2007 Ford F-750 SD

Recalls

1 recall names the 2007 Ford F-750 SD. Newest first.

• Power train › Axle assembly

  Jun 5, 2007NHTSA 07V23800031 vehicles

  On certain trucks built with dana rear axles, the rear axle may have a housing that was built using steel that was thinner than specified.

  Risk and remedy

  Risk

  Through normal use, the axle housing could fatigue and develop a crack which could result in a wheel end lock-up or separation, possibly resulting in a crash.

  Remedy

  Dealers will replace the axle free of charge. the recall began on june 12, 2007. owners may contact ford at 1-800-248-0186.

  Full recall details →

Owner complaints

What owners report most

1. Engine and engine cooling1
2. Power train1
3. Service brakes1
4. Service brakes, air1

Latest complaints

• Jan 5, 2013NH150,000 mi
  Power train · Service brakes
  After a repair to the transmission by a licensed facility, the prop shaft departed the rear axle due to a flange breaking. the prop shaft failed around and tore off the wiring harness to the transmission and the rear brake lines; the cable to the emergency brake was also compromised. As a result…

  After a repair to the transmission by a licensed facility, the prop shaft departed the rear axle due to a flange breaking. the prop shaft failed around and tore off the wiring harness to the transmission and the rear brake lines; the cable to the emergency brake was also compromised. As a result, the engine stopped. All power steering and all braking was lost; the truck rolled to a stop, and then rolled backwards on a busy highway. the driver was able to steer the vehicle into a snow bank. I feel this IS a safety issue as a failure like this should not have caused such a catastrophic loss of control- the front brakes at least should have worked. *tr

• Feb 12, 2009TX23,079 mi
  Engine and engine cooling › Exhaust system · Service brakes, air
  Tl*the contact owns a 2007 ford F-750 sd. while driving in reverse at 5 mph, the air muffler became unwelded and the air brakes failed. as a result, the contact could not stop the vehicle. the dealer stated that he must purchase new parts and repair the vehicle himself. the contact purchased…

  Tl*the contact owns a 2007 ford F-750 sd. while driving in reverse at 5 mph, the air muffler became unwelded and the air brakes failed. as a result, the contact could not stop the vehicle. the dealer stated that he must purchase new parts and repair the vehicle himself. the contact purchased the new parts, which are now a different design, and made a mechanic perform the repairs. the vehicle IS currently driving properly. the failure mileage was 23,079. updated 3/9/09 *cn the consumer stated the brakes failed while he was backing out of his driveway. The problem was a faulty air muffler that was improperly welded. Updated 03/11/09. *Jb

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10205026Exterior mirror - tubular stainless steel west coast style mirror - loose mounting bracket
• 10204983Exterior Mirror - Tubular stainless steel west cpast style mirror - Loose mounting bracket
• 10183762Some 2006-2015 F-Super Duty 650/750 vehicles equipped with exterior tubular stainless steel west coast style mirrors may have a loose mounting bracket due to poor rivet retention.
• 10095225Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4X4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit IS now available for customer purchase. The kit IS designed for severe duty and IS non warrantable. The knuckle seal shield kit gc3z-54024a38-a includes an instruction sheet.
• 10056196Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, F-53 motorhome chassis, low cab forward.
• 10055629Ford: on some trucks, there IS a no crank situation and if voltage on transmission range sensor at pin 21, IS less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. Model 2003-2007 f super duty, 2004-2010 e series, 2003-2005 excursion.
• 10039053Ford: if there IS an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
• 10029424Ford truck: some vehicles may exhibit a loose set back. Follow the service procedure steps to correct the condition.
• 10026387Ford: 6.0L diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
• 100243256.0L turbocharger carbon deposit diagnostics and service tips. Updated 5/29/08.
• 100238556.0L--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles.
• 10023852Some 2004-2008 f-super duty 650-750 vehicles equipped with air suspension may exhibit a condition where the air suspension springs are not re-inflating.
• 100234352005-2008 f-super duty manual transmission- clutch pedal concern.
• 10023233Some 2005-2007 F-650 and F-750 vehicles equipped w/ a 6.0L diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
• 10022675Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10022673Stuck or jumping/bouncing/erratic speedometer and/or tachometer.
• 10022297White smoke, lacks power, exhaust odor, surges, runs rough, or no start.
• 100222936.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct.
• 10022283Rear of vehicle IS too high/low -5TH wheel and goose neck applications.
• 10022280Buck/jerk when pulling large heavy gooseneck trailers. Diesel engines. Reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue.
• 10022243Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10022236Misfire and dtc p0300.
• 10022234Turn signals flashing rapidly after modification.
• 10022233Misfire and dtc p0300.
• 10022232Headlight adjustment needed.
• 10022229Lack of power or lack of performance condition when operated above 5,000 feet of altitude.
• 10021978Power steering pump pulley alignment.
• 10021903ABS light on and possible c1175, c1236, p0500,p0503.
• 10021901Dual fuel tank. One empty fuel does not transfer. Updated 2/6/08.
• 10021621Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10021619Air filter water ingestion / snow packing with codes p0103.
• 10021485White smoke, lacks power, exhaust odor, surges, runs rough, or no start.
• 10021484Adding additional bulbs to turn indicator or hazard flasher circuits.
• 10021483Right fuel tank empty - fuel does not transfer from left tank.
• 10021482No start, no ecm/tcm communications and/or flashing automatic transmission indicator.
• 100214646.0L oil seep or boost pressure leak at hot side charge air cooler duct.
• 10021462Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start.
• 100212786.0L - reduced engine performance - high altitude.
• 10021236Lack of cooling fan operation.
• 10021235Runs rough or misfire due to a stuck valve.

Every Ford F-750 SD model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.