1991 Dodge Dynasty
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Dodge › Dynasty › 1991
These records cover every 1991 Dodge Dynasty. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 1991 Dodge Dynasty. Newest first.
The ABS hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration.
Risk and remedy
Risk
If this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.
Remedy
Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. Also the warranty on all ABS components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). Owners will also be reimbursed for previous ABS component repair costs.
The anti-lock brake system high pressure hose may leak or detach at its crimped end fitting resulting in the discharge of hydraulic fluid.
Risk and remedy
Risk
Fluid discharge eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.
Remedy
Replace the ABS high pressure hose with a hose of different design and construction.
Water leaking under windshield cowl in area above heater blower motor resistor block results in corrosion of the resistor terminals.
Risk and remedy
Risk
Corrosion of the resistor terminals increases electricalresistance, leading to overheating and possble ignition of the wiring connectorsand insulation, causing a fire in the cowl area.
Remedy
The blower motor resistor block will be replaced, and a mastic patch applied to seal the cowl against water entry. Damaged wire connectors will be replaced.
Front outboard safety belt may become difficult to latch and or unlatch due to a webbing stiffener entering the buckle housing and dislodging the buckle latch guide.
Risk and remedy
Risk
Latch may open during accident or sudden stop, exposingseat occupant to increased risk of injury.
Remedy
Replace buckle latch engagement.
Front disc brake caliper guide pin bolts may not have been adequately torqued and could loosen.
Risk and remedy
Risk
This could cause reduced braking effectiveness and couldresult in an accident.
Remedy
Properly torque front brake caliper guide pin bolts to 250 pounds.
Owner complaints
108 complaints6 involved a crash4 involved a fire6 injuries
What owners report most
Latest complaints
- Fuel system, gasoline
I smelled a strong order of gas when driving, when I checked under the hood there was a constant dripping fro the fuel rail supplying the fuel injectors...first , it was a small dripping on the front valve cover and after 2-3 months its a strong continuous dripping filling up the valve cover…
I smelled a strong order of gas when driving, when I checked under the hood there was a constant dripping fro the fuel rail supplying the fuel injectors...first , it was a small dripping on the front valve cover and after 2-3 months its a strong continuous dripping filling up the valve cover spilling into the manifold area. I have restricted driving my car to 5-7 miles at a time to prevent possible fires. my mechanic called the dealership to see how much they cost and this u-shaped aluminum tubing about 14" long ,8" connecting tube where it IS leaking from to another piece of aluminum 14" tubing that goes underneath the manifold IS $300.00 and $150 to install it. I think it IS a factory defect that the manufacturing dealer IS gouging almost punishing them for needing the part by charging 3XS what the piping/tubing really should cost. My mechanic and I have been all over the web looking for the same part but all of them say its a discontinued parts and can only be bought by the dealership. What a rip off they know its a factory defect and in high demand but they are not making anymore than that want to make to keep the demand high and to make a big profit on a design mistake in their fuel system design that they sold to the public. they probably knew it was a defective design but pushed it through anyway. *tr
- Service brakes, hydraulic › Power assist › Hydraulic
ABS anti-lock system warning light goes on at times, then off other times. followed by ABS anti-lock system functions to fail totally reduced brakes to stop vehicle by 95% used parking brake to achieve stop. *tr
- Fuel system, gasoline › Fuel injection system › Fuel rail
Leakage of fuel at the fuel rail connections, above the valve covers, which drains onto the manifold and could start a fire. I am told it will cost over $700 to replace the parts which cannot be bought anywhere else. *tr
- Engine and engine cooling › Engine › Gasoline › Belts and associated pulleys
Purchased said vehicle in sept. 2006 used. Was just driving at posted speed limits in a community area of phoenix, when all of a sudden a loud clacking noise started as I pulled up to my designation, so I turned off the motor, lifted the hood and immediately noticed that the tension pulley had…
Purchased said vehicle in sept. 2006 used. Was just driving at posted speed limits in a community area of phoenix, when all of a sudden a loud clacking noise started as I pulled up to my designation, so I turned off the motor, lifted the hood and immediately noticed that the tension pulley had nearly completely came off the motor. it did cause the serpintine belt to come off of all the pullies of the motor. I had to have the vehicle towed home, again for the second time since sept. 2006. hen the vehicle was at my home I finished removing the pulley that was loose, causing it to bent enough to throw it totally off of its tension purpose. upon removal a bolt was also broken which may have caused the total problem because it was not tightened to torque specs. had to replace both parts attached to this pulley.*ak
- Electrical system › Ignition › Module
For the third time within a 3 year period my car will start and run for about 2 seconds and turn off, I had it towed and the mechanics would replaced the main computer, or say they did, and charge me a great deal of money. I searched recently on the internet to see if others have had the same…
