2007 Chevrolet Cobalt
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Cobalt › 2007
These records cover every 2007 Chevrolet Cobalt. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2007 Chevrolet Cobalt. Newest first.
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original…
Risk and remedy
Risk
If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy
UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk and remedy
Risk
If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy
General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model…
Risk and remedy
Risk
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model…
Risk and remedy
Risk
Fuel leakage in the presence of an ignition source may result in a fire.
Remedy
GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
General motors IS recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac G5 vehicles equipped with electric power steering. the driver may experience a sudden loss of power steering assist that could occur at any time while driving.
Risk and remedy
Risk
If power steering assist IS lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.
Remedy
Dealers will replace the electric power steering motor free of charge. owners are being notified on a rolling basis between march 29 through november 2010. a copy of the mailing schedule IS located in the recall file. owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.
General motors IS recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac G5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. the…
Risk and remedy
Risk
Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Dealers will replace the fuel pump module free of charge. a special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. the safety recall IS expected to begin on or before february 4, 2010. owners may contact chevrolet at 1-800-630-2438, saturn at 1-800-972-8876 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.
Owner complaints
1,564 complaints116 involved a crash16 involved a fire109 injuries7 deaths
What owners report most
Latest complaints
- Electrical system · Fuel/propulsion system · Steering
Fuel Leak it smells and leaks it seems to be coming from the gas tank and sometimes I get random electric failure when I'm driving I lose power steering and My brakes get stiff and hard to push down and my dash will go Off and then go crazy and show that i have no gas
- Fuel/propulsion system
I observed my mother’s 2007 Chevy Cobalt was leaking fuel near the rear tire by the fuel tank. I inspected the tank with engine off and it does not leak. Only with engine running. I lowered the tank and observed a small crack on the plastic return line on the fuel pump module. I started looking…
I observed my mother’s 2007 Chevy Cobalt was leaking fuel near the rear tire by the fuel tank. I inspected the tank with engine off and it does not leak. Only with engine running. I lowered the tank and observed a small crack on the plastic return line on the fuel pump module. I started looking online and could not find a replacement part that was plastic. I then conducted more research and found the recall. I asked my mother and she stated she never received a recall. The recall was issued on 09-19-12. NHSTA ID#12v459000
- Air bags
The contact owned a 2007 Chevrolet Cobalt. The contact stated that while the son was driving at approximately 52 MPH, the vehicle crashed head-on into a second vehicle. During the crash, no air bags had deployed, and the driver sustained fatal injuries. Also, during the crash, the ignition key…
The contact owned a 2007 Chevrolet Cobalt. The contact stated that while the son was driving at approximately 52 MPH, the vehicle crashed head-on into a second vehicle. During the crash, no air bags had deployed, and the driver sustained fatal injuries. Also, during the crash, the ignition key broke off inside the ignition switch, and the vehicle was destroyed. A police report was taken at the scene, and the vehicle was towed to a police inbound lot and later towed to the home. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was unknown.
- Air bags
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at 55 MPH, a 12-point buck jumped into the roadway, causing the contact to abruptly depress the brake pedal; however, the vehicle skidded and crashed into the buck. No air bags deployed. The vehicle was drivable…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at 55 MPH, a 12-point buck jumped into the roadway, causing the contact to abruptly depress the brake pedal; however, the vehicle skidded and crashed into the buck. No air bags deployed. The vehicle was drivable; however, the vehicle was towed to the residence due to the radiator being damaged. The contact stated that he sustained injuries to his left knee, and his fiancée, who was seated in the front passenger side, sustained injuries to her left knee. The contact stated this morning that he noticed his knee was swollen. No medical attention was sought as of yet. The contact stated that a police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 16,265.
- Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the steering wheel seized. There was no warning light illuminated. The contact stated that the steering wheel became difficult to turn. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.
- Air bags · Electrical system · Steering
I was in a crash on 9/19/25 and at the incident none of my airbags deployed. My daily driver for my children and I. I was lucky I was the only passenger at the time. I never expected my airbags not to deploy in a head on crash. The car still sits in my driveway and I have and identical one just like it that I drive! I’d like them evaluated.
