1996 Ford Ford Truck
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Ford Truck › 1996
These records cover every 1996 Ford Ford Truck. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Owner complaints
18 complaints2 involved a crash
What owners report most
Latest complaints
- Fuel system, diesel
Corrosion in ford lcf commercial truck fuel tanks, truck running at 5 miles per hour and continuous stalling of vehicle. *Tr
- Electrical system › Wiring › Front underhood · Vehicle speed control
Received a notice, september 2005, from ford motor company, that a defective switch in the speed control system exist on certain model vehicles, including mine. the switch can cause a fire under the hood with the engine running or off. switches will be available in november 2005. as of this…
Received a notice, september 2005, from ford motor company, that a defective switch in the speed control system exist on certain model vehicles, including mine. the switch can cause a fire under the hood with the engine running or off. switches will be available in november 2005. as of this date no available switches at any dealer I've called. they keep saying next month. called ford motor co. And they are saying the new switches will be available in june 2008. *tr
- Tires
Truck damange due to tire blow-out
- Engine and engine cooling › Engine
The head gasket of my 1996 ford windstar van failed at 79,900 miles. this failure in 1995 ford windstar vans resulted in a recall where ford motors replaced the engines of those vehicles. I am told by my ford platinum mechanic that the 1995 and 1996 windstar engines are the same and that the…
The head gasket of my 1996 ford windstar van failed at 79,900 miles. this failure in 1995 ford windstar vans resulted in a recall where ford motors replaced the engines of those vehicles. I am told by my ford platinum mechanic that the 1995 and 1996 windstar engines are the same and that the gaskets were supplied by the same supplier. My van was manufactured in october, 1995. this failure occurs in other ford motors 3.8 engines, specifically the crown victoria, and lincoln towncar. *Ak
- Tires
While driving at 45 mph right rear tire blew out due to a split in the sidewall, causing driver to pull over, off the road.*ak
- Power train › Automatic transmission
Truck was purchased used with 20,907 miles. Transmission was replaced at 10,000 miles. The transmission went out again at 21, 828 about 11,000 miles later.
- Tires › Tread/belt
Tread separated while driving making it difficult to drive, dealers refused to replace tire because it was not on recall(firestone fr 480 p235r75/15).*et
- Tires
This IS the letter I e-mailed to firestone_consumers_affairs, friday, september 22, 2000. I have had three of my six firestone tires fail with tread separation. These tires are not listed on the recall list. I drive a 1996 27' gulfstream conquest 102 motor home. I am a bachelor: consequently, I…
This IS the letter I e-mailed to firestone_consumers_affairs, friday, september 22, 2000. I have had three of my six firestone tires fail with tread separation. These tires are not listed on the recall list. I drive a 1996 27' gulfstream conquest 102 motor home. I am a bachelor: consequently, I travel alone and carry a relatively small load. All three failures have occurred while driving 55 mph on asphalt roads. The temperature was about 92 to 95 degrees and the roads were smooth, without potholes. My instructions on the doorframe indicate my rear duals should be inflated to 80 psi, the front to 60 psi. I put 80 psi in the front also. the first firestone lt225/r75-16 m&s steeltex radial R4S separated in movile, alabama with about 8,000 miles on the motor home. These are all original equipment tires. I can't find my receipt for this one and the only indication IS that I now have a hercules tire where I did have a firestone. The second firestone lt225/r75-16 m&s steeltex radial R4S separated its tread near fermie, british columbia, canada. This was the left inside dual with about 27,000 miles on 08/04/2000. The tread separated and I was able to drive about 4 miles on the outside dual and reach larry's radiator, mechanical and auto body, 6678 hwy #3 east, fermie, b.c., vob 1MO, phone (250) 423-4111 or (800) 866-8766. the third firestone lt225/r75-16 m&s steeltex radial R4S separated its tread aboujt 3 miles south of thompson falls, montana on 08/14/2000 with about 27,000 miles on the original tires. This was the right inside dual. The tread separated and I was able to drive about 3 miles to reach ron's service, p.o. Box 88 - 606 main st., thompson falls, mt59873 phone (408) 827-4653. my cost: tire #1 - $126.47, tire #2 - $144.61 american dollars, tire #3 - $116.95, total $388.03 (dot number: vnilixa066 tiresize: 225/75r-16)
- Tires › Tread/belt
Right rear tread separated from tire damaging right lower quarter panel and tail pipe. nlm (firestone 2857516)
- Fuel system, gasoline › Storage › Tank assembly
Developed leaks in gas tank under front restraining strap .was repaired and another leak developed under front strap in same area.could have been a very hazerdous situation.seems that there IS a defect in the tank,similar to the 1995 ford windstar recall
- Electrical system › 12v/24v/48v battery › Cables · Engine and engine cooling › Engine › Gasoline
When drivng though a puddle @ slow speeds, battery light blinked and engine shut off. brought car into shop, was told loose battery connection. I read on your web site that other people have the same problem.
