2018 Genesis G80
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Genesis › G80 › 2018
These records cover every 2018 Genesis G80. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2018 Genesis G80. Newest first.
Hyundai Motor America (Genesis) is recalling certain 2015-2016 Hyundai Genesis, and 2017-2020 Genesis G80 vehicles. The front power seat motors may overheat due to a stuck power seat control switch, which can result in a fire while parked or driving.
Risk and remedy
Risk
A fire increases the risk of injury.
Remedy
Owners are advised to park their vehicles outdoors and away from other vehicles or structures until the repair has been performed. The remedy is currently under development. Owner notification letters are expected to be mailed December 7, 2026. Owners of Hyundai vehicles may contact Hyundai customer service at 1-855-371-9460. Genesis owners may contact Genesis customer service at 844-340-9741. Hyundai recall number for this recall is 308 and Genesis' recall number is 035G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 13, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2018-2020 Genesis G80, 2017-2022 G90, and 2019-2022 G70 vehicles equipped with a 3.3-liter V6 turbocharged engine. The left turbocharger oil feed pipe may deteriorate and leak oil.
Risk and remedy
Risk
An oil leak in the presence of hot engine components can increase the risk of an engine compartment fire.
Remedy
Dealers will replace the left turbocharger oil feed pipe, free of charge. Owner notification letters were mailed May 3, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 019G. This recall expands and replaces recall number 19V-538. Vehicles previously repaired under 19V-538 will need to have the new remedy completed.
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Genesis, 2017-2019 Genesis G80, Genesis G90, and 2019 Genesis G70 vehicles. Water may enter the starter solenoid and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Risk and remedy
Risk
An engine compartment fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a remedy relay kit in the engine junction box, free of charge. Owner notification letters were mailed July 15, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 254(H) and 018G(G).
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Genesis and 2017-2020 Genesis G80 vehicles. The Anti-Lock Brake System (ABS) module could malfunction and short circuit.
Risk and remedy
Risk
An electrical short circuit inside the ABS module could cause an engine compartment fire while parked or driving.
Remedy
Owners are advised to park outside and away from structures until the remedy is complete. Hyundai will notify owners, and dealers will replace the ABS module fuse, free of charge. Owner notification letters were mailed July 6, 2021. Owners can contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 201 and 006G.
Hyundai Motor America (Hyundai) is recalling certain 2018 Genesis G80 and 2017-2018 Genesis G90 vehicles equipped with 3.3 liter turbocharged engines. The turbocharger oil supply pipe may have a loose seal, causing oil to leak onto the exhaust manifold.
Risk and remedy
Risk
Oil leaking onto the exhaust manifold increases the risk of a fire.
Remedy
Hyundai will notify owners, and dealers will replace the turbocharger oil supply pipe, free of charge. The recall began October 3, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 003G.
Hyundai Motor America (Hyundai) is recalling certain 2018 Genesis G80 vehicles. The Occupant Classification System (OCS) may incorrectly detect that an adult is in the passenger seat, even if the seat is unoccupied. In the event of a crash, if a child or infant is in the seat, the front passenger air bag may deploy instead of being deactivated.
Risk and remedy
Risk
In the event of a crash, if the front passenger air bag deploys instead of being deactivated when a child or infant are in the front passenger seat, it can increase the risk of injury.
Remedy
Hyundai will notify owners, and dealers will reprogram the OCS, free of charge. The recall began August 24, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 002G.
Hyundai Motor America (Hyundai) is recalling certain 2018 Hyundai Genesis G80 and Genesis G90 vehicles. The windshield and rear window on these vehicles may have been installed with incorrect primer, potentially reducing the glass bonding strength.
Risk and remedy
Risk
If the glass bonding strength is reduced over time, the windshield and rear window may detach while driving, increasing the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will replace the front and rear glass, free of charge. The recall began on July 6, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 001G.
