2017 Hyundai Sonata Plug-In Hybrid
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Sonata Plug-In Hybrid › 2017
These records cover every 2017 Hyundai Sonata Plug-In Hybrid. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2017 Hyundai Sonata Plug-In Hybrid. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.
Risk and remedy
Risk
A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.
Remedy
Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Hyundai Sonata Plug-In Hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.
Risk and remedy
Risk
If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will remove the VPD switch and install a new Battery Management System (BMS) that contains an Overvoltage Protection Device (OPD). The recall is expected to begin May 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 175.
Owner complaints
32 complaints
What owners report most
Latest complaints
- Electrical system
On 12/20/25, the car - a Sonata plug-in hybrid - failed to start. When I pushed the "start" button, the dashboard display lit up w many clearly irrelevant error messages. Each time I pressed start, somewhat fewer error messages blasted toward me, and finally, no response at all. On 12/21/2026, the…
On 12/20/25, the car - a Sonata plug-in hybrid - failed to start. When I pushed the "start" button, the dashboard display lit up w many clearly irrelevant error messages. Each time I pressed start, somewhat fewer error messages blasted toward me, and finally, no response at all. On 12/21/2026, the tow driver said it was the 12-volt battery. He gave us a jump start and we drove a few blocks. However, it failed at the turn lane while waiting for the light to turn. We turned it back on, bought a new battery, had it installed. On 12/29/25, my husband was driving. He turned into the intersection with a traffic light. As he was making the turn, the car simply quit. No warning. The car was dead, and blocking traffic! He pressed the start button to turn off the car, then again to turn it on. He was able to complete the turn and parked on the side of the road. By this time it had a "check engine" light on. He then drove slowly the few blocks back to our house. On 12/30/2025, the car was towed to a local mechanic. He said it threw the code PODE7, "almost certainly for a failed High Voltage battery." It was still under warranty, and we had the car towed to the dealership. After keeping it for 2 or 3 weeks, they confirmed the code and that the control panel needed to be replaced. We finally picked up the car (w new control panel) on 2/20/2026. In the meanwhile, we looked up Hyundai control panel repairs on a reddit forum. We found lots of chatter about it. Turns out it's a recognized problem in Sonata and Ioniq EV and PHEV's! Clearly, a car failing in the middle of an intersection, highway, etc is a safety problem and needs to have repair/replacements made BEFORE THEY HAPPEN!
- Engine · Unknown or other
I am reporting a serious safety issue involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ), originally purchased in California. While driving at approximately 70 mph on a highway, the vehicle suddenly lost all propulsion without warning and rapidly decelerated. This created a dangerous…
I am reporting a serious safety issue involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ), originally purchased in California. While driving at approximately 70 mph on a highway, the vehicle suddenly lost all propulsion without warning and rapidly decelerated. This created a dangerous situation with surrounding traffic and put me and my family at risk. I had to quickly maneuver to the shoulder to avoid a potential collision. The vehicle was towed to an authorized Hyundai dealership in Utah, where it was diagnosed with a failure of the high-voltage battery system. I was informed that the battery requires replacement. This type of sudden loss of propulsion at highway speed is extremely hazardous and could result in a crash, injury, or fatality. There were no prior warnings indicating an imminent failure of this severity. Given the safety risk associated with unexpected loss of propulsion, I am concerned this may represent a broader issue affecting similar vehicles. The vehicle is equipped with an interior camera, and video of the incident can be provided if needed. I respectfully request that this issue be investigated as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Power train
To the National Highway Traffic Safety Administration, I am filing this formal safety complaint regarding a dangerous engine failure incident involving my 2017 Hyundai Sonata Plug-in Hybrid. Description of Incident: While traveling on CA-85 near Mountain View, California, at approximately 65…