- Power train › Automatic transmission
This truck IS equipped with E4 od automatic transmission, while still under original warrentee I complained of jerky and rough shifting and was told by the service manager at the dealer, that this was normal, to protect myself at 32,000 miles I had the transissiom serviced and checked again for…
This truck IS equipped with E4 od automatic transmission, while still under original warrentee I complained of jerky and rough shifting and was told by the service manager at the dealer, that this was normal, to protect myself at 32,000 miles I had the transissiom serviced and checked again for defects, and was told everything was a-okay. the rough and jerky shifting still occurred. at 67,000 miles the E4 od transmission failed. a reputable transmission authority was contacted, the problem and this IS known by ford motor company, IS the transmission in the E4 od which was standard at the time for this model, was not sturdy enough to get the preported 100,000 miles that the dealers brag about. the torque converter IS too light weight for the 7.3 ltr engine and was completely dis intergrated, by the power of the engine. this had been on going even to the original warranty. ford IS aware of the problem as this E4 od transmission has had numerous recalls and sevice bulletins since it's conception in the early 1990's.. Ford motor company sent me a free 24 /24 extended warranty dated active 4 days after I paid $2500 for an overhaul of this E4 od transmission. I have 4 other ford products in my driveway and I'm so unhappy about this I feel like moving over to dodge. my family has always used ford products, but this time we are getting stuck with a huge repair bill that the ford dealer and ford motor company should be responsible for.
- Structure › Frame and members
Rivets and bolts needed replacement in the chassis, however dealership welded frame instead.
- Engine and engine cooling › Engine
Oil pan rusted out causing leakage.
- Seat belts › Front › Anchorage
Shoulder belts mounted to wall, causing belts to cross over the aisle of van, blocking aisle.
- Service brakes, air › Antilock
When pulling trailers the ABS, on these vehicles, IS active and it takes approximately 40% more braking room to stop. this has been observed on the ford and dodge one ton pick-up trucks.
- Engine and engine cooling › Cooling system
Hole in engine cylinder due to not adding chemnical additive to coolant system. *Dh
- Equipment › Electrical › Radio/tape deck/cd etc.
Driver has to take eyes off road to adjust radio due to the radio missing its knobs. *Dh
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 607360For availability of major assemblies, please refer to the exchange program guide.
- 51112Check engine light, code p030x, with no driveability complaint.
- 51041Verify the transaxle installed in the vehicle IS the correct model and model year for the vehicle.
- 505302.3L efi engines display a rolling idle concern.
- 50496Revised hose part# f6hz-9j291-a has been developed to replace hose that shows signs of deterioration, cracks may appear in the outer covering of the hose.
- 50495Information on servicing vehicles with fluid leak from the front axle vent. Revised cover PT# f6tz-4033-ba.
- 50476Vehicles may experience unexplained mil light codes &/or irregular shifting (A4LD). The -12a581- (95-96) or -12b637- (97) wire loom IS coming into contact w/ the center wiper access plate lwr ctr.
- 50431Information on part number for the rotunda tool that IS stated in safety recall rcl/96s48-rcl/96s99.
- 50430Clarified technical instructions for safety recall - rcl/96s54 (attachment III, dealer letter).
Every Ford Ford Truck model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.