2017 Harley-Davidson Flrt

Recalls

1 recall names the 2017 Harley-Davidson Flrt. Newest first.

• Power train › Clutch assembly

  Oct 18, 2018NHTSA 18V734000177,636 vehicles

  Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2017-2018 Police Road King (FLHP), Road King (FLHR), Road King Special (FLHRXS), Electra Glide Ultra Classic (FLHTCU), Ultra Limited (FLHTK), Ultra Limited Low (FLHTKL), Ultra Limited Shrine (FLHTK SHRINE), Police Electra Glide (FLHTP), Street Glide (FLHX), Street Glide Special (FLHXS)…

  Risk and remedy

  Risk

  If the clutch cannot be disengaged it can result in a loss of control, increasing the risk of a crash.

  Remedy

  Harley-Davidson will notify owners, and dealers will install a new secondary clutch actuator piston assembly, free of charge. The recall began November 5, 2018. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0173.

  Full recall details →

Owner complaints

Latest complaints

• Feb 22, 2019AZ
  Power train › Clutch assembly

  2017 harley davidson freewheeler. Consumer writes in regards to hydraulic clutch system safety recall. *Ld *tr

• Jun 27, 2018KY1,200 mi
  Power train
  The vehicle had approx 1200 miles on odometer. I took it to dealer for 1K mile service. They called back and advised me of a problem, I asked what kind, they advised teeth missing off of drive belt, I asked how many , they replied more than 20.. I had previously noticed slight jerking when…

