1995 Volvo 850
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 1995 Volvo 850. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 1995 Volvo 850. Newest first.
On certain passenger vehicles, after prolonged exposure to heat, the fuel tank may seep or leak fuel at the points where the heat shield IS attached.
Risk and remedy
Risk
Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Volvo will inspect the fuel tank and replace it if any evidence of fuel seepage or leakage IS found. all vehicles will receive new reinforcement bushings at the heat shield attachment points to prevent future leaks. this recall will be conducted as a safety recall in the hot weather states of alabama, arkansas, arizona, california, florida, georgia, hawaii, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, and utah, and as a service recall in the other 33 states and the district of columbia. the recall began on september 24, 2004. owners may contact volvo at 1-800-458-1552.
Engine block heaters installed as accessories. the block heater contact surface does not match correctly with the engine block as intended. the block heater could come loose from the engine block, and if being used, could possibly overheat causing damage if it comes in contact with other engine compartment components.
Risk and remedy
Risk
Engine compartment damage could occur increasing the risk of a vehicle accident.
Remedy
Dealers will inspect the block heater and secure the bolts used to install the heater. in some cases, the surface tolerances may be so inappropriate that the heater would need to be replaced with a heater of a modified design.
Some of the jacks supplied with the vehicles do not have the necessary load capacity.
Risk and remedy
Risk
A raised vehicle can fall off the jack increasing the likelihood for personal injury or property damage.
Remedy
Dealers will inspect and replace suspect jacks with a jack meeting the load requirements for these cars.
Owner complaints
111 complaints11 involved a crash9 involved a fire12 injuries
What owners report most
Latest complaints
- Fuel/propulsion system
TL* the contact owns a 1995 volvo 850. The contact stated that the odor of gasoline fuel was emitted inside and outside of the vehicle. The vehicle was taken to an independent mechanic for diagnosis and the contact was informed that the fuel hose was leaking. The hose was replaced however, the…
TL* the contact owns a 1995 volvo 850. The contact stated that the odor of gasoline fuel was emitted inside and outside of the vehicle. The vehicle was taken to an independent mechanic for diagnosis and the contact was informed that the fuel hose was leaking. The hose was replaced however, the contact continued to smell fuel. The vehicle was taken back to the independent mechanic and another cracked hose was replaced but to no avail. The contact stated that he cold see gasoline fuel leaking from under the fuel tank whenever refueling the vehicle. the contact referenced nhtsa campaign ID number: 04v368000 (fuel system, gasoline) and the vehicle was taken to a dealer for repair. He was informed that an exhaust pipe would occasionally strike the fuel tank, causing a stress fracture in the tank. As a result, the fuel tank would need to be replaced. The vehicle was not included in the recall. The manufacturer was notified but offered no assistance. The vehicle was not repaired. the failure and current mileage was 147,000.
- Fuel system, gasoline
TL* the contact owns a 1995 volvo 850. The contact stated after receiving repairs for recall nhtsa campaign ID number: 04v368000 (component: fuel system, gasoline: storage), the vehicle was still experiencing a fuel leakage. The contact stated that the vehicle had to be taken back to the dealer…
TL* the contact owns a 1995 volvo 850. The contact stated after receiving repairs for recall nhtsa campaign ID number: 04v368000 (component: fuel system, gasoline: storage), the vehicle was still experiencing a fuel leakage. The contact stated that the vehicle had to be taken back to the dealer after it failed to pass a smog test, as a result of an evop leakage. The dealer inspected the vehicle and stated that they had already performed the recall repairs and could not find anything else wrong with the vehicle. Since the problem persisted, the vehicle was taken back to the dealer a third time, which diagnosed that the fuel pump was defective and needed to be replaced. The contact decided to take the vehicle to a local mechanic for a second opinion who stated that all of the prior diagnosis were incorrect, and that the actual problem was the vent hose that was attached to the fuel tank was cracked and needed to be replaced. The manufacturer was not made aware of the failure. the vehicle was repaired. The failure and current mileage was 116,007.
