1992 Volkswagen Corrado
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volkswagen › Corrado › 1992
These records cover every 1992 Volkswagen Corrado. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 1992 Volkswagen Corrado. Newest first.
Vehicle description: passenger vehicles equipped with VR6 engines. a coolant system component such as the thermo switch, radiator fan, or water pump, can malfunction causing the coolant temperature and coolant system pressure to increase significantly. over time, excessive pressure can cause leakage of coolant fromthe system, including leakage from the…
Risk and remedy
Risk
Leakage of hot coolant from the heat exchanger can cause injury to the feet of the driver or steam up the interior of the vehicle temporarily impairing the driver's vision.
Remedy
Dealers will install in the coolant inlet hose to the heater core, a pressure reducer with a 5MM diameter secured by a spring tensioned hose clamp. also a new relay that will change the operation of the secondary electrical coolant pump will be installed. dealers will also perform a functional check of the cooling system to make sure that all cooling system components operate properly.
An engine compartment electrical wiring harness may have been routed too close to a sheet metal edge. The wiring can become damaged during normal vehicle operation due to chafing, resulting in an electrical short.
Risk and remedy
Risk
If a short occurs, either the engine could stall orthe radiator fan could stop operating causing the engine to overheat. Eithercondition could result in a vehicle accident.
Remedy
Reroute and secure various wiring harnesses inside the engine compartment.
The fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.
Risk and remedy
Risk
Fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.
Remedy
Replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.
Owner complaints
50 complaints7 injuries
What owners report most
Latest complaints
- Engine and engine cooling › Cooling system
Dt: consumer was driving and a cloud of smoke came from behind steering wheel. prior to this vehilce had been running hot. consumer took vehicle to dealer for a coolant flush, and had the belt replaced around the fan. also, had a new radiator installed. consumer was in the car 5-10 minutes and the vehicle overheated. the fire department came out when the steering wheel smoked. *ak
- Engine and engine cooling › Cooling system › Radiator assembly
Consumer had the same problem as mentioned in nhtsa recall 98v295000. passenger vehicles equipped with VR6 engines. a coolant system component such as the thermo switch, radiator fan, or water pump can malfunction, causing the coolant temperature and coolant system pressure to increase…
Consumer had the same problem as mentioned in nhtsa recall 98v295000. passenger vehicles equipped with VR6 engines. a coolant system component such as the thermo switch, radiator fan, or water pump can malfunction, causing the coolant temperature and coolant system pressure to increase significantly. over time, excessive pressure can cause leakage of coolant from the system, including leakage from the heat exchanger. Dealer indicated this vehicle was not include in the recall due to the vin. *ak
- Engine and engine cooling › Cooling system
The vehicle experienced the same defect with the engine cooling system as stated in recall 98 v 295 000, but the vin number was not included. *nlm
- Visibility › Defroster/defogger/hvac system › Heater core
The temperature gauge flashed. The consumer heard a noise, and at that point the vehicle's cabin became filled with steam and hot radiator fluid was on the floor board. it was determined the heater core failed. *nlm
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core recall repairs done. 1 year later it broke, causing radiator fluid to leak and front windshield to steam up.*ak
- Engine and engine cooling › Cooling system · Visibility › Defroster/defogger/hvac system › Heater core
Recall work performed and failure immediately occurred. ruptured heater core repaired, but car IS unsafe to drive due to coolant fumes. Dealer refuses to fix recall 98v295000. *ak
- Visibility › Defroster/defogger/hvac system › Heater core
My heater core failed spilling radiator fluid into the passenger compartment and vapor through the hvac system.. I have been told this IS a part that consistantly failed in my type of vehicle and am hoping that the manufacturer of the vehicle will be responsable and replace the part as a recall issue.*ak
- Exterior lighting › Fog lights · Visibility › Rearview mirrors/devices › Exterior
Fog lights overheat. vwoa has refused hella oem fog light replacement design. heated outside rear view mirror delaminates.*ak
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core located behind ventilation system blew up, hot coolant hit vent and white smoke and coolant entered into vehicle, chemicals were very strong. took vehicle to dealer ,and they will replace heater core, consumer indicated that he could have been injuried, because liquid was hot,consumer…
Heater core located behind ventilation system blew up, hot coolant hit vent and white smoke and coolant entered into vehicle, chemicals were very strong. took vehicle to dealer ,and they will replace heater core, consumer indicated that he could have been injuried, because liquid was hot,consumer was temporarily blinded by white smoke.*ak consumer stated the dealer finally replaced the heater core after numerous complaints.*slc
- Electrical system › Ignition › Switch · Visibility › Defroster/defogger/hvac system › Heater core
Ignition switch and the heater were repair with used parts and still failed. *ak
- Steering › Rack and pinion
Parts were not defective until other repair was done not relating to this part of car IS fault of dealer but must be repaired at my own expense! Dealer service takes no blame and will not negotiate .