For the third time within a 3 year period my car will start and run for about 2 seconds and turn off, I had it towed and the mechanics would replaced the main computer, or say they did, and charge me a great deal of money. I searched recently on the internet to see if others have had the same problem, and I found that it IS a defective part problem found at this site---http://autorepair.about.com/library/a/1f/bl111f.htm I should not have to pay for a defective part which IS tied in to an anti theft feature. *Jb
- Seat belts › Rear/other
Both rear set belts have trouble being pulled out. They seem to get stuck and cannot be used. This could result in serious injury or death to rear passengers. I have yet to fix the problem. *jb
- Fuel system, gasoline › Fuel injection system › Fuel rail
Purchased vehicle used oct. 2006. near mint condition. power everything & everything functions perfect. vehicle emissions perfect. approx. 4 days after final registration was switched, plated, & insured, I hopped onto the freeway, doing about 65 mph. When suddenly in a matter of seconds, I…
Purchased vehicle used oct. 2006. near mint condition. power everything & everything functions perfect. vehicle emissions perfect. approx. 4 days after final registration was switched, plated, & insured, I hopped onto the freeway, doing about 65 mph. When suddenly in a matter of seconds, I was totally overwhelmed by the smell of gas. I became seriously nauseous and light headed and had to immediately exit the freeway to find somewhere to pull over as fast as I possible could without causing an accident or more serious a fatality. once, I managed to pull over I pulled the hood latch, jumped out to get a breath of fresh air, I popped the hood to try to see where this gas was coming from. All I could see was gas spaying out all over the place, in massive amounts just like a high pressure hose at a car wash. 1\4 tank leaked out all over the top of the engine & all over the intake manifold of my car. I thanked god, that the engine was not hot enough to ignite the whole car, with me inside. after getting the vehicle towed home, we found out it was the fuel rail feeder that distributes gas to the fuel injectors. the after researching other dodge vehicles I found out there was an undocumented recall for this part, this car year, make and model when it first came out, and that chrysler/dodge continued to install this same part on other years, makes & models & daimler chrysler/ dodge was, very well aware of this. last year they grossed $16.63 million dollars in 2005 with $1.5 million in losses & they can't afford to repair this for $700.00 just makes my stomach turn. Now knowing that I could have been killed or could have possibly caused a serious or even fatal injury to someone else, because of daimler chrysler's neglect in admitting this IS a defective manufactured part, and them taking full responsibility for this IS outrageously unbelievable to say the least. *nm
- Fuel system, gasoline › Fuel injection system › Fuel rail
1991 dodge dynasty, 3.3L engine. fuel rail leaking, at crossover tube connection. Fuel leaking down onto vavle cover, which then leaked onto hot exhaust manifold. Minor fire, but thank god I was in my driveway when I smelled the fuel. Opening the hood revealed the small fire that started. The…
1991 dodge dynasty, 3.3L engine. fuel rail leaking, at crossover tube connection. Fuel leaking down onto vavle cover, which then leaked onto hot exhaust manifold. Minor fire, but thank god I was in my driveway when I smelled the fuel. Opening the hood revealed the small fire that started. The dodge dealer wants 300.00 for the part, and I feel chrysler should pay for this part since it IS not a "wear" item, nor IS it a moving part, or in a location prone to wear. Had my wife or myself been driving and the fire occured, this could have been a very dangerous situation, and I would have considered a law suit. Any help you can provide me would be great. If you can provide a complaint number to call for chrysler, I will do so. I feel they should at least pay for the part. Vehicle IS currently parked, as I cannot locate a used replacement. This IS creating a major headache, as we need 2 vehicles, and cannot afford to replace the dynasty at this time, nor can we afford (or justify) 300+ for the repair. thank you. *ak
- Fuel system, gasoline › Fuel injection system › Fuel rail
I own a 1991 dodge dynasty, 3.3 liter. The fuel rail started leaking at the joint on the front, behind the valve cover.*ak
- Power train › Automatic transmission
While driving at any speed and without warning, the transmission failed. *ak *tt *jb
- Fuel system, gasoline
While driving smelt fumes and vehicle stalled out. Contacted dealer.*ak
- Air bags › Frontal · Wheels
Consumer was traveling about 25mph on highway and without prior warning another vehicle veered into consumer's vehicle. upon impact, airbags did not deploy. dealership was aware of problem.*ak while consumer was trying to turn, the wheel locked and a hit pole and building. During the accident the air bag failed to deploy and the consumer had face and chest injuries. *yh
- Electrical system › Ignition › Module · Engine and engine cooling › Engine › Gasoline
Vehicle would constantly shutdown while driving without warning, dealer has replaced computer command control module, but problem IS still occurring.*ak consumer stated the starter, fuel injector, fuel pump, fuel filter coil pack, map sensor, and catalytic converter have all been replaced.*slc
- Fuel system, gasoline › Fuel injection system
Vehicle was leaking fuel from fuel injection tube. When consumer started vehicle fuel started pouring out. also, had strong odor of gasoline. contacted dealer, and dealer stated no recalls, and to call nhtsa. *ak
- Child seat › Base
Problem with child safety seat. I have the fisher price stay in view. when the lever IS pulled to release the seat from the base, one of the mechanisms won't retract allowing you to release the seat. I have informed the manufacturer about this problem. *Ak
- Power train › Automatic transmission
Was just driving down road felt like front end was falling out and started jurking. turned around, had to keep pressure on transmission. paid $1600.00 to have transmission replace.