Owner complaints
99 complaints8 involved a crash1 involved a fire5 injuries
What owners report most
Latest complaints
- Electrical system · Engine · Unknown or other
This complaint is filed regarding an under-hood thermal fire incident and unauthorized modification involving a federally mandated safety recall for a 2018 Genesis G80 (VIN: [XXX]). To resolve a starting issue, technicians at Van Hyundai in [XXX], bypassed the standard ignition circuit and…
This complaint is filed regarding an under-hood thermal fire incident and unauthorized modification involving a federally mandated safety recall for a 2018 Genesis G80 (VIN: [XXX]). To resolve a starting issue, technicians at Van Hyundai in [XXX], bypassed the standard ignition circuit and installed an un-fused manual starter bypass switch kit. This bypass directly conflicted with active NHTSA Safety Recall Campaign 24V107000, which requires a specific fused relay kit (Part 91950-DH15KQQH) to prevent engine fires. This unauthorized, un-fused modification caused a severe electrical short and a subsequent thermal fire incident under the hood. The fire physically melted and destroyed the recall component and adjacent wiring infrastructure. The dealership and corporate office are now refusing to fix the fire damage they caused unless I pay out of pocket. I request an immediate federal investigation into this hazardous repair practice that completely compromised a critical safety recall remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Unknown or other
Failing oil pressure sensor which “blinds” the driver of the engines true oil levels. It occasionally causes the car to go into “limp” mode or stall which could cause unnecessary and unreasonable traffic safety hazards. This is a well known and documented critical safety defect by Genesis as they’ve already executed a recall for the issue in their home country / market of South Korea.
- Steering
When negotiating a curve, the steering wheel sticks and does not return to center without the driver forcing the wheel back to the required direction. Instead of a smooth and consistent feeling when turning the wheel, the steering wheel feels "locked" until the driver's force breaks the steering…
When negotiating a curve, the steering wheel sticks and does not return to center without the driver forcing the wheel back to the required direction. Instead of a smooth and consistent feeling when turning the wheel, the steering wheel feels "locked" until the driver's force breaks the steering wheel free. In addition, the steering wheel makes a faint but noticeable grinding noise when turned in either direction. No warning lights illuminate.
- Seats
The contact owns a 2018 Genesis G80. The contact received a recall notification for NHTSA Campaign Number: 26V664000 (Seats); however, the parts to complete the recall repair were unavailable. The dealer was contacted, and the contact was informed the parts were unavailable to perform the recall repair.
- Unknown or other
After 2 hours on the road August 1, 2026 (from [XXX] to [XXX]), in 119-degree heat, the AC stopped blowing cold air out of the dash vents. There was cold air coming out of the rear-seat vent. The vehicle became unbearably hot. (Took my wife 2 days to recover from heat exhaustion.) The AC started…
After 2 hours on the road August 1, 2026 (from [XXX] to [XXX]), in 119-degree heat, the AC stopped blowing cold air out of the dash vents. There was cold air coming out of the rear-seat vent. The vehicle became unbearably hot. (Took my wife 2 days to recover from heat exhaustion.) The AC started working properly after the car sat for a few days in [XXX]. The Genesis Escondido service shop has not been able to duplicate the problem. The vehicle is still there at the shop. Genesis Customer Care assigned a case # XXX, but are unwilling to buy the car back, or do anything else except contact Genesis Escondido service dept. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Unknown or other
Dear NHTSA Office of Defects Investigation, I am submitting this letter to request an urgent review of a recurring and widespread air‑conditioning failure in the 2018 Genesis G80. The AC system consistently shuts off after extended driving and does not cool down when the car starts, especially in…
Dear NHTSA Office of Defects Investigation, I am submitting this letter to request an urgent review of a recurring and widespread air‑conditioning failure in the 2018 Genesis G80. The AC system consistently shuts off after extended driving and does not cool down when the car starts, especially in high‑heat environments In Texas, cabin temperatures can exceed 120°F, creating conditions that can lead to heat exhaustion or heat‑related illness. This is not an isolated incident. Many owners have reported identical symptoms: AC cooling stops after prolonged operation, airflow continues but without cooling, and the system only resets or thaws after the vehicle sits for an extended period. Despite these repeated complaints, no investigation or recall has been initiated. While AC failure is typically categorized as a comfort issue, the extreme heat exposure caused by this defect presents a legitimate safety concern. Occupants may become ill, visibility can be affected by humidity and fogging, and the failure appears to be tied to HVAC components that may not be functioning as designed.I respectfully request that NHTSA open a defect investigation into this issue to determine whether a safety recall is warranted. Thank you for your time and consideration.