- Seat belts
1995 volvo 850 glt, driver side seat belt retracting mechanism (the roller near driver's left shoulder) was stuck. it was very difficult to pull out the belt, sometimes pulling slowly and little by little seems to work it around. Sprayed some lubricant can free it up for a few days, then it will be difficult to pull out the seat belt out again ... It seems to have a defected design somewhere inside. *Tr
- Fuel system, gasoline · Fuel system, gasoline › Storage
My 1995 volvo 850 developed a gas tank leak at a heat shield attachment. this IS the same defect that led to a safety recall of volvo 850'S in certain southern states and a service recall in the other states in 2004 (see recall campaign 04v368000). I was never provided notice of this recall, and…
My 1995 volvo 850 developed a gas tank leak at a heat shield attachment. this IS the same defect that led to a safety recall of volvo 850'S in certain southern states and a service recall in the other states in 2004 (see recall campaign 04v368000). I was never provided notice of this recall, and volvo now refuses to pay for the necessary replacement of the gas tank--a substantial expense apparently caused by a safety defect that the company failed to remedy. I am having a new gas tank put in by a volvo dealer today. in researching this problem on the internet, I saw that other affected volvo owners did not receive any notification of the recall from volvo. *tr
- Fuel system, gasoline › Storage
Tl*the contact owns a 1995 volvo 850. the contact noticed fuel leaking on the floor of his garage underneath the vehicle. through research, he discovered nhtsa action number ea03008, nhtsa campaign ID number 04v368000 (fuel system, gasoline:storage). the dealer stated that the vin was not…
Tl*the contact owns a 1995 volvo 850. the contact noticed fuel leaking on the floor of his garage underneath the vehicle. through research, he discovered nhtsa action number ea03008, nhtsa campaign ID number 04v368000 (fuel system, gasoline:storage). the dealer stated that the vin was not included in the recall. the contact stated that since the failures were identical, his vin should be included and the manufacturer should be responsible for the repairs. the current and failure mileages were 117,900. updated 01/08/09.*jb
- Fuel system, gasoline › Storage
Tl*the contact owns a 1995 volvo 850. the contact noticed gas leaking from the fuel tank. the dealer stated that the leaked occurred where the heat shield was attached. there IS a recall fuel system, gasoline: storage (nhtsa campaign ID #04v368000) however, the dealer stated that his vin was not included. the failure mileage was 112,750 and current mileage was 113,000. the vin was unavailable.
- Fuel system, gasoline
Tl*the contact owns a 1995 volvo 850. he noticed a gas smell coming from the rear of the vehicle. he stated that gas leaks from the gas tank when he fills it up. he has not spoken with the dealer or the manufacturer. the current and failure mileage was 132,000.
- Seats › Front assembly › Seat heater/cooler
My wife & daughter smelled smoke while driving on a neighborhood street. it seemed to be coming from under the driver's seat. they stopped the car right away and got out. as my wife opened the door to the back seat to get her purse, she saw flames coming from under the driver's seat. they ran…
My wife & daughter smelled smoke while driving on a neighborhood street. it seemed to be coming from under the driver's seat. they stopped the car right away and got out. as my wife opened the door to the back seat to get her purse, she saw flames coming from under the driver's seat. they ran to the nearest house to call 911. while on the phone with 911, less than a minute after getting out of the car, my wife saw the entire inside of the car become engulfed in flames. the fire department was on the scene within 3 minutes, but it was too late. the entire inside of the car was burned beyond recognition. what had been leather seats were now metal frames, the dashboard had evaporated, and the car was totaled. although our insurance company covered the loss of the car, we have had to spend several thousand dollars to replace burnt possessions (like a cell phone and a pda) and pay for car rental. the fire department indicated that the seat heater was the likely cause of the fire, but volvo has not admitted any product failure. when we bought a volvo because of its reputation for safety ("volvo for life"), we certainly didn't expect it to burn up! *nm
- Electrical system · Equipment · Exterior lighting › Brake lights › Switch · Service brakes, hydraulic › Antilock/traction control/electronic limited slip · Visibility › Windshield wiper/washer › Motor
. I have spent $2200 in the last 3 months while herb gordon tries to figure out the problem with the brakes. they have replaced the brake master cylinder, cleaned and resealed the brake calipers and now as a last resort are replacing the internal ABS system, which finally fixed the problem.…