- Electrical system › Ignition › Module
Car would not start because computer went into security mode (while parked), shutting off fuel supply, although car IS not equipped with electronic security system. Computer had to be replaced with an o.e.m. Computer designed to prevent such random occurrances, at my expense of over $500 plus towing charge and inconvenience. *ak
- Structure
Vehicle was hit by a cart and dented the door, consumer saw another cart hit another vehicle which did not cause any damage, the consumer feels that the design of vehicles today are weak compared to the older ones. *slc
- Fuel system, gasoline › Fuel injection system
Fuel rail leakages caused fuel to leak all over engine. Spilled fuel could result in an engine compartment fire. *ak
- Fuel system, gasoline › Fuel injection system › Injectors
The fuel rail IS leaking from two spots. This was discovered by a mechanic after owner took vehicle to shop for heavy gas fumes. The vehicle IS being held at the body shop for repairs. The part IS on back order. Please provide any further information. *ak
- Visibility › Defroster/defogger/hvac system › Fan/motor
Whenever heater IS turned on vehicle would fail to heat up. Problem IS listed on recall(#91v004000), but not for this vehicle. Contacted dealer & mechanic ordered parts. Mechanic informed owner/manufacturer a month later than recall notice. *ak
- Service brakes, hydraulic › Foundation components › Disc › Rotor
While consumer was pulling away from a red light front right rotors split in half, causing loss of control. consumer was able to regain control of vehicle, and pulled over to the side of the road. *ak
- Power train › Automatic transmission
My first transmission failure was during warranty at approx 65,000 miles in 1995. my second transmission failure was in 1997 at 115,000 miles. since I was out of warranty, and did not think chrysler/dodge would replace my transmission I had it rebuilt at my own expense for more than $1700.00. do you think chrysler will reimburse me??.
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Brakes won't stop vehicle. Consumer has had several problems with these brakes. *Ak
- Unknown or other
No summary
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- ABS braking malfunction
There is no summary currently available
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 6092304Subject regarding non-deployed airbag handling procedures.
- 6089800Daimlerchrysler corporation IS now offerinb airbag on / off switches for selected vehicles.
- 6089028Information on 41te/42le service information. *Nlm
- 6088988Concerns with 41te/42le transaxle shudder during an emcc (electronically modulated converter clutch) shift. *Nlm
- 6088834Information regarding nhtsa authorized airbag deactivation for medical necessity. *Nlm
- 6088786Concerns with engine coolant usage. *Nlm
- 621898Automatic transmission fluid usage ATF+4.
- 620059Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty.
- 618049Subject regarding wire splice repairs.
- 615688Subject regarding child seat tether anchors.
- 612160Subject on the child seat tether anchors. *Mjs
- 610635Subject regarding child seat tether anchors.
- 609995This bulletin provides a revised wire splice procedure and related parts.
- 607963Information on child seat tether anchors.
- 607959This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket.
- 605014Conditions with intermittent loss of speed control.
- 604696Subject regarding reusable automatic transmission oil pan gasket.
- 604364Service and parts information on 1999 running changes to transmission range sensor (trs)
- 603153Subject regarding airbag on - off switches.
- 600862Information on installation of radio transmitting equipment.
- 600751Subject on delayed transaxle engagement.
- 54423Authorized airbag deactivation for medical necessity.
- 54371Condition with tranaxle shudder during a 3RD gear to 3RD gear partial emcc ( electronically modulated converter clutch) engagement, 3RD gear partial emcc to 4TH gear partial emcc engagement, or 4TH gear to 4TH gear emcc engagement.
- 52963Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of ethylene glycol.
- 51993Vehicle shudder during torque converter emcc (lock up) operation/diagnostic trouble code 38.
- 51978Vehicles with 3.0L engines - intake valve deposits - driveway die out, rough idle, lack of power, sags or hesitation.
- 51942Difficult to clean light colored "chalky" residue from plastic body components that are molded in black.
- 46371Bulletin supersedes technical service bulletin 08-16-95, dated apr. 14, 1995. If the vehicle operator **repeatedly** presses and releases the set button with their foot off of the accelerator (a 'lift foot set' to begin speed control operation), the vehicle may accelerate and exceed the desired set speed by up to 5 mph (8 km/h) and then decelerate to less than the desired set speed before finally achieving the desired set speed.
- 43055Unknown
- 41049Cruise control overshoot/undershoot during initial set speed selection.
- 39009Improved transmission shift quality.
- 39005Serpentine belt comes off pulleys.
- 37858Pcm not properly disengaging a/c clutch via the relay also the pcm may not energize the a/c clutch relay.
Every Dodge Dynasty model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.