To the National Highway Traffic Safety Administration, I am filing this formal safety complaint regarding a dangerous engine failure incident involving my 2017 Hyundai Sonata Plug-in Hybrid. Description of Incident: While traveling on CA-85 near Mountain View, California, at approximately 65 miles per hour, the engine suddenly and without warning lost all power. The vehicle began to slow down involuntarily in active highway traffic, creating an immediate and serious risk of rear-end collision. The driver had no ability to maintain safe highway speed or accelerate out of danger. The vehicle had to be towed from the scene to the dealership. There was no warning light or prior indication that engine failure was imminent. The failure was sudden, complete, and occurred at highway speed in heavy traffic conditions. Safety Risk to the Public: This incident represents a significant and ongoing public safety hazard. A sudden, unpredictable loss of engine power at highway speed — with no prior warning — places the driver, passengers, and surrounding vehicles at serious risk of collision. This is not an isolated mechanical inconvenience; it is a life-threatening failure mode. Known and Documented Defects: The 2017 Hyundai Sonata Plug-in Hybrid has been the subject of multiple recalls and class action litigation related to engine defects. My incident is consistent with the known failure patterns documented in those proceedings. Despite this history, Hyundai Motor America has denied my warranty claim, citing missed services — a characterization I dispute, as the vehicle was serviced exclusively at an authorized Hyundai dealership whenever the onboard system indicated service was due, and no technician ever identified or disclosed any engine damage during those visits. Request to NHTSA: I respectfully request that NHTSA: 1. Open or expand an investigation into engine failure incidents in the 2018 Hyundai Sonata Plug-in Hybrid 2. Investigate whether a recall is warranted
- Fuel/propulsion system
While driving car stuttered check engine light and check hybrid system flashed. Check engine lights stayed on until getting home. Next day. I scanned and code p0b68 was set.
- Electrical system · Engine · Fuel/propulsion system
While driving at a high rate of speed propulsion to the vehicle suddenly and without warning ceased, the electric and internal combustion engine were non-responsive (ICE stopped; hybrid motor didn't provide propulsion), the warning light said "Check Hybrid System. Turn off engine" I was put at…
While driving at a high rate of speed propulsion to the vehicle suddenly and without warning ceased, the electric and internal combustion engine were non-responsive (ICE stopped; hybrid motor didn't provide propulsion), the warning light said "Check Hybrid System. Turn off engine" I was put at risk because I was traveling at highway speed and was given no warning before the vehicle shut down. This has occurred nine times, I've reported all to Hyundai, they have had the car in the shop three times, the issue is not fixed. No, despite ODB2 error codes, the car has not shut down while a dealership is driving it. Yes, the vehicle has been inspected multiple times by Hyundai. Yes, always "Check Hybrid System. Turn off engine", in almost all cases the check engine light comes on after that, and in some cases additional lights such as "auto hold". This first occurred in Dec 2023, I was told the car was fixed (it wasn't) and happened again in October 2024. I haven't been able to drive my car since then.
- Electrical system · Power train
While driving the 2017 Hyundai Sonata Plug-In Hybrid, the car will begin to stall, a rapid number of audible beeps will start, the "Check Hybrid System" notification will pop up on the dashboard, and the "Check Engine Light" appears.. The car therefore cannot be driven anymore, and I am forced to…
While driving the 2017 Hyundai Sonata Plug-In Hybrid, the car will begin to stall, a rapid number of audible beeps will start, the "Check Hybrid System" notification will pop up on the dashboard, and the "Check Engine Light" appears.. The car therefore cannot be driven anymore, and I am forced to pull over to the side. In order to fix the issue temporarily, I need to turn the car off and turn it back on again. Once this is completed, both the "Check Hybrid System" and the "Check Engine Light" disappears and the car can be driven again. An OBD Scanner is unable to find exactly what is going on as the "Check Hybrid System" and the "Check Engine Light" no longer appear. This has happened 4 times now within the span of 3 months. The people at risk are me (the driver), my passengers, and potentially everyone else on the road in my nearby vicinity as the problem occurs. This problem has been confirmed by the dealer in their Hybrid vehicles. This vehicle has not been inspected yet but that is an ongoing process.