- Unknown or other
Driver side rear door electric latch is stop working and i tried to open the latch manually but the locked latch won't let me but remain locked. I have concerns with the situation because when door latch were broken due to accident, the door would remain locked and passengers would not be able to escape from inside of the car
- Engine and engine cooling
The contact owns a 2018 Genesis G80. The contact stated that the Check Oil and Low Oil warning light illuminated while the vehicle was idling. The warning lights turned off while driving. The vehicle was not taken to the dealer or an independent mechanic to be repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 72,200.
- Air bags · Unknown or other
⭐ 1. The Airbag Control Unit (ACU) and associated restraint‑system components appear to have malfunctioned. The Event Data Recorder shows inconsistent airbag deployment staging, a pretensioner firing while the belt was recorded as unbuckled, a seat‑track sensor fault, unsupported…
⭐ 1. The Airbag Control Unit (ACU) and associated restraint‑system components appear to have malfunctioned. The Event Data Recorder shows inconsistent airbag deployment staging, a pretensioner firing while the belt was recorded as unbuckled, a seat‑track sensor fault, unsupported occupant‑classification data, incomplete curtain‑airbag deployment during rollover, and missing crash‑event data. Yes, the vehicle and the full 29‑page EDR report are available for inspection upon request. ⭐ 2. The restraint system did not protect the occupants as expected. I suffered chest injuries from hitting the steering wheel, and my passenger sustained injuries to their hand and arm. These injuries occurred because the driver airbag did not deploy correctly, the pretensioner logic was inconsistent, and the curtain airbags did not deploy on the driver side despite multiple full vehicle rotations. The system’s irregular behavior increased the risk of serious injury or death. ⭐ 3. No. The issue occurred during a crash event and cannot be safely reproduced. However, the malfunction is confirmed by the vehicle’s own Event Data Recorder, which documents the deployment irregularities, sensor faults, and data‑integrity issues. ⭐ 4. The vehicle was inspected by insurance representatives after the crash. The manufacturer has not performed an engineering‑level inspection of the Airbag Control Unit or restraint‑system logic. The EDR report was obtained through the insurance process and serves as the primary source documenting the malfunction. ⭐ 5. No warning lamps or messages appeared prior to the crash. There were no symptoms indicating that the airbag or restraint system would malfunction. The failures were only discovered after reviewing the Event Data Recorder.
- Air bags
The contact owns a 2018 Genesis G80. The contact stated that while driving at an undisclosed speed, the contact's vehicle was involved in a crash. The contact stated that the vehicle crashed into a deer, and then crashed into a hill. The vehicle spun around three times and rolled over after…
The contact owns a 2018 Genesis G80. The contact stated that while driving at an undisclosed speed, the contact's vehicle was involved in a crash. The contact stated that the vehicle crashed into a deer, and then crashed into a hill. The vehicle spun around three times and rolled over after crashing into the hill. The front driver's air bag did not deploy. The contact stated that no warning lights were illuminated. A Police report was filed. The contact sustained bruises to the chest and back pain. The passenger who was seated in the front passenger's seat sustained bruises. No medical treatment was provided at the scene of the crash, however the contact later visited her primary physician. The vehicle was towed to the contact's family members' residence and later towed to the contact's residence. The insurance inspection confirmed that, according to the EDR, the front diver's air bag skipped stage one. In addition, the contact was informed that an unknown recall had been initiated for the front passenger's air bag for the vehicle. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the aftermarket seat covers were the cause of the steering wheel's functionality not functioning as intended. The contact was informed that the aftermarket seat cover was the cause of the driver's side air bag not deploying. The contact stated that the seat covers were purchased after the crash to cover the damaged seats as a result of the crash. The failure mileage was approximately 126,000.
