1999 Volkswagen New Beetle
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volkswagen › New Beetle › 1999
These records cover every 1999 Volkswagen New Beetle. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 1999 Volkswagen New Beetle. Newest first.
On certain passenger vehicles, the brake lamp switch may malfunction.
Risk and remedy
Risk
If this happens, the brake lamps could become inoperative; or the lamps could come on and stay on, even though the vehicle IS parked.
Remedy
Dealers will inspect and, if necessary, replace the brake lamp switches. Owner notification began september 26, 2003. owners should contact vwoa at 1-800-822-8987.
Owner complaints
34 complaints2 involved a crash2 injuries
What owners report most
Latest complaints
- Electrical system › Wiring › Interior/under dash
Defective or incorrect dashboard instrument cluster and repeated failures of sensors and other miscellaneous electrical switches.*ak
- Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
Nar 02/28/2003 mr the consumer has had ongoing problem with the catalytic converter, and the emissions control system. *cb
- Seats › Front assembly › Recliner
Drivers seat adjuster bolts fell out, resulting in drivers seat silding fully to rear and seat coming off tracks. The drivers seat slid all the way to the back seat and I was looking at the roof with no ability to reach the brake, clutch, or accelerator pedals. My ability to steer the vehicle was severly impaired. *Ak
- Structure · Visibility › Sun/moon roof assembly
The roof cover IS falling down. the glue that IS use to keep the cloth attached to the roof IS very poor and after 3 years it will start to fall down. I have 2 identical VW beetle's and they both suffer from this problem. *jb
- Latches/locks/linkages › Hatchback/liftgate › Lock
Remote hatchbatch lock release failure.
- Service brakes, hydraulic › Foundation components › Disc › Rotor
At less than 27K miles, I had to replace the brake pads and rotors. The dealer said the rotors for the new beetle are notoriously thin, and have to be replaced almost as often as the brake pads. This repair cost me $950. My roommate, another VW new beetle owner had the same problem at 31K, many other complaints were registered on beetlebuzz.com, when it was in operation. *Ak
- Exterior lighting › Headlights › Concealment devices
Low beam headlight on drivers side no longer functions. Dealer states cracked housing allowed water in which in turn burned out bulb. Judging by the number of new beetles I see with one head light out this appears to be a common problem. *jb
- Electrical system › Wiring › Fuses and circuit breakers
My 1999 volkwagen beetle has a melted fuse block on top of the battery. I believe this was caused by the fuses being faulty as one leg of the fuse was completely burned off and the fuse was still not blown. I believe this IS a fire hazard that should be looked into. On the website newbeetle.org, there are several more instances of this occurring including photos. *Ak
- Electrical system › Wiring › Interior/under dash
Consumer states that instrument cluster failed. it does not register readings for the vehicle speed or rpms.*ak
- Engine and engine cooling › Engine
I was driving down the expressway at about 55 mph, when my steering wheel locked up, and my car went up on the center divider. I could not steer my car off the divider, and the brakes weren't working as well either. I imagine what happened was that the engine stopped and my car powered off…
I was driving down the expressway at about 55 mph, when my steering wheel locked up, and my car went up on the center divider. I could not steer my car off the divider, and the brakes weren't working as well either. I imagine what happened was that the engine stopped and my car powered off without warning (the car has a history of failed warning lights or warning lights going on for no reason, having the instrument panel replaced once, but not solving the problem). my car ended up spinning out across the road and slamming into a tree on the passenger side. if the timing was different by a split-second, I would have probably hit the tree with the driver's side, or slammed head-on into a light pole. my car was totaled and I split my head open and had to get stitches. I am very lucky to be alive. I have had nothing but problems with this car, and another one of it's stupid failures almost killed me. *jb
- Engine and engine cooling › Exhaust system
Mass air flow sensor failed. *nlm
- Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap
Remote fuel door release failure- 2ND occurrence. First occurrence about a year previous and was dealer repaired. Unable to fuel vehicle.
- Latches/locks/linkages › Hatchback/liftgate › Lock
Remote hatchbatch lock release failure- 2ND occurrence. First occurrence about a year ago and was dealer repaired.