- Steering
I was driving the vehicle with 2 other occupants onboard on [XXX] towards US-101. The EPS warning light already came on after entering [XXX] from [XXX], but initially, I didn't think it was much of an issue. As I merged to the right lane in preparation of entering the highway, the steering began…
I was driving the vehicle with 2 other occupants onboard on [XXX] towards US-101. The EPS warning light already came on after entering [XXX] from [XXX], but initially, I didn't think it was much of an issue. As I merged to the right lane in preparation of entering the highway, the steering began to feel very stiff, so I immediately made a right turn into a local street when there was a little bit of steering left. As soon as I pulled over, the steering locked up completely, and both the EPS warning light and the dash display's lane-departure system warning were activated. Luckily no other vehicle or humans were endangered at the time. I put the car into park and powered it off. When I powered it back on again several minutes later, the issue resolved itself and I was able to continue driving with normal steering, and steering remained normal after several power on/off cycles which included both local and highway driving. Come to think of it, ~3 months before this incident happened, I already noticed occasional stuttering of the steering wheel and humming of the EPS assembly when the car is stationary or at low speed. I took the car to a third-party repair shop on the next day since the Hyundai dealership appointment is a week away at the earliest. They ran diagnosis before telling me that the steering sensor in the EPS motor assembly failed, and this happened very frequently for 2017 Sonata Plug-in hybrids. This happens so often, apparently, that Hyundai issued service bulletin [XXX], but this very much looks like a recall to me, as when the system fails, steering is lost completely, and could cause great harm to myself as well as the occupants onboard, not to mention other vehicles around me. I was lucky that it happened before I entered the highway and also had a place to pull over. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system · Engine · Fuel/propulsion system
Vehicle lost power in freeway. Complete power failure. Early crashed into. Vehicle coasted to off ramp and towed away.
- Unknown or other
About 3 weeks ago I had just left my house, battery fully charged and gas tank full. I was coming down a hill to a stop sign and started braking. Suddenly the car seemed to lose power and essentially stopped moving. There was an error on the dash saying "hybrid system failure". There was barely…
About 3 weeks ago I had just left my house, battery fully charged and gas tank full. I was coming down a hill to a stop sign and started braking. Suddenly the car seemed to lose power and essentially stopped moving. There was an error on the dash saying "hybrid system failure". There was barely able enough power to slowly pull the car over to the side of the road. I turned off the car and checked the battery in the trunk - I didn't see any obvious concerns. My husband got there 10 minutes later and we tried turning the car on again. It came on fine but there was an engine warning light. We were able to drive it without difficulty back to my house. I was unable to get a timely appointment at my local Hyundai dealer, so a couple days later My husband drove it to a local garage to see if they could figure out what the problem was. When he turned the car on again the engine light was no longer on. However, at the garage they were able to pull up a history of the car alerts and it confirmed that it said hybrid system failure. I have done some research online and it sounds like there was a recall on Hyundai sonatas hybrids for 2017 but I did not see a recall for the plug-in version of the hybrid. I searched online, however, and there were many other owners of Hyundai sonata plug-in hybrids that reported the same incident. I am hoping that a recall gets is issued for the plug-in hybrid as well so that more owners don't have the same problem. If I had been driving on the highway at 65 mph in a middle lane and my engine suddenly lost power it could have been fatal. Oh - one other recent problem I had that I'm not sure is related is that my car recently started losing electric miles very quickly. From the time it was purchased until a few months ago, it was losing plug-in miles at about 1 mi per year (i.e. each year a fully charged battery gave me 1 mile less). Then about 6 months ago it started losing electric miles very quickly - about 1/mo. Dealer said it was normal aging.
- Engine · Unknown or other
Occurrence: This has been a recurring issue for over a year (over a year, might be closer to two years now) for our PHEV Sonata. It has happened approximately 10 times. Problem: Total engine shutdown when driving the car. "Shut down engine" type error message pops up and cannot accelerate.…
Occurrence: This has been a recurring issue for over a year (over a year, might be closer to two years now) for our PHEV Sonata. It has happened approximately 10 times. Problem: Total engine shutdown when driving the car. "Shut down engine" type error message pops up and cannot accelerate. Steering still works, but it can be hard to pull over due to lack of engine power. The car can be restarted after shutting down, but must first come to a complete stop and into Park. Safety Issue: The car stops working. Obviously, this would be quite dangerous on a busy road, a highway, or if you were taking a left turn, etc. Confirmation: The dealer indicates that the hybrid battery is a problem and should be replaced. However, due to supply chain issues, we have been waiting for over a year for the replacement. **** Reproduction Steps: **** We have found that it is most likely to happen with a fully charged battery and a sudden braking action. I suspect the issue happens when trying to charge the battery but due to its condition, it shuts down instead. It tends to happen: 1) Full Charge: Battery is fully charged overnight or "topped up" to full charge 2) Sudden Braking: Having to brake hard, such as being cut off. We have found that adjusting charging and driving habits has reduced but not eliminated the issue. Suggestion: I would suspect that having some electrical component to prevent a sudden overcharge might eliminate this problem (shunting excess current or turning off regenerative braking for sudden stops). Warning Messages: A warning message is seen, but it happens at the same time the engine is shut down and disappears before you could take a picture of it (as you are busy trying to do an emergency pull over).