. I have spent $2200 in the last 3 months while herb gordon tries to figure out the problem with the brakes. they have replaced the brake master cylinder, cleaned and resealed the brake calipers and now as a last resort are replacing the internal ABS system, which finally fixed the problem. ignition switch replaced, the windshield wiper bolts came loose causing the windshield wipers to stop in the middle of driving on a highway in the rain, air sensors and oxygen sensors seem to need replacing at least twice a year. *nm
- Visibility › Windshield wiper/washer › Linkages
Driver side windshield wiper blades no longer contacts glass because motor spindle axis has become misaligned forcing wiper arm up. suspect that mounting plate or bracket for motor has become distorted/bent. I bent arm for temporary fix. other owners of volvo 850 have reported similar problems (www.brickboard).*jb
- Engine and engine cooling › Exhaust system › Emission control
Dt: received manufacturer's recall s139032105, took vehicle to dealer for recall repairs. after an emission test was done vehicle did not pass it. vehicle was taken back to dealer for a check up. the dealer said that part for the emission was not included in the recall. The manufacturer…
Dt: received manufacturer's recall s139032105, took vehicle to dealer for recall repairs. after an emission test was done vehicle did not pass it. vehicle was taken back to dealer for a check up. the dealer said that part for the emission was not included in the recall. The manufacturer stated the same thing. This was done on july 18, 2005. Consumer believed this part should be included in the recall because it was related to the defective part mentioned in the recall. *ak
- Fuel system, gasoline › Storage
Consumer received a recall notice for 1995 volvo 850 in which she sold. consumer wants the new owner contacted in reference to the recall.***no answer required***. *Mr before the consumer sold the vehicle she complained of a gas odor, but the dealer always stated there was nothing wrong. *jb
- Electrical system
Upon starting the vehicle, and backing out the drive way, consumer saw smoke, seemed to be coming from under driver's seat. consumer then went into the house to get water. Upon returning to the vehicle it was engulfed in smoke, and fire.*ak *bf *nm
- Engine and engine cooling › Engine
While attempting to start the vehicle it caught fire in the engine compartment without warning. The consumer states that there was excessive fuel leakage. The cause has yet to be determined. Please provide additional information. *nm
- Fuel system, diesel › Storage › Tank assembly
Gas was leaking onto the ground due to heat shield being punctured. *ak
- Fuel system, gasoline › Delivery › Fuel pump · Fuel system, other › Delivery › Hoses, lines/piping, and fittings
I purchased a used vehicle and filled the tank full until auto pump kicked off, drove less than 1 mile home and parked in the garge. The next morning, garage filled with gas fume odor, no visible leak, researched hayned repair manual, found access cover to fuel tank sending unit and fuel pump inside vehicle, removed covers, found fuel leak at fuel pump cover.*ak
- Fuel system, other › Storage › Tank assembly
Consumer saw/smelled fuel leaking from the fuel tank. Dealership was notified, but did not resolve the problem. *Ak
- Engine and engine cooling · Seat belts · Unknown or other
The front seats have broken three times. the band that keeps the backs in position either fails and the seat will not return to a previous position or it slips and fails to adjest the seats. this was fixed and paid for twice. Now within 15 months it has failed again and smythe volvo will only…
The front seats have broken three times. the band that keeps the backs in position either fails and the seat will not return to a previous position or it slips and fails to adjest the seats. this was fixed and paid for twice. Now within 15 months it has failed again and smythe volvo will only offer a 10% reduction in the cost. this should last monger then 15 months. I would like to know if anyone else has had this problem. we weigh 124 and 145 respectively. we haven't adjusted the seats very often. would like to know how common this problem IS. volvo says it IS not common. we think it IS defective repair or defective design and they share in the responsibility. please advise.
- Structure › Body › Door › Hinge and attachments
When shutting both frontal doors consumer noticed that the door hinges broke from the frame of the vehicle. This was causing the doors not to close. Consumer will contact the dealership about this issue. *Ak
- Seats › Front assembly › Seat heater/cooler
Consumer's heated seat caught on fire. the seats fabric contained the fire. *Ak *nm
- Service brakes, air › Antilock › Control unit/module
Abs/tracks system failure on both 1995, 850 and 1998, V70. when abs/track light(s) comes on, no abs/track. left front weel may pull when braking on V70. volvo corp. Does not want to do anything about this problem... made several calls, had inspection/service done by "certified volvo service technician," volvo will not accept problem...
