2021 Thor Motor Coach Hurricane
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Thor Motor Coach › Hurricane › 2021
These records cover every 2021 Thor Motor Coach Hurricane. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2021 Thor Motor Coach Hurricane. Newest first.
Thor Motor Coach (TMC) is recalling certain 2018-2021 Hurricane and Windsport recreational vehicles. The driver and front passenger overhead cabinets may detach.
Risk and remedy
Risk
Overhead cabinets that detach while the vehicle is in motion can fall onto seat occupants, increasing the risk of a crash or injury.
Remedy
Dealers will inspect and reinstall the overhead cabinets, if necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000290.
Thor Motor Coach (Thor) is recalling certain 2019-2021 Hurricane and Windsport motorhomes, models 27B, 29M, 32T, 33X, 34J, 34R and 35M. The electronic control center circuit board may be damaged from voltages over 17 volts causing damage to the circuit board.
Risk and remedy
Risk
A damaged circuit board could increase the risk of a fire.
Remedy
Thor will notify owners, and dealers will add an additional circuit module to the existing component board to provide reverse polarity and over-current protection, free of charge. The recall began October 20, 2020. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000203.
Owner complaints
2 complaints
What owners report most
Latest complaints
- Engine and engine cooling
See attached document for complaint.
- Engine · Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor · Unknown or other
The floor on my coach above the Catalytic converter has become soft. I am being told it is from the heat from the Catalytic converter. O called Thor and was told there should be a heat shield there campong world of Ashville says there is not a heat shield on it I have a picture no shield is…
The floor on my coach above the Catalytic converter has become soft. I am being told it is from the heat from the Catalytic converter. O called Thor and was told there should be a heat shield there campong world of Ashville says there is not a heat shield on it I have a picture no shield is present. I mistakenly told them something was cutoff during a recall I thought it was aa heat shield but it was something around the radiator. I have all service records nothing has been done around the Catalytic converter area. From other post on Thor forums this problems seems to exist in several of thor models. I have even read this could cause a fire and since it is at the exit door I would think they would take care of a problem that is probably less than $1000 to fix especially since their product is close to $200,000
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10197977On your vehicle, the rear axle may contain an inadequate volume of lubricating oil. An inadequate volume of rear axle lubricant may result in rear wheel bearing damage potentially leading to bearing seizure. Bearing seizure may lead to rear axle or driveshaft failure. A rear axle or driveshaft failure may result in loss of vehicle motive power, loss of transmission park function, and loss of parking brake function, increasing the risk of a crash. This affects the following Thor Motor Coach products: model year 2021/2022 Ace, Challenger, Freedom Traveler, Hurricane, Miramar, Outlaw, and Windsport motorhomes
- 10179806On certain model year 2021 Hurricane & Windsport Motorhomes built on a 2020 Ford F53 Chassis, the fog light relay will buzz at a certain voltage range. The fix will be to install a harness to the fog light relay.
Every Thor Motor Coach Hurricane model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.