  The vehicle had approx 1200 miles on odometer. I took it to dealer for 1K mile service. They called back and advised me of a problem, I asked what kind, they advised teeth missing off of drive belt, I asked how many , they replied more than 20.. I had previously noticed slight jerking when releasing clutch and getting underway, but blamed it on operator error.. The amount of teeth missing could have led to a catastrophic loss of power. Don't know if the drive belt was defective, it IS being replaced under warranty. Possible cause could be related to the rear pulley. Upon examination it showed signs of extreme wear for 1200 miles, including gouges on the tip of every tooth across the entire width of pulley. Also noticed there was deformation and redistribution of the metal teeth resulting in some sharp edges being created. The front (transmission) pulley did not seem to be affected, but due to it's smaller size the large section of missing teeth would be enough to encircle it, which could have led to a possible loss of power.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11008736SERVICE BULLETIN M1555 (REV E): BATTERY WARRANTY GUIDELINES. PURPOSE: Revision E. Added: Added procedures for the DCA-8000 E Battery Tester.* Updated: All sections. This bulletin informs the dealership network that Harley-Davidson has provided guidelines for battery warranty.
• 11007544SERVICE BULLETIN M1490 (V 24.8.8): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). Version 24.8.8. Release Date: Week of August 5, 2024. New Features for Harley-Davidson vehicles: Advanced Module Replace for 2021 and later Revolution Max; 2023 and later CVO Touring; and 2024 Street Glide (FLHX), Road Glide (FLTRX). New Features for LiveWire vehicles: Updated calibrations for 2024 S2DM EV1/ EV6; 2024 S2MH EV1; and 2024 S2DM, S2MH. Changes: Added Hand Control Module (HCM) (Part No. 71500522A and 71500536A) for reflash support.
• 11005514GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1158: OIL FILTER PACKAGING AND CASE QUANTITY UPDATE. PURPOSE: To inform dealerships that Harley-Davidson has made updates to oil filters including new part numbers, packaging design, and bulk case quantity changes.
• 11001293SERVICE BULLETIN M1490 (V 24.6.4): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: Revision. This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). Version 24.6.4. Release Date: Week of May 1, 2024. New Features for LiveWire S2DM and S2MH, 2024 Revolution Max, and 2024 Touring.
• 10254115SERVICE BULLETIN M1612 (REV A): MILWAUKEE-EIGHT AND TWIN CAM TRANSMISSION GEAR PACKS. Purpose: Revision. Update: Notes for Table 3 and 4. * Updated: Part Numbers. This bulletin informs dealers that all: Twin Cam gear packs on CVO, Dyna, Police, Softail, Touring & Trike models and Milwaukee-Eight gear packs on CVO, Police, Softail, Touring & Trike models ordered after December 04, 2023 will not come with the shift drum, forks, shafts and related hardware. Models Affected: 2006-2017 Twin Cams: Dyna models 2007-2016 Twin Cams: CVO, Police, Touring and Trike models 2007-2017 Twin Cams: Softail models 2017-2024 Milwaukee-Eight: CVO, Police, Touring and Trike models 2018-2024 Milwaukee-Eight: Softail models
• 10248401GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1146: 68193-95 BULB WEDGE, FENDER TIP LAMP. Purpose: To inform dealers of an issue with the bulb wire terminals not being to specification. The light bulbs were used in numerous front and rear fender tip light assemblies for domestic and international applications.
• 10248400GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1144: 2021-2022 SCREAMIN' EAGLE STAGE I (CARB) EO APPROVALS. PURPOSE: Revision. To inform California dealers about the new California Air Resources Board (CARB) approvals for select 2021-2022 Harley-Davidson vehicles. Summary: Various Screamin' Eagle Air Cleaner Kits and Stage I calibrations have been approved for sale on select 2021 and 2022 Harley-Davidson models. Please see the table below that indicates which part numbers should be ordered for what models. Revision: Refer to Summary. Update non-Bluetooth calibrations availability.
• 10248398SERVICE BULLETIN M1612: MILWAUKEE-EIGHT AND TWIN CAM TRANSMISSION GEAR PACKS. Purpose: This bulletin informs dealers that all: Twin Cam gear packs on CVO, Dyna, Police, Softail, Touring & Trike models and Milwaukee-Eight gear packs on CVO, Police, Softail, Touring & Trike models ordered after December 04, 2023 will not come with the shift drum, forks, shafts and related hardware. Note: Resubmission is a correction to Selected Products Section of Transaction ID 24MC44619, NHTSA ID 10248397. Models Affected by M1612 to include only: 2006-2017 Twin Cams: Dyna models 2007-2016 Twin Cams: CVO, Police, Touring and Trike models 2007-2017 Twin Cams: Softail models 2017-2024 Milwaukee-Eight: CVO, Police, Touring and Trike models 2018-2024 Milwaukee-Eight: Softail models