- Steering
Hard to Turn Brand New front suspension
- Electrical system · Service brakes, hydraulic · Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical failures had occurred. The contact also stated that the ABS activated and deactivated independently, and the traction control became inoperable. The instrument panel also became inoperable, and the contact was unable to see the speedometer and fuel gauge functions on the instrument panel. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown. The VIN was not available.
- Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while her daughter was driving at an undisclosed speed, the contact became aware of a loud noise coming from the steering wheel. After the failure, while attempting to park the vehicle, the contact became aware of a crunchy sound…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while her daughter was driving at an undisclosed speed, the contact became aware of a loud noise coming from the steering wheel. After the failure, while attempting to park the vehicle, the contact became aware of a crunchy sound coming from the steering wheel. The contact stated that due to the failure result, the steering wheel became abnormally stiff and difficult to maneuver. No warning lights were illuminated. The vehicle was towed but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 160,000.
- Engine
Timing chain came right threw the valve cover
- Unknown or other
Key can be removed while a car is still running. It still does this. Hasn't been repaired.
- Fuel/propulsion system
The fuel pump failed and had began leaking profusely. The car was brought to the Chevy dealership where I was told it would be fixed under special coverage 12191. Chevy had tried an aftermarket part to fix but it would not seal properly and continued to leak. I got in contact with General Motors…
The fuel pump failed and had began leaking profusely. The car was brought to the Chevy dealership where I was told it would be fixed under special coverage 12191. Chevy had tried an aftermarket part to fix but it would not seal properly and continued to leak. I got in contact with General Motors who said a new part had been ordered, a week later they told me there was no new part as they discontinued it. They are now saying that it isn’t their responsibility to fix the car due to its mileage even though special coverage 12191 specifically states no expiration due to mileage. They are offering me a credit towards a down payment which I do not want as I am not interested in having a new car payment, i want my car repaired or to be compensated once they total it out. This is my daily driver car and I have been without it for four months while GM shoves me around and refuses to deliver on their failed product. Please help.
- Fuel/propulsion system
Started smelling gas when driving vehicle. Found fuel leak on top of fuel tank. Took vehicle to Mesa Auto Works (480-969-1954) on [XXX] and they diagnosed a Fuel Pump Module broken and leaking fuel. Replaced unit at a cost of $730.22 with the fuel pump module costing $382.80. This defect could have…
Started smelling gas when driving vehicle. Found fuel leak on top of fuel tank. Took vehicle to Mesa Auto Works (480-969-1954) on [XXX] and they diagnosed a Fuel Pump Module broken and leaking fuel. Replaced unit at a cost of $730.22 with the fuel pump module costing $382.80. This defect could have resulted in a car fire and or worse. Definitely a safety issue. I have searched online and found many other complaints about this same defect. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that the vehicle made an abnormal sound while reversing. Additionally, the contact stated that while starting the vehicle, the power steering warning light was illuminated. The contact stated that while attempting to drive the vehicle…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that the vehicle made an abnormal sound while reversing. Additionally, the contact stated that while starting the vehicle, the power steering warning light was illuminated. The contact stated that while attempting to drive the vehicle, the steering wheel was firm. The contact turned around and drove back to the residence. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 10V073000 (Steering); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 179,200.
- Air bags · Engine
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the Service Air Bag message was intermittently displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the Service Air Bag message was intermittently displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 120,000.
- Fuel system, gasoline
The contact owns a 2007 Chevrolet Cobalt. The contact stated that there was an abnormal fuel odor near the fuel tank. There was fuel leaking from the fuel cap. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that there was an abnormal fuel odor near the fuel tank. There was fuel leaking from the fuel cap. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer was not contacted. The failure mileage was approximately 105,000.
- Fuel/propulsion system
Gas smell, no gas is visable on ground and vehicle is hard to start after sitting.