- Air bags
While driving on an icy road at 20 mph my car skidded of the road and hit a tree head on. The car will be most likely totaled, and I received injuries to my leg, back, shoulder and neck. although my car IS equipped with both front and side air bags, not one of them deployed. I mentioned the car…
While driving on an icy road at 20 mph my car skidded of the road and hit a tree head on. The car will be most likely totaled, and I received injuries to my leg, back, shoulder and neck. although my car IS equipped with both front and side air bags, not one of them deployed. I mentioned the car received massive damage, yet the air bag system did nothing to lessen my injuries because they didn't work as I hoped. I purchased my VW beetle with the safety features in mind, but I now have learned that numerous complaints about the non deployment of air bags IS common. I feel fortunate that my injuries were not life threatening, yet feel cheated that my vehilcle's safety features did not work when I needed them most. dt
- Electrical system › 12v/24v/48v battery › Cables
Consumer statedthe design of the battery cable assembly could possibly start a fire under the vehicle's hood. the battery cable was situated on top of the battery along with the fuse box. this resulted in the cable being "eaten" through and drained the battery. consumer had to replace battery, cable twice and fuse box once. Ts *tt
- Structure › Body › Hood
The hood latch has failed twice, including the original and a replacement. the hood pops open while driving, once at 55 mph and another time at 65 mph. after this occurs, the latch will no longer work, and it IS impossible to close the hood fully. the safety hook on the latch IS the only thing…
The hood latch has failed twice, including the original and a replacement. the hood pops open while driving, once at 55 mph and another time at 65 mph. after this occurs, the latch will no longer work, and it IS impossible to close the hood fully. the safety hook on the latch IS the only thing that will engage. the vehicle IS scheduled to be taken in for a third latch replacement on oct. 30, 2002, which IS the earliest date that the dealer can schedule the repair. mr
- Engine and engine cooling › Exhaust system
The 1999 new beetle has been a nightmare (lemon). Its reliability / safety / enviromental impact IS poor. Please assist new bettle owners. VW assistance / knowledgement has been non existent.*ak
- Vehicle speed control
While operating the vehicle on the expressway with the cruise control on, the brake was applied and the cruise control failed to disengage. Driver turned cruise control off manually to avoid accident. Problem was reported to dealer who advised that there was a faulty brake light switch and that the…
While operating the vehicle on the expressway with the cruise control on, the brake was applied and the cruise control failed to disengage. Driver turned cruise control off manually to avoid accident. Problem was reported to dealer who advised that there was a faulty brake light switch and that the vehicle also had no brake light activation. There IS no warning light to advise of problem with brake system. Dealer employee advised there are numerous incidents and switch has been redesigned at least once. No recall or notice of this safety problem has been sent. This problem could lead to a serious high speed accident, as cruise does not disengage when brake pedal IS depressed to stop or slow vehicle. Upon release of brake vehicle surged and accelerated forward to regain speed. VW IS aware of this and IS concealing this problem to avoid notification/recall.*ak
- Fuel system, gasoline › Fuel injection system
Iam reporting this beacuse the engine stopped without warning at 55 mph while passing on an express way. the car would not restart. The car restsrted after ten minutes. This has occurred again but at lower speeds. I have not been to a dealer with the problem as yet. For my oen convience the car will be taken to newton morotsprots route 206 newton, nj tel 973-383-2626 this am. *Ak
- Visibility › Power window devices and controls
This appears to be a very common problem. the window regulator system IS clearly defective and IS expensive to fix. time-consuming and expensive even for a do-it-yourselfer.*ak
- Visibility › Power window devices and controls
Power window switch breaks and must be replaced often. we know many new beetle ownwers - nearly all have had the problem. window can stick down and not be closeable, in any weather, in any area - definite security problem in the wrong neighborhood. ours was fixed on warranty less than 10,000…