• 10248397SERVICE BULLETIN M1612: MILWAUKEE-EIGHT AND TWIN CAM TRANSMISSION GEAR PACKS. Purpose: This bulletin informs dealers that all: Twin Cam gear packs on CVO, Dyna, Police, Softail, Touring & Trike models and Milwaukee-Eight gear packs on CVO, Police, Softail, Touring & Trike models ordered after December 04, 2023 will not come with the shift drum, forks, shafts and related hardware.
• 10245706GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1144: 2021-2022 SCREAMIN' EAGLE STAGE I (CARB) EO APPROVALS. PURPOSE: To inform California dealers about the new California Air Resources Board (CARB) approvals for select 2021-2022 Harley-Davidson vehicles. Summary: Various Screamin' Eagle Air Cleaner Kits and Stage I calibrations have been approved for sale on select 2021 and 2022 Harley-Davidson models. Please see the table that indicates which part numbers should be ordered for what models.
• 10244933GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1143: SCREAMIN EAGLE CARB APPROVALS. PURPOSE: To inform California dealers about the new California Air Resources Board (CARB) approvals. Screamin' Eagle Quickshifter and Screamin' Eagle Extreme Flow 55mm Intake Manifold.
• 10244929SERVICE BULLETIN M1611: MILWAUKEE-EIGHT TRANSMISSION SHIFT DRUM UPDATE. PURPOSE: This bulletin informs dealers of a transmission shift drum running change to all variants of the Milwaukee-Eight powertrain. Starting on October 4, 2023 all Milwaukee-Eight CVO, Police, Softail, Touring and Trike models will be assembled using a common shift drum. The new shift drum (Part No. 33900265) is replacing the old shift drum (Part No. 33900172). The new shift drum was developed to include the "D" shaft on the end to interface with the Gear Position Sensor on 2023 CVO Street Glide (FLHXSE) and Road Glide (FLTRXSE). For all other Milwaukee-Eight models, the bearing door has been modified by adding a pocket to accept the "D" shaft of the new shift drum.
• 10242096SERVICE BULLETIN M1600: 2023 MILWAUKEE EIGHT OIL PAN FASTENER CHANGE. PURPOSE: This bulletin informs dealers that there is a running change for the oil pan fastener on all Milwaukee-Eight powered Softail and Touring models. As of Monday July 31, 2023, Powertrain Operations (PTO) in Menomonee Falls, WI is building all Milwaukee-Eight Softail and Touring powertrain models with new oil pan fasteners (Part No. 12600369). The old fasteners (Part No. 4741A) will still remain available for dealer purchase. The oil pans for the Softail and Touring models were updated to accept the new fastener geometry. Their Part Numbers have been superseded to (-A). Touring will be (Part No. 24400180A) and Softail will be (Part No. 24400208A). The new fastener will not fit with an old oil pan but the old hardware will still be available for dealer purchase. The old fastener CAN be used with a new (-A) oil pans. The fastener torque has not been changed.
• 10235272SERVICE BULLETIN M1586: SCREAMIN' EAGLE OIL PUMP INCORRECTLY MACHINED. PURPOSE: This bulletin informs dealers that Harley-Davidson has found a quality issue with the Screamin' Eagle Oil Pump and how to check inventory for this condition. Markets Affected: Worldwide
• 10228742SERVICE BULLETIN M1507: LOW/NO CHARGING DIAGNOSTICS. Revision. PURPOSE: To inform the dealers of updated and new symptom-based diagnostics for the low or no charging symptom. Motorcycles Affected: 2017-2023 Touring and Trike platform; 2018-2023 Softail platform. Required Dealer Action: Use the new diagnostics on all affected platforms. View current electronic version of the Electrical Diagnostic Manual (EDM) at https://serviceinfo.harley-davidson.com.
• 10210129SERVICE BULLETIN M1507: LOW/NO CHARGING DIAGNOSTICS. Revision. PURPOSE: To inform the dealers of updated and new symptom-based diagnostics for the low or no charging symptom on affected platforms. Required Dealer Action: Use the new diagnostics on all affected platforms. Replace the LOW OR NO CHARGING symptom based diagnostic in the electrical diagnostic manual with the updated and new sections.
• 10195169Harley-Davidson is aware of conditions that may result in a streaking appearance or film residue on the inside of some instrument gauges including speedometer and tachometers. This may occur after exposure of the vehicle to humid conditions. This condition may remain even after the moisture has evaporated.
• 10193488Harley-Davidson is aware of conditions that may result in a streaking appearance or film residue on the inside of some instrument gauges including speedometer and tachometers. This may occur after exposure of the vehicle to humid conditions. This condition may remain even after the moisture has evaporated.
