2007 Ford Super Duty

Owner complaints

Latest complaints

• Oct 20, 2017NC
  Engine

  Erg valve not working properly. Cooling/coolant system not working properly. engine gets too hot to run. Vehicle had to be towed and parked. now at mechanical shop.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10143079Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
• 10109070The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
• 10109021When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the 'brown' spark plug boots, as provided. The updated 'brown' spark plug boots are longer than the black boots to accommodate a running change in the spark plug length. The ignition coil bodies and spring/resistor are transferable and only the rubber boots require replacement. Failure to install the spark plug boots provided with the replacement engine could lead to drivability concerns.
• 10039053Ford: if there IS an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
• 10030838Ford: certain vehicles, e series and f super duty, with ambulance prep package ambulance class action settlement-6.0l diesel engine replacement warranty extension. Awareness communication dated 4/20/09.
• 10030837Ford: certain vehicles with ambulance prep package ambulance class action settlement; specific component warranty extension. Awareness communication, dated 4/20/09.
• 10030836Ford: multiple vehicles with a torq shift transmission intermittent clunk when shifting between drive, reverse and park and/or during 2-3 upshift. Models f super duty; e series; excursion; F53 motorhome chassis and low cab forward.
• 10028826Ford: some vehicles with diesel engines may experience no starts, hard starts or rough running when cold and may be accompanied with diagnostic trouble codes (dtcs) p0611, p1378 and/or all 8 injector circuit codes.
• 10028730Ford: some vehicles equipped with 6.0L diesel engine may exhibit any one or combination of the following concerns-lack of power, white/black smoke or a surge.
• 10028284Ford trucks: misfire, lack of power, buck/jerk, excessive smoke, crank/no start-diagnostics for fuel system. There are several potential causes for these symptoms.
• 10028125Ford: vehicles may exhibit fuel in the engine coolant, due to leaks in the cylinder head fuel injector area. Symptoms may include fuel in engine coolant and coolant expulsion from the degas bottle. Updated 3/20/09.

Every Ford Super Duty model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.