- Exterior lighting
When operating the headlights in auto dim mode and the headlights are bright, when I try to dim the headlights manually using the dimmer switch, the headlights go out completely. When operating the headlights with auto dim mode turned off and the headlights are bright, when I try to dim the…
When operating the headlights in auto dim mode and the headlights are bright, when I try to dim the headlights manually using the dimmer switch, the headlights go out completely. When operating the headlights with auto dim mode turned off and the headlights are bright, when I try to dim the headlights manually using the dimmer switch, the headlights will not dim. This places myself and oncoming traffic at risk by them either being blinded by the high beams when I'm unable to dim or me hitting them or another object when the lights go out completely when I try to dim them. I reported this to the local dealer who mentioned similar issues on model years prior to mine which were sold under the Hyundai Genesis branding. I will note that the Hyundai Genesis model and my Genesis G80 model use the same platform.....the cars are identical except for the branding. The Hyundai Genesis model referenced had a recall for this issue, so I don't understand why the same recall hasn't been issued for the Genesis G80 model, which is having the same safety issues.
- Air bags
I was in a accident severe enough to deploy all air bags but my steering wheel, I went to genesis with the issue and they inspected the car when they edr report came back everything matched but the model of the car it comes back to a GV80, on my genesis app my car comes back as a G90, my car IS a…
I was in a accident severe enough to deploy all air bags but my steering wheel, I went to genesis with the issue and they inspected the car when they edr report came back everything matched but the model of the car it comes back to a GV80, on my genesis app my car comes back as a G90, my car IS a genesis G80 the matter concerns conflicting vehicle indetifaction data across multiple official genesis systems as well as a failure of the airbag to deploy during a crash. two idenpendent genesis systems - the event data recorder edr and the official genesis owner portal are identifying my vehicle as a different model a genesis GV80 and G90 despite my car being a G80. these systems should never disagree about the vehicles identity as they are responsible for safety critical information crash data warranty tracking and recall eligibility.. the edr box showing the incorrect model identifaction .. This IS a major defect data misclassification and a safety system failure that calls for a recall
- Air bags
The contact owned a 2018 Genesis G80. The contact stated that while driving at an undisclosed speed during the night, a deer hit the contact's vehicle on the front passenger side. The vehicle spun around and ended up in a "grass hill" where it came to a stop. The driver-side air bags did not…
The contact owned a 2018 Genesis G80. The contact stated that while driving at an undisclosed speed during the night, a deer hit the contact's vehicle on the front passenger side. The vehicle spun around and ended up in a "grass hill" where it came to a stop. The driver-side air bags did not deploy. However, the front passenger and side curtain air bags were deployed. The front passenger-side control arm detached from the vehicle due to the impact. The police were called and filed a police report. The contact and the passenger were not injured. The vehicle was towed to the residence. The contact took the vehicle to the dealer. The manufacturer was notified of the failure, and a field inspector from Genesis stopped by the Hyundai dealer to retrieve the Event Data Recorder (EDR). The inspector informed the contact that the Event Data Recorder (EDR) showed that the contact's vehicle was a GV80. The contact stated that her vehicle is a G80. The field inspector then requested permission from the contact to retrieve the information from the Event Data Recorder (EDR) to change the vehicle information to a G80. The contact refused. The contact stated that the Genesis application on the contact's phone provided the following codes: B1378, which meant that the "Side Airbag Front-Driver Resistance is too High," and B1649, which meant "Crash Recorded - Rollover Event." The dealer replaced the control arm. The air bags were still deflated. The vehicle is at the contact's residence. The insurance company was informed. The failure mileage was approximately 127,000.