- Electrical system
My 2017 Hyundai hybrid PHEV vehicle stuttered and failed to accelerate when the gas pedal was depressed and a warning light indicated a problem which was confirmed as a failed battery in January 2023. I was advised by the Hyundai Sonata service center 13 weeks ago that the vehicle was unsafe to…
My 2017 Hyundai hybrid PHEV vehicle stuttered and failed to accelerate when the gas pedal was depressed and a warning light indicated a problem which was confirmed as a failed battery in January 2023. I was advised by the Hyundai Sonata service center 13 weeks ago that the vehicle was unsafe to drive due to a defective battery. They have not been able to replace the battery or provide an estimate of when the replacement battery will be delivered. The battery has a lifetime warranty but the Hyundai company and dealership is not providing a loaner vehicle or reimbursing me for rental vehicle while the unsafe vehicle sits in the service center for more than 3 months. Please help.
- Electrical system · Engine · Fuel/propulsion system
Problem began Dec. 2021. Has occurred on 16 occasions since then. Warning light "Check Hybrid System; Turn off Engine" comes on while driving. The car then shuts off the engine and there is a 100% loss of motive power. Sometimes is associated with very rough braking with the car "knocking'." On 3…
Problem began Dec. 2021. Has occurred on 16 occasions since then. Warning light "Check Hybrid System; Turn off Engine" comes on while driving. The car then shuts off the engine and there is a 100% loss of motive power. Sometimes is associated with very rough braking with the car "knocking'." On 3 occasions there has been partial/near complete loss of braking power. All incidents have occurred while under power, so far all while under 45 mph. No accidents yet. Two near collisions from the rear. Hyundai was notified of the problem Dec. 2021/Jan. 2022. After a month of testing they stated the car needed a new plug-in hybrid battery. One was not available and due to "supply chain issues" is still not available 15 months later. Dealership provided a loaner vehicle Jan to Sept. 2022. They requested their car back and Hyundai initially agreed to cover the cost of a rental car. I rented a car for 6 weeks in Sept.-Oct. 2022 at which point a new case manager informed me that Hyundai would not pay for a rental vehicle any longer (note: they did reimburse me the cost of those 6 weeks rental). Hyundai is well aware of the safety issues involved in driving this vehicle. However, they have chosen to ignore them. Their attorney, in a letter to the Ohio Attorney General's Office, blamed the lack of a plug in hybrid battery on supply chain issues (letter was Nov. 2022, at which time the battery was supposed to be available March 2023) and only stated that my vehicle was "drivable." Another warning message "High System Temperature; Switching to Hybrid Mode" has been occurring for a couple of years periodically. Since October 2022, the malfunction indicator lamp is always on and 99% of the time the "Check Hybrid System!" warning light also comes on after about a minute after starting the vehicle. On 3 other occasions the vehicle has entered into "limp home mode" instead of complete shutdown.
- Electrical system
The vehicle has stalled in traffic numerous times since I bought it in 2016 creating a traffic safety issue. Without warning the lights on the dash will flash and the car dies. I have worried each time that traffic behind me would collide with my car. #1 1 1/2 years into ownership this occurred.…
The vehicle has stalled in traffic numerous times since I bought it in 2016 creating a traffic safety issue. Without warning the lights on the dash will flash and the car dies. I have worried each time that traffic behind me would collide with my car. #1 1 1/2 years into ownership this occurred. They replaced part of the EV charging system that was overheating on the cars. (RECALL) # 2 1 /2 years into ownership the air-conditioner failed and the car stalled in traffic due the air-conditioner failing. (REPLACED UNDER EXTENDED WARRANTY) # 3 Last year I complained that a Hybrid Overheat Message would come on switching to EV mode and the transmission felt like it was slipping occasionally, and the battery only held 20 miles of charge, rated for 27. They refused to change the battery system under the lifetime warranty. #4 Last summer car stopped charging (REPLACED INVERETER UNDER EXTENDED WARRANTY) This month car stalled on the roadway, lights flashed on dashboard. Could have been rear-ended, Had to coast to a stop and restart the car. Took to dealer the said the replaced an EV computer for 5K (REPLACED COMPUTER UNDER EXTENDED WARRANTY) 3 days later same issue, stalled on busy street without warning. Took to dealer and the replaced the cars main battery, charging me $450.00 3 Days later it stalled again without warning in traffic, It's not back in the shop. THIS VEHICLE HAS MAJOR SAFETY PROBLEM. IT'S EXTREMELY DANGEROUS TO HAVE A CAR STALL IN TRAFFIC WITHOUT ANY PRE-WARNING. THE DESIGN IS DEFECTIVE. THE CARS NEED TO BE RECALLED AND BOUGHT BACK AT FULL PRICE BY THE HYUNDAI.