• 10180723GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1105: SCREAMIN' EAGLE CALIBRATIONS & SMART TUNE UPDATES. PURPOSE: To inform dealers, that new Screamin Eagle calibrations are now available for 49 State application. These calibrations are for the launched Touring (119/122 ci) Stage III Kits and Softail (128/131ci) Stage IV Kits/Crate. Smart Tune software program enhancements within latest software release. Screamin' Eagle Smart Tune software program has been enhanced to allow for more advanced data acquisition over a broader range.
• 10180722GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1103: SCREAMIN' EAGLE - NEW STAGE KIT CALIBRATION AVAILABILITY. PURPOSE: Revision. To inform dealers of Screamin Eagle calibrations delayed availability. This delay covers the new Touring (119/122 ci) Stage III Kits and Softail (128/131 ci) Stage IV Kits/Crate. The Screamin Eagle team expects to have all necessary 49-State calibrations by September 14, 2020.
• 10180720SERVICE BULLETIN M1450: MILWAUKEE-EIGHT EQUIPPED VEHICLES - LOSS OF POWER OR HIGH ENGINE BRAKING. PURPOSE: Revision. 2017 - 2019 model motorcycles equipped with a Milwaukee-Eight engine can experience a condition known as sumping during extended periods at high rpm or under heavy engine load. This bulletin provides the diagnostic procedure for determining if sumping is occurring.
• 10179456GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1104: HIGH-FLOW EXHAUST SYSTEM FITMENT UPDATE. PURPOSE: To inform dealers of Screamin Eagle Touring High-Flow Exhaust System is now a 49-State compliant fitment for the 128/131 ci Stage IV Kit and 131ci Crate Engine. This exhaust system was designed in parallel with the 131 ci Crate engine for optimal performance while maintaining legal on-road use.
• 10179451GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1103: SCREAMIN' EAGLE - NEW STAGE KIT CALIBRATION AVAILABILITY. PURPOSE: To inform dealers of Screamin Eagle calibrations delayed availability. This delay covers the new Touring (119/122 ci) Stage III Kits and Softail (128/131 ci) Stage IV Kits/Crate. The Screamin Eagle team expects to have all necessary 49-State calibrations by September 07, 2020.
• 10179447GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1104: HIGH-FLOW EXHAUST SYSTEM FITMENT UPDATE. PURPOSE: To inform dealers of Screamin Eagle Touring High-Flow Exhaust System is now a 49-State compliant fitment for the 128/131 ci Stage IV Kit and 131ci Crate Engine. This exhaust system was designed in parallel with the 131 ci Crate engine for optimal performance while maintaining legal on-road use.
• 10178101SERVICE BULLETIN M1464: BOOM! AUDIO - GENERAL INFORMATION AND SOFTWARE UPDATE 1.22.X. PURPOSE: Revision. This bulletin helps the dealer locate needed information to update and service Boom! Box Audio Infotainment systems. It also lists software revisions and the fixes addressed in each revision. This bulletin also replaces the following documents: TT431A: Software Download and Warranty Information, M1346: Boom! Box Audio System Software Update, M1344E: Boom! Box Infotainment System General Information and Procedures, M1442: Box Infotainment System General Information and Software Release 1.21.X Description, and The Boom! Box Infotainment System Job Aid located on h-dnet.com
• 10177089SERVICE BULLETIN M1517: MILWAUKEE-EIGHT ENGINE - CRANKSHAFT POSITION SENSOR. PURPOSE: To notify dealers of a Crankshaft Position (CKP) Sensor change for 2017-2020 vehicles equipped with a Milwaukee-Eight (MKE-8) powertrain.
• 10176175GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1097 INTERNATIONAL FITMENT: THE BOOM! BOX GTS SOFTWARE UPDATE. PURPOSE: To notify International dealers that International GTS radios are now available to be ordered and installed in 2014-2018 Touring, CVO Touring and Trike models previously equipped with 6.5 GT radios as retrofittable with additional parts and software as noted. Markets Affected: Only international markets are affected.
• 10173477SERVICE BULLETIN M1510: MILWAUKEE-EIGHT ENGINE - NEW OIL FILTER. REVISION. PURPOSE: To inform dealers of an improved oil filter for the Milwaukee-Eight (MKE-8) engine. The new oil filter uses the same synthetic 5-micron media as the current filter, however, the new oil filter effective media surface area was increased by 25%. The increased media supports the higher oil flow rate of MKE-8 engines. Fitment, clearance and performance testing has only been performed on MKE-8 vehicles. All Twin Cam vehicles continue to use the current oil filter.
• 10173463SERVICE BULLETIN M1510: MILWAUKEE-EIGHT ENGINE - NEW OIL FILTER. REVISION. PURPOSE: To inform dealers of an improved oil filter for the Milwaukee-Eight (MKE-8) engine. The new oil filter uses the same synthetic 5-micron media as the current filter, however, the new oil filter effective media surface area was increased by 25%. The increased media supports the higher oil flow rate of MKE-8 engines. Fitment, clearance and performance testing has only been performed on MKE-8 vehicles. All Twin Cam vehicles continue to use the current oil filter.