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Volvo 850 anti-lock brake system hydraulic modulator pump developed a significant fluid leak (3-6 oz per day, or greater). this part IS non-repairable and must be replaced at great cost (quoted $1900). as a key brake system component, failure of this part may cause (1) significant loss of brake…
Volvo 850 anti-lock brake system hydraulic modulator pump developed a significant fluid leak (3-6 oz per day, or greater). this part IS non-repairable and must be replaced at great cost (quoted $1900). as a key brake system component, failure of this part may cause (1) significant loss of brake function due to air & moisture intrusion into the brake lines, (2) non-functioning brakes when greater amounts of fluid are suddenly lost, and/or (3) fire danger, when dripping brake fluid contacts nearby exhaust manifold components. *Jb
- Seat belts
The seat belt failed to retract from its position.*jb *ts
- Fuel system, gasoline › Storage › Tank assembly
No summary. dt
- Seats › Front assembly › Seat heater/cooler
Consumer states while driving 30 mph the drivers seat started getting hot. The seat heater burned through the seat. The dealer was notified. Please provide more information. mr
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Fuel tank leaks
This engineering analysis was opened on june 11, 2003, based on 54 reports of fuel tank leaks.the subject vehicles were 1993 through 1996 model year (my) 850 vehicles. Model 850 was also produced in my 1997 and was included in this investigation. Analysis of the data reveals two distinct issues. First, the 1994…
This engineering analysis was opened on june 11, 2003, based on 54 reports of fuel tank leaks.the subject vehicles were 1993 through 1996 model year (my) 850 vehicles. Model 850 was also produced in my 1997 and was included in this investigation. Analysis of the data reveals two distinct issues. First, the 1994 through 1997 my vehicles stand out by accounting for 95 percent of the reported leaks.these vehicles share the same fuel tank design (pn 9142618). The 1993 my vehicle uses a different fuel tank design (pn 9141101).secondly, the failures occurred predominantly in hot climates, e.g., california, arizona, texas, florida, georgia, louisiana, etc.testing of fuel tanks from consumer vehicles at the vehicle research and test center confirmed leaks through cracks in the fuel tank wall at a heat shield mounting attachment in the 1994 through 1997 my fuel tanks (pn9142618). Details of the tests are available in test report vrtc-dcd3060.volvo will conduct a safety recall on all my 1994 through 1997 vehicles originally sold or registered in the following 17 hot states: ca, az, nm, tx, la, ms, al, ga, sc, fl, nc, tn, ar, ok, ut, NV, and hi.all 1994 through 1997 my vehicles in all other states will be remedied under a service campaign.the remedy for both the recall and service campaign IS to install a new bushing at each heat shield attachment point (3 per tank).also, all tanks (vehicles in all states) will be inspected for fuel seepage at the heat shield attachment points and volvo will replace any tank showing signs of fuel seepage.the new bushings will prevent heat shield stresses from being transferred to the three heat shield mounting attachments on the fuel tank.the safety recall IS filed under nhtsa safety recall number 04v368.this investigation IS closed.
- Fuel tank leaks
The office of defects investigation opened thisinvestigation on january 16, 2003.the basis for opening the investigation was 15 consumer reports alleging gasoline leaking from the fuel storage tank.volvo provided 43 additional reports in its response to the preliminary evaluation, 4 of which were duplicates of the 15 odi reports. This investigation has been upgraded for further study.
- Inadvertent side air bag deployment
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10241661Complimentary upgrade c00009 description.
- 10241651Rubber cushion
- 10213885The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
- 10213883ICUP/Google Built-In Diagnostic Operations
- 10213882Battery Charger/maintainer requirement
- 10212892Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- 10212891VIDA QR Scanner Mobile App
- 10205692Service Campaign 140: Inspecting the Fuel Tank and Installing Rubber Dampers.
- 10205691Inspecting the Fuel Tank and Installing Rubber Dampers.
- 10181041Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10179681This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
- 10178503Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10173760This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
- 10171676Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10170147Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
- 10169394This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
- 10169393This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
- 10169391Software Installation Policy changes.
- 10169389This is a Service Manager Bulletin: Technician Skillset Requirments
- 10169036Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10169021Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
- 10167953Software Installation Policy changes.
- 10167952Descripition of Goodwill Policy and Guidelines.
- 10167915Dice Tool bulletin explaining the offer.
- 10167872This is a Service Manager Bulletin: Service Scheduling system enhancements. Improving Service Action/Recall scheduling.
- 10167861This is a Service Manager Bulletin: The online bookstore, www.volvotechinfo.com, serves Volvo Retailers, employees, Independent Repairers and customers throughout the United States and Canada by providing easy order-access to service, parts and owners? literature over the Internet.
- 10167854Mandatory Special Tool List
- 10167847Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers
- 10167833This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.
- 10167828This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be filled in and attached to the affected Vehicle Report. (External sources: Authority, Insurance companies, Rental companies, etc)
- 10167817This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.
