2019 Volvo Vnm

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10252317CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
• 10252316CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
• 10251325CBR - Telematics Gateway (TGW) Connect Ability Issues.
• 10251323CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
• 10251319CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
• 10251317CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
• 10249569CBR: TGW Will Not Connect After SIM Card Replacement
• 10249563Fleet Improvement Campaign: (ABS) Software Update and Brake Inspection
• 10248093Service Campaign: Volvo trucks has determined that certain VN model trucks built with an D13 Turbo Compound engine that have had a reman TC unit installed could experience a failure with the reman TC unit.
• 10248063CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
• 10246113Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been developed. The new software will be delivered as an updated PAR file to the ABS Module and will help reduce heat load on steer axles brake assemblies during an adaptive cruise control braking event. Follow the instructions below to visually inspect the brake rotors on the steer axle for excessive heat damage and update the ABS software.
• 10244826Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
• 10244825CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
• 10243469Service Campaign: (Revision extending the campaign expiration date another year, to 12-31-2024)
• 10243461TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
• 10243460TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
• 10243458CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
• 10241911CBR: Valve Stem Extension Contacting Outer Wheel
• 10241906TSB: Barksdale Leveling Valve, Leak Test
• 10241904CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
• 10240272TSB: Hood Cable Breaking or Binding
• 10240252CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
• 10240249CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
• 10240244CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
• 10233504Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
• 10227195Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
• 10227180Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
• 10225706Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
• 10225704Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
• 10225702TSB Washer Reservoir Leak
• 10225683Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
• 10225680Engine Control Module (EMS) Software (MSW) Information October 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
• 10225676Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
• 10225675Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
• 10224584Expendable Items Parts List.
• 10222288Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
• 10222270TSB-Charge Air Cooler t-clamp install.
• 10219421Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
• 10219302Part information for AMT input shaft repair kits and the shim kit that is required for repair.
• 10215308Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion

Every Volvo Vnm model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.