Power window switch breaks and must be replaced often. we know many new beetle ownwers - nearly all have had the problem. window can stick down and not be closeable, in any weather, in any area - definite security problem in the wrong neighborhood. ours was fixed on warranty less than 10,000 miles ago - problem IS so common that we are buying extras to carry with us. VW IS definitely aware of the problem and IS silent. four years worth of cars have been produced with the same defective switch, and current production IS unchanged, to my knowledge. thanks for your time. *ak no summary listed for above vehicle. *ak
- Electrical system › Wiring › Fuses and circuit breakers
Cooling fan fuse holder assembly sit on top of the battery in the engine compartment. this holder has a history of failure (according to the mechanic at the dealership). in many cases the fuse does not make adequate contact and may spark over time. in my case the fuse arched and melted the assembly. this IS troublesome given the close proximity to the explosive gases which are generated by the battery. *ak
- Power train › Automatic transmission
Since purchased the vehicle has been slow to shift into gear from park or neutral, the consumer has had near accidents on several occasions, the dealer has not been able to repair the problem. nlm
- Power train · Vehicle speed control
Runaway engine - engine speeded, tachometer to red line. *ak
- Air bags › Frontal › Sensor/control module · Electrical system · Engine and engine cooling › Engine · Fuel system, gasoline › Storage › Tank assembly · Seats
At various speeds vehicle will stall out and die without warning. dealer has repaired electrical system, and fuel tank. but, problem still exists vehicle experiences oil leaks. air bag light IS on, dealer secured loose connector clear codes. passenger seat would not move up or down. trunk very hard to close, dealer adjusted upper and lower trunk lock assembly. *slc
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10007885Driver and passenger door window regulator repairing. Additional information regarding door window, separates from window regulator clamps.
- 10007712Evaluating fuel mixture diagnostic trouble codes (dtc) - how to perform effective diagnostic related to fuel system adaptation system too rich/ too lean. Volkswagen.
- 10007711Evaluating fuel mixture diagnostic trouble codes- how to perform effective diagnosis related to fuel system adaptation - system too rich/too lean. Volkswagen.
- 10006057New style brake light switch requires care during installation to prevent damage to switch.
- 10004523Safety recall - wt - brake light switch.
- 10004522Safety recall - wt - new beetle brake light switch.
- 10001570Driver and passenger door window regulator repairs.
- 10000544Malfunction indicator light on with diagnostic trouble codes p0410, p0411, p1200, or p1423 stored.
- 10000542Malfunction indicator light on with diagnostic trouble codes (dtc) p0410, p0411, or p1423 stored in dtc memory.
- 633842Fresh air blower motor, inoperative at ambient air temperatures near or below freezing.
- 626970Some vehicles may experience instrument cluster malfunction. *Slc
- 621623Subject regarding malfunctioning instrument cluster.
- 621613Subject regarding latch system lower anchors and tethers for children, installing / retrofitting.
- 621611A condition may exist with coolant leaking from the coolant reservoir bottle wiring connector contaminating the wiring harness and / or contamination resulting in various malfunctions of the instrument planel.
- 612477Information regarding the installation of the grounding strap during replacement of the fuel tank. *Mjs
- 612470Customers may complain of a humming noise from general area of the front end during cornering, on vehicles with 02J transmissions. *Mjs
- 612463Vehicles may experience no air flow adjustment at center air outlet (s). *Mjs
- 612442Information regarding the repair of the headlight electrical connection. *Mjs
- 610584Information containing a component ground identification chart which lists ground locations that have been integrated into the repair information system.
- 608348Information on vehicle's exhibiting wind noise/whistle from instrument panel area. Mjs
- 608346Information on radio serial number/code, sticker location on vehicle's begining with vin #'s: golf/ jetta (1999, 2000, 1h_xm215697), new golf/ new jetta (1999,2000 all), new beetle (1999-2000-1c_wm024452), cabrio (1999-2000- 1 h _xm215697), passat (1999,2000 all). Mjs
- 608345Information regarding vehicle's that exhibit static/interference on am radio stations. *Mjs
- 608344Information on repair of vehicle's exhibiting wind noise/whistle from instrument panel area. Mjs
- 607970Information on replacing the shift pattern insert.
- 607937Conditions with poor am reception.
- 606632Important information regarding new vehicle windshield, rear and side glass, scratch, stress crack and distortion survey form.
Every Volkswagen New Beetle model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.