolts may not provide adequate clamping force between the brake caliper and brake anchor plate, resulting in reduced brake effectiveness, increasing the risk of a crash.
Remedy
DTNA will notify owners, and dealers will inspect and repair as necessary, free of charge. The recall began March 17, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-873.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011106Service Solution for Power steering Pump TBB 61280827 replacement with TBB 246122
- 11011076Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
- 11010192Extended Warranty Policy for certain Cummins B6.7 engines for TBB vehicle DEF headers for EPA and CARB Emissions Reporting
- 11010186CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
- 11008508Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
- 10251202Important Campaign Information letter for FL974 - Revised Bulletin & Population
- 10251200Revised Emissions Recall: Cummins DEF Sensor Shortage. REVISION: Some vehicles formerly in Group F have been moved to Group G and have been assigned a new part number as specified in Table 1. An SRT for 'Calibration Code Only: Update or Confirm' has been added, as shown in Table 2, to be used when a new DEF header is not required. There have been some other minor changes to the work instructions and SRT times.
- 10249516Emissions Recall: Cummins DEF Sensor Shortage
- 10199357Thomas Built Buses Product Awareness Bulletin on MY2021 Cummins B6.7 Containment Plan
- 10193754Thomas Built Buses Product Awareness Bulletin on School Bus Lettering
- 10193743Thomas Built Buses Product Awareness Bulletin on Lettering Changes - Notification
- 10193738Thomas Built Buses Product Awareness Bulletin on Heater Hose Changes
- 10193736Thomas Built Buses Product Awareness Bulletin on National Drivers Seat Update
- 10193733Thomas Built Buses Product Awareness Bulletin on Defender Composite Stop Arm Changes
- 10193728Thomas Built Buses Product Awareness Bulletin on PV360 NS Camera Type D
- 10193726Thomas Built Buses Product Awareness Bulletin on Buy America Cummins B6.7 Engine
- 10193723Thomas Built Buses Product Awareness Bulletin on Roof Top Lettering (Addendum)
- 10193722Thomas Built Buses Product Awareness Bulletin on 12V Outlets Update
- 10193716Thomas Built Buses Product Awareness Bulletin on Power Outlet
- 10193702Thomas Built Buses Product Awareness Bulletin on Data Book Update
- 10193697Thomas Built Buses Product Awareness Bulletin on Lettering Update
- 10193696Thomas Built Buses Product Awareness Bulletin on Allison 7 Year Warranty
- 10193682Thomas Built Buses Product Awareness Bulletin on Freedman Seating Update
- 10193677Thomas Built Buses Product Awareness Bulletin on Slide n Click Update
- 10193653Thomas Built Buses Product Awareness Bulletin on Lamp Monitors
- 10193602Thomas Built Buses Product Awareness Bulletin on ESC Update EFX and HDX
- 10193580Thomas Built Buses Product Awareness Bulletin on Corrosion Protection EFX & HDX
- 10189319Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
- 10187529Important Campaign Information Letter for Dealer Travel for Campaign Performance TBB.
- 10187440Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
- 10184029Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
- 10183988Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
- 10180350Tech Talk discussion about power steering fluid.
- 10178006Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customers location to perform a recall or field service campaign.
- 10177979Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
- 10177838Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
- 10177653Warranty Information Letter for Detroit and TBB Parchment Format Update. In the continuing effort to standardize across brands, DTNA is pleased to announce that Detroit Diesel Corporation (Detroit) and Thomas Built Bus (TBB) parchments will be transitioned to the format used for Freightliner, Freightliner Custom Chassis Corporation (FCCC), and Western Star. DTNA's goal is to improve and align documentation but individual coverages have not changed. Updated parchments, also known as coverage sheets, will be published on a rolling basis.
- 10177648Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
- 10174376Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
- 10174061Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Every Thomas Built Buses Saf-T-Liner Efx model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.