- Service brakes, air › Antilock › Abs warning light · Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated while driving 25-35 MPH, the RPM’s continuously fluctuated, and the vehicle lost power steering functionality. The ABS warning light was illuminated and the message "Power Steering Failure" was displayed. The contact was able to veer to…
The contact owns a 2007 Chevrolet Cobalt. The contact stated while driving 25-35 MPH, the RPM’s continuously fluctuated, and the vehicle lost power steering functionality. The ABS warning light was illuminated and the message "Power Steering Failure" was displayed. The contact was able to veer to the side of the road by using physical force to turn the steering wheel. The contact turned off and restarted the vehicle; however, the failure persisted. The contact was able to drive the vehicle to the residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The contact related the failure to NHTSA Campaign Number: 10V073000 (Steering); however, the VIN was not included. The failure mileage was approximately 191,000.
- Fuel system, gasoline
The contact owns a 2007 Chevrolet Cobalt. The contact stated that upon inspecting the vehicle, he noticed a fuel odor and a leak at the rear driver’s side tire. The vehicle was not diagnosed or repaired. The dealer and manufacturer were notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 140,000. The VIN was unavailable.
- Fuel system, gasoline
The contact owns a 2007 Chevrolet Cobalt. The contact stated while starting the vehicle, there was an abnormal fuel odor inside the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not contacted. The failure mileage was 200,000.
- Power train
The contact owns a 2007 Chevrolet Cobalt. The contact stated while driving 60 MPH, the anti-theft warning light illuminated. Additionally, the low fuel warning light was illuminated; however, there was fuel in the tank. The contact stated that the vehicle lost power steering functionality and the…
The contact owns a 2007 Chevrolet Cobalt. The contact stated while driving 60 MPH, the anti-theft warning light illuminated. Additionally, the low fuel warning light was illuminated; however, there was fuel in the tank. The contact stated that the vehicle lost power steering functionality and the steering wheel became firm. The contact pulled over on the side of the road and waited for the vehicle to cool down. The vehicle was taken to the dealer but was not diagnosed. The manufacturer was contacted, and a case was filed. The failure mileage was 155,000.
- Fuel/propulsion system
fuel lines starting pouring gas right at driver side rear wheel gas lines rusted with holes in them and my car only has 40 thousand miles on it and parked in a garage this could have been very bad since the gas lines are right next to the exhaust
- Engine
The contact owns a 2007 Chevrolet Cobalt. The contact stated that on multiple occasions while driving at unknown speeds, he heard an abnormal beeping sound, and the vehicle went into LIMP Mode. An unknown warning light was illuminated. The vehicle was not diagnosed or repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 177,000.
- Air bags
The driver of the Cobalt lost control and swerved into the path of a tractor-trailer and collided head-on with the tractor-trailer. The airbag in the Cobalt did not deploy despite significant frontal damage to the Cobalt. A download of the ACU in the Cobalt revealed that the Cobalt's ignition…
The driver of the Cobalt lost control and swerved into the path of a tractor-trailer and collided head-on with the tractor-trailer. The airbag in the Cobalt did not deploy despite significant frontal damage to the Cobalt. A download of the ACU in the Cobalt revealed that the Cobalt's ignition switch was in the accessory position at the time of the crash. The ignition switch recall work had been performed on the Cobalt prior to the crash.
- Steering
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to maneuver and started to shake. The power steering assist warning light illuminated then turned off. The dealer was notified of the failure and the contact…
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to maneuver and started to shake. The power steering assist warning light illuminated then turned off. The dealer was notified of the failure and the contact scheduled and appointment. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Electric Power Steering Failure
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power…
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007196This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies.
- 11007116This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006682This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11006421GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
- 11004761This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 11004727This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 11000158This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.
- 11000119This service bulletin provides technicians with information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
- 10254240Information on COAX Repair Kit Availability.
- 10253770This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10251888This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250347This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle service record retention and proper handling of assembly returns for Canadian Dealers only.
- 10250013High Voltage Safety ? High Voltage Disabling
- 10249980This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include ?Vibration? ?Business Associate Code? and the last 8 of the Vehicle Identification Number.
- 10249590This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249535This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
- 10249295This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
Every Chevrolet Cobalt model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.