2005 Hino Conventional Ldt W/ JO5E

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 101848632005-07 Conventional Light Duty Truck (LDT) with a J05E engine. During engine performance diagnostics, comparative readings from a like engine can be useful data points from a known good engine to use for comparisons (refer data in PDF documents).
• 10183803This document is to inform dealers and workshops of the correction to Workshop Manuals for J08 engines listed below.
• 10182793New Product Offering ? DAVCO Diesel Pro Fuel Filter Retrofit Kits
• 10182787ECU File Downloading, Reprogramming and INF File Uploading via HinoNet
• 10182785Davco fuel filter change and priming procedure
• 10182775The document is to inform the dealers of the release of Hino Diagnostic eXplorer (HINO DX) Ver. 1.2.0 as described below.
• 10182759Lock Assembly Kit (Keyed Alike)
• 10182755Rear Axle gear ratio change or change in tire size
• 10182740The ECM receives a brake light signal, which deactivates the accelerator pedal
• 10182739ABS warning light is on. Code 3-1 thru 3-4.
• 10182681Cut Key Ordering Process
• 10182677This document is to inform dealers of the correction to Worshop Manuals for the J08E engines.
• 10182676This document is to inform of the procedure to calibrate the Pulse Adjust Module when needed (ex. tire size change, rear carrier ratio change) .
• 10182675Remanufactured Alternators and Starters for Conventional Trucks
• 10182674HINO genuine oil filter replacement is recommended at 6000-20000 miles depending on duty cycle and type of oil used
• 10182669Fuel diluting engine oil
• 10182648Restricted fuel system causing low power. 1. Fuel lines plugged or restricted 2. Fuel filter plugged
• 10182647Chassis experienced premature brake failure after a brake job was performed which included brake caliper replacement.
• 10182646No throttle response on 2007 air brake chassis with automatic transmissions when selector placed in drive. No cruise control on 2007 air brake chassis with manual transmissions.
• 10182644Running out of fuel, dual tanks not equalizing
• 10167193This design change of the idler gear case and idler gear bolt is to address the idler gear bolt loosening under abnormal loading from fuel supply pump and the gear train. The redesigned idler gear case and idler gear bolt are designed to increase their robustness and prevent the idler gear bolt from loosening.
• 10144321Cab over engine (coe) ecu, dcu and vcs software update
• 10118115TT-15-024 During engine performance diagnostics, comparative readings from a like engine can be useful. Below are data points from a known good engine to use for comparisons.
• 10118109TT-15-016 The purpose of this publication is to communicate the standard measuring positions on the Hino chassis. In some cases, the customer may report a visual chassis posture concern where the chassis appears to be leaning more towards the driver side or passenger side. The following publication can be referenced to obtain the manufacture?s measurement positions and specifications. Should the truck not meet the specifications, you should consider the following potential causes noted in the inspection guideline section below.
• 1011810706 - 012 speedometer pulse adapter conversion form
• 1011810607 - 008 dx report ? Exporting, saving and printing from past work information
• 1011810507 - 006 voltage drop test
• 1011810407 - 005 No Throttle Response (brake light switch)
• 1011810307 - 004 ABS Wheel Sensor (active fault 3-1 thru 3-4)
• 10118099SB-13-009 This bulletin is to inform dealers and workshops of proper paint codes for all Hino models. ALL MODELS
• 10117680SB-15-026 A subject vehicle may exhibit an engine oil leak or engine coolant leaking externally from the engine head gasket sealing area on the exhaust manifold side of the engine. An improved head gasket has been made available as a service part and should be used if replacement of the head gasket is necessary. Improvement of the head gasket includes the addition of rubber seals around the engine oil and engine coolant port holes.
• 10117666SB-15-009 This bulletin provides the corrective action for a fluid overflow condition from the main housing breather at startup in cold ambient temperatures at or below +5F (-15C).
• 10117655SB-14-003 The following is to inform you of the revision of the inspection procedure for the DTC?s P0340 and P0341. You are kindly requested to attach this service data to the relevant pages of the workshop manuals for maintenance and to use for servicing.
• 1011757406-011 high pressure fuel pump front seal failure
• 1011757306 - 010 LOW POWER (fuel restriction)
• 1011757106 - 008 ABS EXTENSION HARNESS No throttle response on 2007 air brake chassis with automatic transmissions when selector placed in drive. No cruise control on 2007 air brake chassis with manual transmissions.
• 1011756906-001 running out of fuel, dual tanks not equalizing
• 1011603013-008 Injection Pump Drive Case. Please note the following part number changes to the Injection Pump Bearing Case. Not replacing the correct replacement parts WILL result in major engine damage. The Hino Ordering system has been modified to make the below changes into a kit that consist of the correct parts when ordering the kit ID number. The below information illustrates the kit components per engine and date ranges.
• 10116027PTB 08-08 2005-2008 Quick Reference Guide Correction to Page 60
• 10116025PTB 01-08 Complete Engine Assembly Part Numbers

Every Hino Conventional Ldt W/ JO5E model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.