1995 Ford F Super Duty
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › F Super Duty › 1995
These records cover every 1995 Ford F Super Duty. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 1995 Ford F Super Duty. Newest first.
Vehicle description: motor home chassis. hot exhaust gasses can leak from the exhaust gas return (egr) tube on the engine. a hole can develop in the flexible section of the tube. heat damage to the passenger compartment floor and floor covering can occur.
Risk and remedy
Risk
Depending on the materials used in the construction of the completed vehicle, ignition of these materials could occur resulting in a vehicle fire.
Remedy
Dealers will replace the egr tube.
Owner complaints
12 complaints3 involved a fire
What owners report most
Latest complaints
- Vehicle speed control
1995 ford f- superduty rollback burnt up while sitting in front of shop. burnt front of building and a customer car.
- Vehicle speed control
My ford F-350 with crewcab and duellys and power stroke 7.3 diesel engine caught fire after sitting idle for 3 days. Every ford mechanic says cruise control on diesels and gas engines are 100% interchangeable. *tr
- Fuel system, gasoline › Delivery › Fuel pump
Fuel pump failure. *bf the consumers father experienced the same defect. the engine also had run rough. (1996 coachman motor coach on a ford superduty chassis) *sc
- Electrical system › Wiring › Interior/under dash
The wiring harness connection box primary to the fuse box on my 1995 ford super duty with 7.3 turbo diesel caught fire. The box melted the big red wire, which was the cause . I am not the first person that had this problem. Now I have no dash lights and my dimmer switch had to be replaced. Should there be a recall on this problem? *jb
- Fuel system, gasoline › Delivery › Fuel pump
Owner of motor home had defective fuel pump that broke. manufacturer refused to replace/recall fuel pump and no replacement pumps available in the us. *tt
- Structure › Body › Door
No summary listed for abov evehicle. *ak
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Two times, on on 9/99 & the recent on 3/3/00, first at 9800 miles and the 2ND. At 28,236 miles. speed at first was at 55mph. And the 2ND. Time at 65mph. this IS a class a motorhome with a ford f- super duty chassis with a 34FT. Itasca by winnebago on it. the first time I hit a raised spot on…
Two times, on on 9/99 & the recent on 3/3/00, first at 9800 miles and the 2ND. At 28,236 miles. speed at first was at 55mph. And the 2ND. Time at 65mph. this IS a class a motorhome with a ford f- super duty chassis with a 34FT. Itasca by winnebago on it. the first time I hit a raised spot on the cement highway with the left front tire, and the 2ND. Time it was a 10 inch. Dia.,approx. 2Inch deep chuck hole with the left front tire. when it hits these disturbuances it causes the font end to go into a very tremendous shimmy, that IS so serve that I have to come to within 5MPH. Of a complete stop before it will come back to normal steering again. I have hit holes and cracks with the right front and does not bother it. the suspension, wheel bearing, shocks, steering box, pitman and linkage have been checked and all tight. it also has a hydraulic steering control on the steering cross shaft, which I do believe without it I could loose control before getting stopped. this shimmy or heebie jeebies IS so violent that the whole motorhome IS shaking things off of the table or knocking things onto the floor. I can not find any bulletins on this problem, and have read where class c cutaway 350 fords are having a problem similar to mine. This has happened 2 times in 28,300 miles which IS not much, but I get on a rough section of highway and it does cause mr to sit on pins and needles wondering when and if its going to go into its heebie- jeebies. Any help will be appreciated. Thankyou. *ak
- Equipment › Appliance › Air conditioner
A/c clutch belt also controls power steering and power brakes, broke causing difficulty in controlling vehicle. Mjs
- Suspension
Consumer experiences problem with no control of the coach whenever vehicle hits a small bump or lump in the road . This condition occurs intermittently. Dealer notified, and informed consumer that this condition cannot be corrected unless they can duplicate the problem. *ak
- Service brakes, hydraulic › Foundation components · Suspension
When brake pads wear 50% the caliper strikes the spring destroying the effectiveness of the brakes.
