2022 Blue Bird Vision Transit Bus
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Blue Bird › Vision Transit Bus › 2022
These records cover every 2022 Blue Bird Vision Transit Bus. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
8 recalls name the 2022 Blue Bird Vision Transit Bus. Newest first.
Blue Bird Bus Company (Blue Bird) is recalling certain 2022-2027 Vision transit buses. The exhaust hanger cotter pin may contact the hydraulic brake line, damaging the line and causing a brake fluid leak.
Risk and remedy
Risk
A brake fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire. Additionally, a brake fluid leak can extend the distance required to stop, increasing the risk of a crash.
Remedy
Dealers will replace the exhaust hanger cotter pin. Dealers will also inspect and replace the brake lines as necessary. All repairs will be performed free of charge. Owner notification letters were mailed September 17, 2026. Owners may contact Blue Bird customer service at 1-478-822-2242.
Blue Bird Bus Company (Blue Bird) is recalling certain 2021-2026 Vision school buses. The brake interlock software may unintentionally activate the parking brake at any driving speed.
Risk and remedy
Risk
A bus that stops suddenly without warning, increases the risk of a crash.
Remedy
Dealers will update the brake interlock software, free of charge. Owner notification letters were mailed November 18, 2025. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R25DS.
Blue Bird Body Company (Blue Bird) is recalling certain 2020-2024 All American and 2021-2024 Vision transit buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency…
Risk and remedy
Risk
An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Remedy
Dealers will replace the label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (NSB).
Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision and 2021-2023 All American transit buses. The convertible seats may have been incorrectly installed, which can result in an unsecured seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly…
Risk and remedy
Risk
An unsecured seat may not adequately restrain an occupant, increasing the risk of injury during a crash.
Remedy
Dealers will inspect and repair the seat, free of charge. Owner notification letters were mailed March 04, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R24CM-NSB.
Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision transit buses equipped with a 7.3L gasoline engine. The transmission shift cable may have insufficient clearance from the gasoline fuel supply line at the left rear corner of the engine, which can result in a fuel leak.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Dealers will inspect and reroute the transmission cable, free of charge. Owner notification letters were mailed February 9, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22CB (NSB).
Blue Bird Body Company (Blue Bird) is recalling certain 2018-2023 Blue Bird Vision transit buses equipped with Roush fuel return lines included in GEN 4 and GEN 5 LPG Conversion Systems that were installed on vehicles sold or registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota…
Risk and remedy
Risk
A corroded fuel line can leak fuel, increasing the risk of a fire.
Remedy
Dealers will replace the fuel return lines, free of charge. Owner notification letters were mailed May 24, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BX-NSB.
Blue Bird Body Company (Blue Bird) is recalling certain 2022-2023 Vision transit buses. The fuel supply line was incorrectly routed, allowing it to chafe against a bolt head, which can damage the line and create a fuel leak.
Risk and remedy
Risk
A fuel leak increases the risk of a fire.
Remedy
Dealers will reroute the fuel line, and replace the fuel line if any damage is found, free of charge. Owner notification letters are expected to be mailed on June 21, 2022. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BU-NSB.
Blue Bird Body Company (Blue Bird) is recalling certain 2022-2022 Vision and All American transit buses. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air…
Risk and remedy
Risk
Unintended spring brake application may occur, increasing the risk of a crash.
Remedy
Dealers will replace the SC-3 check valves, free of charge. Owner notification letters were on mailed November 18, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BE-NSB.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10244319Revised: Coolant leaks at the transmission cooler fittings on the radiator are occurring due to deformation of the gasket used to seal off the transmission cooler. This deformation is caused from transmission oil wicking through the thread adapter threads and exposing the lower portion of the gasket to transmission oil. Re-configure hydraulic interface between the transmission cooler lines and the transmission oil cooler. SU2302 Revised to include Labor Time of 1 Hour and a Component Code. Incorrect wording on the Header Page beginning on Page 2.
- 10244318Revised: Coolant leaks at the transmission cooler fittings on the radiator are occurring due to deformation of the gasket used to seal off the transmission cooler. This deformation is caused from transmission oil wicking through the thread adapter threads and exposing the lower portion of the gasket to transmission oil. Re-configure hydraulic interface between the transmission cooler lines and the transmission oil cooler. SU2302 Revised to include Labor Time of 1 Hour and a Component Code.
- 10244309Coolant leaks at the transmission cooler fittings on the radiator are occurring due to deformation of the gasket used to seal off the transmission cooler. This deformation is caused from transmission oil wicking through the thread adapter threads and exposing the lower portion of the gasket to transmission oil. Re-configure hydraulic interface between the transmission cooler lines and the transmission oil cooler.
- 10217921Cummins recently issued Temporary Repair Practice (TRP2484) for certain vehicles with DEF sensor failures in which DEF sensor replacement parts are not available. This provides a temporary ECM calibration that inhibits engine warning messages for communication errors with the DEF sensor allowing continued operation without engine derate. Regulators are allowing for this temporary calibration to be loaded in the engine ECM by a Cummins authorized repair location if the DEF sensor fails. This temporary calibration does not repair the failure therefore a final repair must be performed and the original calibration be re-installed. Field Service has been requesting an ECM image be uploaded within the support ticket as part of the diagnostics and is carried over into Service Update 2201 (SU2201). In order to receive an authorization code and utilize Cummins TRP2484, you must follow the process, as outlined in SU2201. The specific component affected is Assembly Code: 35-300 Emissions Components.
- 10210253This document provides information on the cluster software improvement to address symptoms of acceptable parasitic battery loss attributed to CAN Devices not going to sleep. This symptom is occasionally accompanied by the cluster flashing on/off on an approximately 3-minute frequency. Blue Bird and Ametek have developed a software to alleviate this concern.
