2007 Fleetwood Excursion
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Fleetwood › Excursion › 2007
These records cover every 2007 Fleetwood Excursion. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2007 Fleetwood Excursion. Newest first.
Fleetwood IS recalling 3,782 my 2006-2009 providence, excursion, expedition, discovery and boulder diesel motor homes. the battery cable IS routed too close to a sharp edge located on top of a shelf installed over the driveshaft.
Risk and remedy
Risk
This can cause abrasion to the battery cable insulation, leading to an electrical short and possibly a fire.
Remedy
Dealers will re-route the cable away from the sharp edge location. This service will be performed for you free of charge. the recall began on may, 26 2009. owners may contact fleetwood at 800-509-3418.
Fleetwood IS recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard…
Risk and remedy
Risk
If this solution IS exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
Remedy
Fleetwood IS working with dometic to repair these refrigerators (please see 08e032). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. To manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216.
Freightliner IS recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (aac) front axles. during the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
Risk and remedy
Risk
Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
Remedy
Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. the recall began on december 21, 2007. owners can contact freightliner at 1-800-547-0712.
Certain motor homes fail to comply with section 6.2.6, "marking of alternative exits," as required by the ansi/nfpa 1192 standard on recreational vehicles. the dinette alternate exit/emergency egress window IS not identified by an exit label and red egress latches. this window IS used to exit the motor home in an emergency situation and must be clearly…
Risk and remedy
Risk
In the event of a crash, a passenger may not know immediately where the exit/ emergency egress window would be located, increasing the risk of injury.
Remedy
Dealers will inspect and replace the existing black window latch with a red egress window latch and apply the "exit" label to the dinette alternative exit/ emergency egress window. the recall began on february 15, 2007. owners may contact fleetwood at 1-800-509-3418.
Owner complaints
3 complaints1 involved a fire
What owners report most
Latest complaints
- Electrical system · Engine
The battery cables and wiring go through a firewall that IS metal. the hole in the firewall does not contain any type of gasket or protective material and as a result the cables and wiring rub along the metal hole in the firewall. the cables and wires rub on the metal and cut through the…
The battery cables and wiring go through a firewall that IS metal. the hole in the firewall does not contain any type of gasket or protective material and as a result the cables and wiring rub along the metal hole in the firewall. the cables and wires rub on the metal and cut through the protective coating on the cables and wires thus exposing them to contact the metal and causing a short, arc and fire. the heat then compromises all the other cables resulting in them also losing their protective coatings and fire results. over 38 cables and wires have been destroyed and we have lost all electrical components to the rv. while driving the vehicle on may 27, 2016 it shifted out of drive on its own causing an immediate slow down in addition to the fire hazard. there was a fire in battery compartment and underneath motor home where the cables and wires ran through the metal fire wall.
- Visibility
TL* the contact owns a 2007 fleetwood excursion rv. The contact stated that he noticed that the driver side window had an abnormal accumulation of moisture and fog. The contact stated that the failure would become worse during rainy weather. The manufacturer advised the contact that they could not…
TL* the contact owns a 2007 fleetwood excursion rv. The contact stated that he noticed that the driver side window had an abnormal accumulation of moisture and fog. The contact stated that the failure would become worse during rainy weather. The manufacturer advised the contact that they could not assist. The vehicle was not taken to the dealer for diagnosis of the failure or repairs. The failure and current mileage was 10,045.
- Service brakes, air › Drum › Drum · Service brakes, air › Drum › Shoes/linings
Defective motorcoach brakes 01/07/07 test drove new motor coach. during test drive it was difficult to slow the rv down. 01/09/07 rv taken to chassis manufacturer by dealer for brake noise. 01/11/07 received call from dealer that the chassis manufacturer had to replace a brake drum due…
Defective motorcoach brakes 01/07/07 test drove new motor coach. during test drive it was difficult to slow the rv down. 01/09/07 rv taken to chassis manufacturer by dealer for brake noise. 01/11/07 received call from dealer that the chassis manufacturer had to replace a brake drum due to a recall on the brake drums. 01/13/07 received document that stated that the drums were found to be glazed and the drums were turned and the shoes were arched. it also stated that the rollers and the s cams were to be inspected and cleaned as needed. purchased motorhome. 01/14/07 returned rv to dealer for brake noise and vibration. 01/15/07 contacted the chassis manufacturer. the rep told me that there was no recall on the brake drums and that the brake drums were turned to about 10/1000 and that the rollers were cleaned and lubed due to corrosion found on the rollers. the rep also went on to say that the brake drums were found to be glazed and that they got real hot. 01/16/07document from chassis manufacturer shop states that brakes were checked for proper assembly and taken on a road test to burnish in brakes. no inspection performed by manufacturer. 01/26/07brought rv in for brake inspection at an independent shop. same braking condition exists after inspection. 02/13/07brought rv into rv repair shop. instructed shop to inspect the brakes for complete condition and obtain p/n's off of all four drums. the rv had rarely been driven. 02/20/07brought rv into a motorhome representative dealer (not original dealer) for a brake inspection. 02/23/07brought rv into brake and clutch shop for an additional brake inspection. this vehicle has a severe brake problem that shakes the steering wheel and has an excessively loud brake squeal and rumbling. drums @ 100/1000 at last brake inspection vehicle will not be driven. *jb
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10022825Electric levelers may fail to operate properly due to an open circuit in the sensor harness, or a control module that does not function per design. Updated 6/14/10.
- 10022565Accumulation of moisture inside the electric leveler motor brake boot. This causes corrosion of the leveler brake and subsequent seizure of the leveler motor. Fleetwood. Updated 7/6/09.
- 10022211Replace the controller for power gear electric jack levelers. Updated on 10/01/07. Updated 4/28/10.
Every Fleetwood Excursion model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.