- Air bags · Electrical system · Steering
I am writing to formally report a serious safety defect in my Genesis vehicle and to request immediate investigation, documentation, and corrective action. Following a recent crash event, my vehicle’s diagnostic scan revealed DTC B1378, which is associated with a fault in the airbag system…
I am writing to formally report a serious safety defect in my Genesis vehicle and to request immediate investigation, documentation, and corrective action. Following a recent crash event, my vehicle’s diagnostic scan revealed DTC B1378, which is associated with a fault in the airbag system circuitry. This code is widely recognized as an indicator of an airbag defect and is consistent with conditions that warrant manufacturer recall. During the crash: - Multiple airbags deployed, - The steering‑wheel airbag did NOT deploy, - The SRS system recorded a crash severe enough to trigger other airbags, - The vehicle now displays B1378, confirming an internal fault. The failure of the primary driver airbag to deploy during a crash is a critical safety malfunction. Combined with the presence of B1378, this raises substantial concerns regarding a defective airbag module, wiring harness, or sensor — all of which fall under manufacturer responsibility and federal safety standards. I am requesting the following: Immediate corrective action, including repair or replacement of all defective components. Documentation of this issue in your internal safety‑defect tracking system. Given the severity of this failure and its implications for driver safety, I am also submitting this information to the National Highway Traffic Safety Administration (NHTSA) for review. Please confirm receipt of this letter and provide a written response outlining the next steps. Sincerely, [XXX] Hagerstown, MD --- INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system
There is a known issue with these vehicles where the Oil Pressure Sensor/Switch triggers at idle and low RPMs but nothing is necessarily wrong other than the sensor itself. However, since the sensor malfunctions, owners can’t know if the pressure is actually bad or if oil levels are normal. This is…
There is a known issue with these vehicles where the Oil Pressure Sensor/Switch triggers at idle and low RPMs but nothing is necessarily wrong other than the sensor itself. However, since the sensor malfunctions, owners can’t know if the pressure is actually bad or if oil levels are normal. This is a safety concern for all owners. However, Genesis is requiring owners to pay around $3000 to repair this. Most of the models are 2017-2019, which are past its manufacturer warranty years.
- Air bags
I hit a grass wall after striking a deer who bent my control arm and all airbags DEPLOYED BUT THE ONE WHO SAVES THE DRIVER THE MOST IMPORTANT AIRBAG
- Air bags · Electrical system · Steering
1-THE steering wheel airbag failed to deploy during a collisiom while all other airbags `airbags including rear seat airbags -did deploy. this suggest a possible malfunction in the airbag control module steering wheel airbag unit or sensor system. **yes the vechcle IS available for inspection…
1-THE steering wheel airbag failed to deploy during a collisiom while all other airbags `airbags including rear seat airbags -did deploy. this suggest a possible malfunction in the airbag control module steering wheel airbag unit or sensor system. **yes the vechcle IS available for inspection by genesis, nhtsa, or any authorized party. 2. As the driver I was at direct risk the steering wheel airbag IS designed to protect the head and chest in a frontal collision. Its failure to deploy left me vulnerable to impact with the steering wheel and dashboard. the lack of deployment has worsed the outcome 3. Not yet I am seeking a diagnostic scan from genesis - certified dealer to confirm the failure and identify any fault codes in the airbag system. 4. The vehicle IS being assigned to an ajuster but not yet by genesis or nhtsa. I am requesting a formal inspection by genesis and will provide access to the vehicle. 5. There was no warning lights or messages prior to the incident. 6. I was navigating a turn when a deer entered the roadway I swerved and the front right wheel became struck causing me to strike an embankment. The control arm broke and the impact triggered full airbag deployment including rear seat airbags but not the steering wheel airbag based on the severity and location of the impact, the steering wheel airbag should have deployed. I believe this failure may be due to a sensor malfunction or defect in the airbag system. This raises concerns regarding the reliability of the vehicle’s safety mechanisms, as the absence of steering wheel airbag deployment during such a significant frontal impact posed a serious risk to driver safety.
- Electrical system
A/C does not work as blower will not put out cold air. During hot days in Florida with children and elderly in the car this poses a risk to our health. This happens when A/C has been on for approximately one hour. No warning messages whatsoever. This has been reported by many Genesis G80 owners who own a G80 from the years 2017 - 2020. Genesis Corporate is aware of the problem but has not submitted a recall.
- Power train
Oil pressure sensor issues.