- Structure
On right hand side, front splash guard rubs against brake line, causing brake line to rupture. *ak the fender splash guard on the passenger side firewall rubs the hydro boost line and ruptures the hose. *slc
- Suspension › Front
Can be driving down the road and steering will jerk to either left or right make steering difficult had it serviced 11 times. tt
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10004856External oil leak diagnosis for 7.3L dit engines. Various models including 2003 super duty f series.
- 10004838Lack of power and/or low performance condition caused by no return fuel flow to the fuel tank.
- 10004836Aftermarket wiring alterations - service tip.
- 10004834Low rpm, no start, runs poorly, stall. 7.3L dit engine.
- 10004832A high number of high pressure rexroth pumps and injection pressure regulators (ipr) are being replaced due to oil leaking, when all that IS required IS a new gasket or seal on either the pump or ipr.
- 10004825The front end accessory drive (fead) belt may wear, shred and/or come off during deceleration.
- 10004823On vehicles with transmission build dates prior to 9/20/95, the overdrive cancel lamp may be illuminating and diagnostic trouble code (dtc) p1728 present and/or engine stall when reverse and/or manual low IS selected.
- 10004822No start/hard start and/or long crank time for vehicles with 7.3L di turbo diesel.
- 10004821Hard or no start, hesitation, idle rough, low power, misses, stalls.
- 10004820Availability of new sealant for servicing 7.3L di turbo engine.
- 10004819The water-in-fuel lamp may stay on and the fuel may be slow to drain or not drain at all when the fuel drain valve IS opened.
- 10004818Rear of engine oil pan, near the crankshaft, may leak oil.
- 10004817A lack of accelerator control when moving off of the idle position.
- 10004816Hard starting after the fuel injectors have been replaced.
- 10004815Poor idle quality and/or low output after the engine returns to idle speed.
- 10004814A no-start or reduced power condition may occur intermittently.
- 10004812Loss of power and malfunction indicator lamp may also illuminate with diagnostic trouble codes 128 and 845 or p0236 and p0238 stored in memory.
- 10003748New transmission cooler flusher - service tips. 2003 escort and super duty f series included.
- 10001943Exhaust air rush noise and lower power.
- 6090143Subject regarding 4r100 transmission flexplate replacement for vehicles with 7.3L diesel engine.
- 6090087Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems.
- 6090082Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement.
- 6089681Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses.
- 3057500Unknown
- 625715Brake shift interlock.*jb
- 623988Information regarding transmission fluid usage charts. *Slc
- 623944Some vehicles may exhibit heater core leaks. *Slc
- 616522Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system.
- 615171Rear brake drag or excessive wear on rear brakes.
- 615165Brief information concern vehicles exhbiting external oil leaks.
- 615163Information on vehicles exhibiting and o/d off lamp flashing with diagnostic trouble code 62 / 628 / 1728.
- 615162Brief information on vehicles exhibiting a stall on deceleration condition.
- 615155Brief information on vehicles exhibiting lack of power condition.
- 615154Brief information vehicles exhibiting hard start / no start condition.
- 615151Information on vehicles exhibiting rough idle / miss.
- 613350Service tip information regarding the reverse clutch piston and piston seal usage.
- 613341Experiencing front end shimmy occurring at various driving speeds and IS usually induced when hitting bumps such as large potholes or rough railroad crossings.
- 613021Experiencing excessive brake pedal travel accompanied by reduced braking effectiveness when the vehicle IS operated at an idle for extended periods, in hilly terrain, in high ambient temperatures and / or when the vehicle IS located in excess of its gross vehcle weight rating (gvwr).
- 612343Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system IS not properly flushed, fluid in-line filter kit. *Mjs
- 612203Information regarding the new transmission cooler flusher- service tip. *Mjs
Every Ford F Super Duty model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.