2023 Thor Motor Coach Gemini
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Thor Motor Coach › Gemini › 2023
These records cover every 2023 Thor Motor Coach Gemini. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2023 Thor Motor Coach Gemini. Newest first.
Thor Motor Coach (TMC) is recalling certain 2023 Gemini and Compass motorhomes. Washers were not installed with the roof mounting brackets.
Risk and remedy
Risk
Without washers, the solar panel can detach and become a road hazard, increasing the risk of a crash.
Remedy
Dealers will inspect and install washers on the mounting brackets as necessary, free of charge. Owner notification letters were mailed February 26, 2025. Owners may contact TMC customer service at 877-855-2867. TMC's number for this recall is RC000322.
Thor Motor Coach (TMC) is recalling certain 2022 Scope, Tellaro, Sanctuary, Delano, Sequence, Tranquility, Rize, Synergy, Quantum, Magnitude, Geneva, Compass, Chateau, Four Winds, and 2022-2023 Tiburon, and Gemini vehicles. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.
Risk and remedy
Risk
A gas leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed June 27, 2022. Owners may contact TMC customer service at 1-877-855-2867.
Owner complaints
2 complaints
What owners report most
Latest complaints
- Electrical system · Equipment · Structure
The contact owns a 2023 Thor Motor Coach Gemini. The contact stated that the wire connecting the solenoid to the generator was burned. The solenoid was making a cranking sound while turned off. The contact stated that the head bolts had fractured and detached on the side awning rails on both sides.…
The contact owns a 2023 Thor Motor Coach Gemini. The contact stated that the wire connecting the solenoid to the generator was burned. The solenoid was making a cranking sound while turned off. The contact stated that the head bolts had fractured and detached on the side awning rails on both sides. The skylight window was leaking water into the cabin of the camper. The contact stated that there was a warning informing the contact that the motorhome was due for an oil change that occurred earlier than expected. The contact received notification of NHTSA Campaign Number: 25V097000 (Structure, Equipment); but had not taken the motorhome to the dealer to be repaired under the recall. The dealer was contacted, and warranty coverage was discussed; however, there were no final decisions made. The motorhome was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the dealer. The failure mileage was approximately 1,478.
- Forward collision avoidance › Warnings · Lane departure › Warning · Vehicle speed control › Cruise control
Purchased October 8 2022. Vehicle is a 2023 Thor Gemini 24KB on a 2022 Ford chassis. Vehicle has been in for repair of these items for over 30 days. Vehicle warning light notifications - Antilock Brake Fault Hill Start Assist Warning Pre-collision Assist Not Available Adaptive Cruise Control Not…
Purchased October 8 2022. Vehicle is a 2023 Thor Gemini 24KB on a 2022 Ford chassis. Vehicle has been in for repair of these items for over 30 days. Vehicle warning light notifications - Antilock Brake Fault Hill Start Assist Warning Pre-collision Assist Not Available Adaptive Cruise Control Not Available All Wheel Drive Not Available. It was viewed by Ford technicians. It is stated by Ford technicians the vehicle is not safe to operate. Problem first appeared November 2022.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10220385Wood stiles are delaminating due to the vendor changing the glue used for the wrapped stiles.
- 10214142This is the print that is associated with the previous submission for TSB 22-08. I forgot to attach both documents
- 10214139Gemini/Compass E-start is not wired correctly.
Every Thor Motor Coach Gemini model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.