- Engine · Power train · Unknown or other
Component: Engine / Turbocharger / Oil Line / Fire Risk Vehicle Problem: For the past five months, my oil light has been coming on and off sporadically (not flickering), even though mechanics and oil shops said there was no issue. A few days ago, the car started smoking out of nowhere, though it…
Component: Engine / Turbocharger / Oil Line / Fire Risk Vehicle Problem: For the past five months, my oil light has been coming on and off sporadically (not flickering), even though mechanics and oil shops said there was no issue. A few days ago, the car started smoking out of nowhere, though it wasn’t overheating and there were no visible signs of leakage. I took it to the shop, and they diagnosed a turbocharger oil supply pipe leak that is severe and poses a fire risk. I am in a new city with no support system and have a baby. Multiple car dealerships have refused to fix my vehicle, even though I have been informed this part is under recall. I have tried calling and visiting, and no one will help. This is a safety concern, especially since the vehicle is at risk of catching fire while driving.
- Electrical system · Unknown or other
Rear left door lock actuator has failed. Door will not open from inside or outside. There is no emergency release of any kind. This is a major safety concern as in the event of an accident occupants could be stuck inside the vehicle. This is a known issue with this model as well as several Hyundai/Kia models
- Engine · Forward collision avoidance › Warnings
Engine while driving inadvertently stalls and vehicle shuts off. Does not matter what the conditions are. Have to place vehicle back in park and completely shut down vehicle to restart. It first starts by engine slowing down and then engine speeding up and ultimately stopping. When placed in park vehicle lungs forward slightly and front sensor tends to go off in warning without a vehicle in front of
- Unknown or other
My 2018 Genesis G80 has an issue in which the A/C quits working and blows warm air on the driver's side. I live in Florida where the heat is stifling and having warm air blowing during the high temperatures is dangerous. I have contacted Genesis who sent me a $220 Gift Card to have the dealer…
My 2018 Genesis G80 has an issue in which the A/C quits working and blows warm air on the driver's side. I live in Florida where the heat is stifling and having warm air blowing during the high temperatures is dangerous. I have contacted Genesis who sent me a $220 Gift Card to have the dealer diagnose the problem. The dealer stated that this is a very common problem that Genesis will not acknowledge. My car only has 28,385 miles on it and is stored in a garage most of the time. I was told it needs a new evaporator coil which will cost $3,000. I am [XXX] and my husband is dealing with [XXX] I joined the Genesis G80 online forum and found that I am one of MANY people suffering with this problem. As the temperatures have already started to rise in Florida, I was struggling today as I drove to visit my husband in the hospital. I cannot go on much longer like this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system
Reverse lights no longer illuminate when placing car into reverse. This is a safety issue as cars behind me are not made aware if I am wanting to reverse until they see the car in motion.
- Electrical system
Air conditioner freezes up and blows hot air in very hot weather. Causes dangerous driving environment.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by…
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009768Certain GV70 (JK1, JK1A), GV80 (JX1) and G80 (RG3) vehicles may have a hum or whine noise condition from the rear differential at certain speeds. This bulletin describes the procedure to inspect the vehicle for the hum or whine noise and if necessary to tighten the rear differential lock nut first. If the hum or whine noise remains, then replace the rear differential or other driveline components as necessary.
- 11006825This bulletin provides information to inspect and replace the front or rear wheel bearing hub assemblies for all Genesis vehicles. This procedure is applicable when noise (whirring, roaring, grinding, rumbling, etc.) is present which gets louder when driving with more speed.
- 10253275This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.
- 10253049Genesis applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10253044This bulletin provides the procedure to repair the panoramic sunroof creaking noise originating from the panoramic moving glass assembly. Applicable
- 10253030Some vehicles may experience seat noise from seat bottom when vehicle is turning. This bulletin describes the procedure to install an e-ring clip to the tilt pipe housing on the front seat.
- 10253027If you are servicing a vehicle with a transmission slipping concern, follow the Service Procedure shown below and perform a stall test. This TSB provides a procedure to test each clutch in the transmission. If the vehicle fails the stall test, replace the transmission. PASS: Stall speed is between 1700~2900 rpm (See shop manual for stall speed). FAIL: Engine revs to redline limit (6,000~6,500 rpm). If so, replace the transmission.
- 10238378Certain 2017-2020MY G80 vehicles may exceed evaporative emissions standards due to Onboard Refueling Vapor Recovery (ORVR) system. To correct this symptom, install an auxiliary canister assembly between the canister and Canister Close Valve (CCV).
