1999 Freightliner Columbia
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Freightliner › Columbia › 1999
These records cover every 1999 Freightliner Columbia. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 1999 Freightliner Columbia. Newest first.
On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
Risk and remedy
Risk
Seizure of the bearings can cause wheel separation or wheel end fire.
Remedy
Dealers will replace both front hubs. owner notification IS expected to begin on or before september 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an EC-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic…
Risk and remedy
Risk
This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
Remedy
Dealers will replace the ABS ecu.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Front brake air hose leaks
Certain 1998-2001 freightliner century and columbia vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage freightliner vehicles.the leaks have been frequently discovered at fmcsa roadside inspections since these inspections are conducted with the brakes applied (pressurizing the air hose)…
Certain 1998-2001 freightliner century and columbia vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage freightliner vehicles.the leaks have been frequently discovered at fmcsa roadside inspections since these inspections are conducted with the brakes applied (pressurizing the air hose) whereas driver pre-trip inspections may not always be performed with the brakes applied. After a thorough technical review of this matter,odi has concuded that while the subject vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage and peer vehicles, these leaks appear to be minor. Freightliner has extended the warranty for this component to 5 years, 500,000 miles and will assist in alerting those vehicle owners whose vehicles are most susceptible to front brake air hose leakage by issuing a service bulletin alerting those owners to the potential for front brake air hose leakage to occur. See attached report for full technical details.
- Integral hub and bearing assembly
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold…
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. Odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10195659SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
- 10195478SS 1033638 - Power Window Express Down Module Discontinued
- 10187830Revised Technical Service Letter for Series 60 and Series 50 Camshaft Timing Specifications. Camshaft timing, valve lash, injector height, and Jake Brake lash are all very important specifications that must be followed closely in order to optimize the performance and service life of any Detroit Diesel engine.
- 10184785Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
- 10181852Tech Talk discussion on 6067 PK60 engine smoking on start up.
- 10181049Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
- 10170603Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish. Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
- 10163599Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- 10163511Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
- 10161128Steering Intermediate Shaft Replacement
- 10160786Service Bulletin- sb54311 ICU Odometer Programming
- 10160773fp00024 Cable-Tie Reference
- 10158072Adjusting Tilt Lock Force on TRW Steering Columns
- 10158051Adjusting Tilt Lock Force on TRW Steering Columns
- 10158020Fuel Level Sending Unit Retrofit
- 10156420Adjusting Tilt Lock Force on TRW Steering Columns
- 10156399Adjusting Tilt Lock Force on TRW Steering Columns
- 10156370Technical Publications Ordering
- 10156368Fuel Level Sending Unit Retrofit
- 10156351Reminder: Paper Service Bulletin Mailings Are Discontinued
- 10154899Important Campaign Information on FL614 Recall
- 10151533Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
- 10151510Operating Hours for the Customer Assistance Center
- 10142300sb9815 Paint Finish Standards
- 1014228533-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
- 1014228435-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
- 1014227554-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
- 1014227254-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
- 1014227154-274 - Plastic Battery Box Cover Retainer Clip
- 10142073sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
- 10141700sb2061 Replacement Shunt Tube, EPA07 Caterpillar C13 and C15 Engines
- 10141699sb2059 Replacing Push-to-Connect Air Line Fittings with Brass Compression Fittings
- 10141698sb2058 Early EPA07 QLD Radiator Replacement
- 10141697sb2057 New Surge Tank Design
- 10141696sb2056 Transmission Oil Line Removal and Installation
- 10141695sb2055 Columbia Surge Tank Shunt Tube Support Bracket Breaking
- 10141692sb2051 Radiator Surge Tank Vent Line Plumbing
- 10141681sb2040 New-Style Coolant Hose Clamps Available
- 10141680sb2039 Cummins N14 Fan Drive Belt
- 10049539Freightliner: brake s-cam tube lubrication interval change. To ensure optimum service life and trouble-free operation, the recommended maintenance interval for lubricating meritor s-cam brake tubes on century class, columbia, cascadia and coronado over-the-road vehicles IS changed from M2 to the M1 maintenance interval.
Every Freightliner Columbia model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.