- Engine
The engine started knocking on the freeway and all the lights in the car went off. The engine failed and I barely made it off the freeway. I was almost hit by two cars trying to get to a safe place. The engine has the same issue as the other morsels that have recalled the engine for the same rod…
The engine started knocking on the freeway and all the lights in the car went off. The engine failed and I barely made it off the freeway. I was almost hit by two cars trying to get to a safe place. The engine has the same issue as the other morsels that have recalled the engine for the same rod failure issue but Hyundai has not extended the recall to the plug in hybrid. This model also bends to be recalled because it is a danger to all owners and other drivers. Hyundai declined to repair the defective engine.
- Engine
On cold mornings, during the first start of the day, and while going downhill, the internal combustion engine comes on while running on electrical power from the battery. This is understandably to heat up the engine to ideal temperatures. But within a minute, the car gives a hybrid battery error…
On cold mornings, during the first start of the day, and while going downhill, the internal combustion engine comes on while running on electrical power from the battery. This is understandably to heat up the engine to ideal temperatures. But within a minute, the car gives a hybrid battery error, fully loses power requiring to be stopped immediately. This is obviously dangerous anywhere but particularly downhill. The car requires to be restarted after pulling over 1-3 times until the engine / battery reach ideal temperatures. Then the car runs as expected. The dealership has been unable to diagnose the issue and chalked it up to an unrelated recall - which has been fixed, but the issue still occurs risking the safety of the people inside the car and around.
- Engine
While driving on surface streets (10-15 MPH) about 5 minutes out from our house, the accelerator stopped working properly and a warning popped up along the lines of "Hybrid HEV warning: Please shut off engine and restart." Since there were no other cars behind us, we were able to thankfully pull…
While driving on surface streets (10-15 MPH) about 5 minutes out from our house, the accelerator stopped working properly and a warning popped up along the lines of "Hybrid HEV warning: Please shut off engine and restart." Since there were no other cars behind us, we were able to thankfully pull over without too much trouble. However, if we had been on a highway this would have been incredibly dangerous, as we would have lost speed quickly and had no safe way to pull over. There were no warnings prior to this happening on that day. The car just sudden stopped working and then lights popped on. Using an OBD reader, the issue code was P0DE7: Hybrid/EV Battery - Cell Voltage High. We are going to the dealer at the earliest appointment to have it looked at, and the car is clearly not safe for anything but surface roads with easy pull-offs. Related Items: A week or so ago, we had an incident where the car was a bit sluggish to accelerate after a right hand turn (e.g., needed to take foot off the gas, then put it back on after a moment to accelerate). However, no check engine light came on and the car ran fine after. A second potential related item was that the expected mileage on battery-only had reduced from about 27 to 23 miles on a full charge. This occurred within the last two months before this issue.
- Engine
The contact owns a 2017 HYUNDAI Sonata Plug-In Hybrid. The contact stated while driving approximately 35 MPH, the vehicle started making a loud knocking sound. The contact pulled over and noticed an excessive amount of oil underneath the front of the vehicle. The contact took the vehicle to a…
The contact owns a 2017 HYUNDAI Sonata Plug-In Hybrid. The contact stated while driving approximately 35 MPH, the vehicle started making a loud knocking sound. The contact pulled over and noticed an excessive amount of oil underneath the front of the vehicle. The contact took the vehicle to a certified mechanic who diagnosed that there was a hole in the engine block. The mechanic showed the contact a piece of metal that had fractured from the engine. The contact stated that three days later while driving approximately 25 MPH, the vehicle stalled. The vehicle was towed to the dealer who confirmed that the vehicle was not included in NHTSA Campaign Number: 21V727000 (Engine). The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 76,000.