- 10238375Certain 17-18MY Genesis G80 (DH) vehicles may exceed evaporative emissions standards due to Onboard Refueling Vapor Recovery (ORVR) system. To correct this symptom, an auxiliary canister assembly between the canister and Canister Close Valve (CCV) will be installed.
- 10235568Certain 2017-2020MY G80 vehicles may exceed evaporative emissions standards due to Onboarding Refueling Vapor Recovery (ORVR) system. To correct this symptom, install an auxiliary canister assembly between the canister and Canister Close Valve (CCV).
- 10235567Certain 2017-2020MY G80 vehicles may exceed evaporative emissions standards due to Onboard Refueling Vapor Recovery (ORVR) system. To correct this symptom, install an auxiliary canister assembly between the canister and Canister Close Valve (CCV).
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10230903This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly.
- 10206362When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) information is not available. This bulletin describes the 3-part Software to correct this condition and activate Genesis Connected Services (GCS).
- 10206361When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) information is not available. This bulletin describes the 3-part Software to correct this condition and activate Genesis Connected Services (GCS).
- 10203273Certain G80 and G90 Genesis vehicles may experience DTC code P0597 for Thermostat Heater Control Circuit/Open. This bulletin provides information on replacing the electric thermostat. No drivability issues are associated with this condition.
- 10202186This bulletin describes the procedure to variant code the Genesis Sedan (DH) navigation system. A black/blank screen or black and white image may be displayed from the rear view camera after the navigation unit is replaced without performing this variant coding procedure.
- 10202185When servicing a vehicle with a Check Engine light and any of the DTCs listed below, follow the Service Procedure to replace the related solenoid and E-module or park position switch.
- 10200079This TSB provides consolidated diagnosis and repair information, currently in the shop manual, to address DTC U0109 / U010900 related to a communication error with the Fuel Pump Control Module (FPCM).
- 10191796Certain G80 and G90 Genesis vehicles may experience DTC code P0597 for Thermostat Heater Control Circuit/Open. This bulletin provides information on replacing the electric thermostat. No drivability issues are associated with this condition.
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190042This bulletin provides best practice recommendations when performing brake service procedures.
- 10190040This TSB describes the procedure to update the TCU to revise the diagnosis logic for OBD communication test.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10183961This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10183956Certain G80 and G90 Genesis vehicles may experience DTC code P0597 for Thermostat Heater Control Circuit/Open. This bulletin provides information on replacing the electric thermostat. No drivability issues are associated with this condition.
- 10182301This bulletin provides repair information on certain 18MY G80 (DH) vehicles equipped with a 4-bolt steering gear assembly. If a vehicle exhibits a center biased steering feel, and no DTC(s) are active in the steering system, it is recommended to replace the rack-mounted motor driven power steering (R-MDPS) assembly using the updated part numbers shown below:
- 10180991The bulletin describes the procedure to measure and set propeller shaft angles to optimize driveline vibration performance on certain 2017-2018MY 3.8L AWD G80 (DH) vehicles.
- 10180988This bulletin provides information on wheel cleaning procedure and cleaning agent recommendations.
- 10178175This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes, or during normal driving operation.
- 10176182This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
- 10176181The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
- 10176178This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
- 10174807The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
- 10174801Certain Genesis G80 and G90 vehicles may experience the Shift By Wire (SBW) system slipping into Neutral when shifting from Reverse to Drive or Drive to Reverse. Replace the electronic shifter with a new shifter that has a production date of 6/2/17 or newer to resolve this condition.
- 10173551Some vehicles may experience seat noise and/or possible wobble movement from the seat bottom when the vehicle is turning. This bulletin describes the procedure to install an e-ring clip to the tilt pipe housing on the front seat.
- 10173546This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
- 10173545This bulletin describes the mandatory procedure to submit battery test data electronically for battery warranty claims by running the GDS Battery Claim App. The App must be run right after an incident battery is removed from the vehicle or after a battery charge is completed which qualifies for a warranty. It must be run at any time between RO open and close dates.
- 10172230Certain 2017-2018 G80 (DH) vehicles may have a condition where the seat backboard comes loose. This bulletin describes the procedure to replace the seat backboard clip.
Every Genesis G80 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.