- 10167751Title : No . Page Volvo Special Tool 186 1 of 1 Cabinet Car Market : SPECIAL United States , Canada TOOLS Date : YEAR MONTH DAY BULLETIN 2012 02 02 Take Your Special Tool Storage to the Next Level Maintain Your Parts & Service Department Efficiency , Organization and Productivity with the Volvo Special Service Tool Cabinet from Stanley Vidmar ! System includes ( 3 ) Stanley Vidmar Modular drawer cabinets with partitions , dividers and lock , ( 2 ) overhead shelf door cabinets with one shelf and lock ; designed to store Volvo Special Service Tools . Features ? Three - cabinet system with two overhead storage cabinets . ? 38 drawers with compartments . ? Exceptional tool organization with dedicated compartments , partitions and dividers . ? All cabinets are lockable . ? All steel construction . ? Drawers rated at 400 lbs . capacity fully loaded and extended . ? Drawer cabinets have pallet base included . ? Allows cabinets to be moved fully loaded and as your needs change . ? Tool locator sheets and index provided for placement of 600 tools in drawers and overhead cabinets . Technical Weight approx . ( lbs ) 2400 554 - VOLVO - SPL Color Volvo Blue Volvo Special Tool Cabinet Power supply ( V / Hz / A ) None Dimensions ( L x W x H ) 90 " x 27 - 3 / 4 " x 90 " Dealer Price $ 7,292 To Order Call 800 - 345 - 3399 or visit Volvodealersolutions.com today ! Promo # VO12 - 11 All Product Sold F.O.B . Shipping Point Pricing effective through June 30 , 2012 " Fixed Right ? First Time " SERVICE TECHNICIANS SERVICE PARTS WORKSHOP Service MANAGER MANAGER FOREMAN Personnel : read and initial . 2012 Volvo Cars of North America , LLC Printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste
- 10167746Please use attached file to create new version of bulletin. Please remove original bulletin by same number dated 2/18/2010.
- 10167722VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America YEAR MONTH DAY 2014 02 06 FUNC GROUP : FUNC DESC : 0 Publications Page 1 of 3 Attachment Vehicle Type Eng Struc Week Type Eng Sales Body Gear Steer Model Year Plant Chassis range Desc Range XXX 1927 - 9999 0000001 - 0999999 0 - 0 CSC Customer Symptom Codes Code Description 1C Administrative and Factory scheduled maintenance / Administrative and Factory scheduled maintenance DTC Diagnostic Trouble Codes Rows beginning with * are modified Note ! If using a printed copy of this Technical Journal , first check for the latest online version . Text In our Service Literature , a vehicle is often referred to by its ? type ? , not its ? model ? . For example the 1999 - 2006 Model Year S80 is type ? 184 ? . You may also see the designation , for example ? P2X ? . This is referring to a platform type or vehicle family . If a document states ? P1X ? or ? 5XX ? as an example , it will apply to all models within the platform type . ? 54X ? will apply to the ? 544 ? , ? 545 ? and ? 542 ? models . ? X ? represents variable data . ? Right first time in Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2014 VOLVO CARS OF NORTH AMERICA , LLC Technical Journal 19245 Platform Model Type Model Years Comments P3 S80 124 2007 - V70 135 2008 - 2010 XC70 136 2008 - XC60 156 2010 - S60 134 2011 - V60 155 2015 - P2 S80 184 1999 - 2006 V70 285 2001 - 2007 XC70 295 2001 - 2007 S60 384 2001 - 2009 XC90 275 2003 - P1 S40 544 2004 - 2012 V50 545 2005 - 2012 C30 533 2007 - 2013 C70 542 2006 - 2013 X40 S40 644 2000 - 2004 V40 645 2000 - 2004 900 940 9
- 10167697Midtronics psc-550s and psc-700 vehicle power supply information
- 10164860This is a Service Manager Bulletin: Technician Skillset Requirments
- 10164857Retailers should only use a Volvo part number on claims for items purchased directly from Volvo. Failure to follow this policy will result in claim adjustments. Warranty reimbursement rates and quantity limits for the parts listed, with the exception of the oil part numbers, Wynn?s Airco-clean, R134A and R1234YF are set by Volvos Parts Department and based on the pricing in effect on the repair date. For the most current pricing retailers must refer to the parts system. Reimbursement rates for oil part numbers, Wynn?s Airco-clean, R134A and R1234YF are set by the Warranty Department. Updated parts pricing for these parts are provided via a Warranty CPI.
- 10164856Retailers should only use a Volvo part number on claims for items purchased directly from Volvo. Failure to follow this policy will result in claim adjustments. Warranty reimbursement rates and quantity limits for the parts listed, with the exception of the oil part numbers, Wynn?s Airco-clean, R134A and R1234YF are set by Volvos Parts Department and based on the pricing in effect on the repair date. For the most current pricing retailers must refer to the parts system. Reimbursement rates for oil part numbers, Wynn?s Airco-clean, R134A and R1234YF are set by the Warranty Department. Updated parts pricing for these parts are provided via a Warranty CPI.
- 10164851Software Installation Policy changes.
- 10164132Description of Goodwill Policy and Guidelines.
Every Volvo 850 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.