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core has malfunctioned, causing hot fluids to enter into passenger's compartment from vent which caused windows to steam up. also, consumer mentioned recall 98v295000. Consumer not sure if this vehicle was subject to recall. Please provide any further details. *ak
- Visibility › Defroster/defogger/hvac system
While driving at 30mph steam came out thru vents (no visivility) and hot coolant came in from behind the dashboard burning me and my wife's feet, impairing vehicle control, almost causing an accident due to hot water and lack of visibility. according to VW a recall was performed to prevent this from happening on july 30, 1999 and the vehicle had 63,376 miles on it at the time. Now the vehicle has 68,505 miles. *Ak
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core failed causing steam to enter vents of vehicle.
- Electrical system › Wiring › Front underhood
Would like to know if VW IS responsible on fixing the recalls and anything related to them? No safety defect mentioned in summary. *ak
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core leaked into passenger's compartment and steamed up the interior of the car. This caused the consumer to nearly be burned even after recall repairs were done. Took to dealer in response to a recall letter to install coolant pressure throttle unit, and did a check on coolant system. This was suppose to prevent the problem from happening. *Ak
- Engine and engine cooling › Cooling system
Just like to know on what parts IS VW responsible for and if a problem has been affected from a recall, do they pay? And to see if it IS worth purchasing a '92 corrado slc. No safety defect mentione din summary. *ak
- Engine and engine cooling › Cooling system
Vehicle keeps overheating and coolant leaked out into the passenger's seat from the dash. Dealer can't find solution. *ak
- Service brakes, hydraulic › Foundation components › Master cylinder
When applying brakes pedal gets hard, and at other times pedal goes to the floor. Dealrr said that master cylinder needed to be replaced. *ak
- Engine and engine cooling › Cooling system
Recal 98v295000, vw/engine coolant system; the vehicle was corrected on may 19, 1999 under notice. Three weeks later vehicle needed repair again. Manufacturer IS refusing to correct for the second time free of charge. *ak
- Power train › Clutch assembly
My 2ND gear synchro IS failing due to what I believe IS a defective clutch from the manufacturer. the factory clutch does not have ni or cd plated splines, exacerbating shifting problems
- Visibility › Defroster/defogger/hvac system › Heater core
Heater core failed, causing windows to fog up, affecting driver's visibility.
- Visibility › Defroster/defogger/hvac system
No summary listed for this vehicle. *ak
- Visibility › Defroster/defogger/hvac system › Heater core
Vehicle overheated due to a heater core failure and released a large amount of steam, water and coolant into the occupant compartment of the vehicle.
- Visibility › Defroster/defogger/hvac system › Heater core
Heating core failed.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Heater core repture
Heater core allegedly ruptures and releases hot coolant into the vehicle interior, resulting in impaired visibility and potential burn injuries to occupants.
- Heater core rupture
Heater core allegedly ruptures and releases hot coolant into the vehicle interior, resulting in impaired visibility and potential burn injuries to occupants.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10213836Airbag Issues.
- 10159010The part number listed in the document is to be returned if it meets the criteria provided.
- 10157383VAS 6154 Replacement Part Setup Guide
- 10155644This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.
- 10128105This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- 10128104This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- 10128055This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests.
- 10126785Update model year applicability to include 2017.
- 10026848Volkswagen: exhaust heat shield, replacement guidelines. Heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced.
- 621613Subject regarding latch system lower anchors and tethers for children, installing / retrofitting.
- 53604Conditions with engine intermittently will not start.
Every Volkswagen Corrado model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.