• 10172226SERVICE BULLETIN M1508: 2009-2020 TRIKE PLATFORM - REVERSE MOTOR. PURPOSE: To inform dealers of a running change for the new reverse motor (Part No. 83388-09C) for Trike models. As of January 28, 2020 all Trike platform vehicles will be manufactured using the new reverse motor. The new reverse motor will be used to replace reverse motor assemblies (Part No. 83388-09, 83388-09A,83388-09B) that have failed diagnostics. Refer to Table 2. This motor contains several improvements for better motor durability.
• 10162967SERVICE BULLETIN M1492: 2017 - 2019 TOURING - MILWAUKEE EIGHT - INNER PRIMARY VENT. Purpose: Revision. Harley-Davidson has learned that a small percentage of dealers and customers are finding low transmission oil levels and high primary oil levels during normal maintenance intervals. This could indicate that oil is transferring from the transmission case to the primary housing through the transmission mainshaft. A inner primary vent service kit (Part No. 26500027) is now available to address this issue. The kit allows the primary to breath and prevents excessive pressure. All markets are affected.
• 10155120SERVICE BULLETIN M1359: 2014 - 2016 TOURING - HYDRAULIC CLUTCH LINE REPLACEMENT. PURPOSE: REVISION. A leak may occur on some Touring, CVO Touring, Police Touring and Trike models equipped with hydraulic clutch. The leak may occur when the line is replaced or when a P&A clutch line is installed. The area of the leak is at the joint where the clutch line attaches to the secondary clutch actuator (right side of the transmission). Required Dealer Action: Use Snap-on Flare Nut Socket (Part No. GAN85087B) and Snap-on Torque Wrench (Part No. QJR117F or similar) to tighten flare nut. Each time clutch line is installed or torque is adjusted to determine if leak is still present, bleed the clutch system.
• 10139400SERVICE BULLETIN M1463: MILWAUKEE-EIGHT - ROCKER COVER GASKET INVENTORY PURGE AND REPLACE. Purpose: To inform dealers that previous rocker cover gasket design on Milwaukee-Eight? are prone to varying degrees of oil leaks. These leaks may occur on certain vehicles with different combinations of painted, polished and chrome parts. Purge inventory of old gaskets and replace with new gasket which has enhanced sealing features.
• 10139399TECH ARTICLE TA0023: TA0023: Crankshaft Rod Bearing. Purpose: Technicians have been falsely identifying connecting rod bearings as failed due to a perception of resistance as the rods are rotated. The clearance of the Twin Cam and Milwaukee-Eight crank pin bearings are maintained to a very tight range. This optimizes performance and maintains low mechanical noise in operation. The connecting rod bore can also distort slightly in operation due to stress relaxation. As a result, bearing clearance decreases due to the contact zone broadening and the load being distributed over more rollers. The combination of a bore being slightly out of round and reduced bearing clearance can result in varying degrees of resistance through the range of motion. Axial clearance is also tightly controlled for proper alignment. For these reasons, zones of resistance can be found when the connecting rods are rotated by hand through their range of motion. Resistance during rod motion, by itself, is not an indication of a performance or durability concern.
• 10125156Service Bulletin M1430B: BOOM! BOX INFOTAINMENT SYSTEM GENERAL INFORMATION AND SOFTWARE RELEASE 1.20.X DESCRIPTION informs the dealer network that Boom! software version 1.20.3 released December 19, 2016 and is now available to download. This also provides notice that revision 1.20.2 was found to be corrupt. Do not install version 1.20.2 and delete any stored copies.
• 10125153SERVICE BULLETIN M1450: MILWAUKEE-EIGHT EQUIPPED VEHICLES - LOSS OF POWER OR HIGH ENGINE BRAKING. Purpose: 2017 and 2018 model motorcycles equipped with a Milwaukee-Eight engine can experience a condition known as sumping during extended periods at high rpm or under heavy engine load. This bulletin provides the diagnostic procedure for determining if sumping is occurring.
• 10125141SERVICE BULLETIN M1442: BOOM! BOX INFOTAINMENT SYSTEM GENERAL INFORMATION AND SOFTWARE RELEASE 1.21.X DESCRIPTION. This bulletin helps the dealer locate needed information to update and service Boom! Box Audio Infotainment systems. It also lists software revisions and the fixes addressed in each revision.
• 10124218SERVICE BULLETIN M1458: 2009 - 2018 TRIKE - SERVICE MANUAL SUPPLEMENT UPDATE. The purpose of this bulletin is to communicate updates to thereverse motor inoperative diagnostic procedure in the service manual supplement. A high percentage of reverse motors that have been returned are in good condition. The belief is that the 150 A circuit breaker is tripped, and not fully reset. This is causing the technician to replace good parts that they believe are faulty.

Every Harley-Davidson Flrt model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.