- 10201629The intent of Service Update SU2103 is to announce a new Shaw Development Technical Bulletin. The Technical Bulletin is intended to guide Shaw Development customers in troubleshooting fault codes related to the DEF tank assembly on Cummins engine equipment. This document is intended to be a living document, and the details and processes within can/will change as system designs evolve, or other new information comes to light. Access to this Shaw Development Technical Bulletin will be available on the Blue Bird Vantage website.
- 10201625The intent of Service Update SU2101 is to provide instruction when windshield replacement is required on buses equipped with Blue Bird Factory Installed Mobileye Collision Mitigation Features. Applicable Blue Bird features: 38105-34 MOBILEYE,COLLISION MITIGATION,250kB USA 38105-35 MOBILEYE,COLLISION MITIGATION,500kB USA (NEA Only)
- 10201622The intent of Service Update SU2104 is to provide a quick reference document of Required Dealer Service Support Software for servicing, a current production model Blue Bird Bus. The list includes standard OEM bus and truck service software such as; Cummins INSITE, and Allison DOC, and it also includes unique service software applications that are required to fully service a Blue Bird bus such as; AMETEK, ACTIA, and MODINE. These software applications provide troubleshooting support and software update capabilities. This document is intended to be a living document and will be updated as advancements are made in technology and product improvements are implemented. Therefore, to ensure you always have the latest revision it is highly recommended that the document be downloaded from the Blue Bird Vantage website.
- 10201621The intent of Service Update SU2105 is to provide service notification of a running product improvement part change to the relay used for diesel exhaust fluid (DEF) line heaters. The new DEF line heater relay will be "Diode Suppressed". The new relay change is being made to improve circuit fault diagnostic capabilties. This change implements two new diode suppressed relay part numbers based on bus model application. The new relays are easily distinguishable by color. They have a yellow high temp tape wrap. Models Affected: Vision (BBCV), All American, and TX4 (T3FE, T3RE), with EPA/CARB certified on highway Cummins Diesel Engine Features Built After 07/26/2021 Subject: The intent of Service Update SU2105 is to provide service notification of a running product improvement part change to the relay used for diesel exhaust fluid (DEF) line heaters. Information: The new DEF line heater relay will be "Diode Suppressed". The new relay change is being made to improve circuit fault diagnostic capabilities. This change implements two (2) new diode suppressed relay part numbers based on Blue Bird bus model application. The new relays are easily distinguishable by color. They have a yellow high temp tape wrap. New Diode Suppressed Relay Type, Part Number, And Application: Diode Suppressed Micro Relay 10073451 All American and TX4 (T3FE, T3RE) with Cummins Diesel Engine Features Built After 07/26/2021 Diode Suppressed Mini Relay 10073452 Vision (BBCV) with Cummins Diesel Engine Features Built After 07/26/2021
- 10200529Overview: Certain 2022 model year Blue Bird Vision School Bus units that are equipped with a ROUSH CleanTech 7.3L V8 gasoline or propane engine, with or without an air pump, Roush and Blue Bird have identified a concern with falsely setting misfire codes. This may or may not be combined with fuel gauge accuracy concerns and these concerns may cause a check engine light to be illuminated. Affected Units: Roush and Blue Bird is voluntarily issuing a Service Bulletin for the following: Certain model year 2022 Blue Bird Vision School Buses Manufactured from May 3, 2021 through July 16, 2021 A separate printout will be provided listing all buses in your territory that are affected by this service bulletin. Service Bulletin S21BK will be mailed to all owners on record. Be sure to review your list and advise of any incorrect owner names and/or addresses. Repair Parts: No additional parts/items are required to perform Service Bulletin S21BK. Please reference the Roush Instructions and reference the link to obtain a Voucher Code. Labor Reimbursement Complete ROUSH CleanTech warranty claim for reimbursement. A warranty claim was automatically generated when obtaining your voucher code. Reprogramming is covered using operation RCTE04B Powertrain Control Module (PCM) - Reprogramming and pays 0.5 hours at your current established warranty labor rate. Once flashing is completed, you can attach a copy of your Repair Order (RO) to the case for payment. Roush CleanTech will notify Blue Bird Campaigns Administration of the completion of Service Bulletin S21BK. The Roush CleanTech, LLC. contact for Service Bulletin S21BK campaign is as follows: Customer Service 1-800-59-ROUSH (OPT2) support@roushcleantech.com www.roushcleantech.com/service Time Allowance: Time allowed to perform the flash is .5 hours (30 minutes). Completion Notification: To request reimbursement for completed repairs, please reference the details within the Roush Instructions.
- 10197678Overview: Certain 2013 through 2022 model year Blue Bird Vision School and Non-School Bus units has experienced signs of single strand failing, leading to multiple stands, and eventually belt failure. The belt composition is not ideal for the life cycle of the bus. This Service Bulletin will provide owners with a one-time new replacement belt with the more durable material that is currently being used in production and for service. This Service Bulletin is for part cost coverage only. No labor reimbursement will be provided. Affected Units: Blue Bird Body Company is voluntarily issuing a service bulletin for the following: o Certain model year 2013 through 2022 Blue Bird Vision School Buses omanufactured from January 10, 2012 through February 26, 2021 o Certain model year 2013 through 2022 Blue Bird Vision Non-School Buses omanufactured from November 20, 2012 through November 19, 2020 Repair Parts: The Parts List outlined in the S21AZ Instructions details the part required to perform Service Bulletin S19AZ and should be ordered through Blue Bird Service Parts. The belt is based on the engine generation. Parts are currently available. Time Allowance: No labor will be provided to replace the belt with a more durable material belt, per the published Service Bulletin instructions.
Every Blue Bird Vision Transit Bus model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.