- Engine · Fuel/propulsion system
On August 31st 2021, While driving my 2017 Hyundai Sonata PHEV on interstate 95 the check engine and hybrid system warning lights came on and the car simultaneously lost power for 3-4 seconds, which caused a decrease in speed from 65 to approximately 50 mph. There was a tractor trailer behind me…
On August 31st 2021, While driving my 2017 Hyundai Sonata PHEV on interstate 95 the check engine and hybrid system warning lights came on and the car simultaneously lost power for 3-4 seconds, which caused a decrease in speed from 65 to approximately 50 mph. There was a tractor trailer behind me but thankfully it braked to avoid striking my car. The car regained partial power and I was able to drive it home. I took the car to the dealership to have it repaired. The dealer diagnosed a faulty battery management system, and replaced this component after 17 days. On September 25, while driving on a street the car once again lost power for 3-4 seconds, with the check engine and hybrid system lights simultaneously illuminated. There was a recall on my vehicle several years ago to prevent this dangerous problem. I had the car repaired at that time but clearly the problem was not fixed as my car has subsequently lost power on two separate occasions, in a manner that could have easily caused a crash.
- Unknown or other
The trunk will not open by any means, at times it can be opened, but the emergency release does not work. If anyone gets in, they cannot get out, especially with the Hybrids which do not have fold down back seats. Federal mandate states the trunk must have an operational emergency release, but with the trunk latch issue, the emergency release does NOT work.
- Unknown or other
The trunk latch not locking. Opened trunk in driveway, tried to close trunk and it wouldn't lock/close.
- Engine
TL* the contact owns a 2017 hyundai sonata plugin hybrid. The contact stated while driving 50 mph, she heard an abnormal sound. The contact stated that there was no warning light illuminated. The contact drove to her residence. The contact stated she had the vehicle towed to harrisonburg ford, inc.…
TL* the contact owns a 2017 hyundai sonata plugin hybrid. The contact stated while driving 50 mph, she heard an abnormal sound. The contact stated that there was no warning light illuminated. The contact drove to her residence. The contact stated she had the vehicle towed to harrisonburg ford, inc. (3155 s main st, harrisonburg, va 22801; (540) 434-0700), where it was diagnosed with needing the engine to be replaced. The vehicle was repaired. The manufacturer had not been informed of failure. The failure mileage was approximately 75,000.*dt
- Engine · Power train
I was driving my hyundai 2017 sonata plugin hybrid on the high way in hev mode and suddenly I felt severe vibration in my car. Then I changed my engine to EV mode and it was fine. Engine light came on. Every time the gas engine came on the car started vibrating and non responsive to gas. I drove…
I was driving my hyundai 2017 sonata plugin hybrid on the high way in hev mode and suddenly I felt severe vibration in my car. Then I changed my engine to EV mode and it was fine. Engine light came on. Every time the gas engine came on the car started vibrating and non responsive to gas. I drove about 10 more km towards home on electric only engine and then got it towed to the dealership. It felt like engine lost its power. I recently changed the voltage protection device on the car as a recall. All services were done on time and car had only 33000 km.
- Unknown or other
The shark fin antenna cover came off the vehicle. When I parked the car, after driving on the highway, I noticed that it was gone. This definitely can pose a driving hazard if it comes off the vehicle while driving on the highway. I noticed that what was left of the base mounts appeared to be…
The shark fin antenna cover came off the vehicle. When I parked the car, after driving on the highway, I noticed that it was gone. This definitely can pose a driving hazard if it comes off the vehicle while driving on the highway. I noticed that what was left of the base mounts appeared to be cracked which resulted in the fin breaking free. This definitely appears to be a manufacturing defect. It's approximately a $500 cost at the dealer to repair. This shouldn't happen after two years of car ownership. It will get very costly to replace this at the dealer every two years. Based on others' experiences, this appears to be a common occurrence with this vehicle.
- Vehicle speed control
While vehicle IS in motion at various speeds with cruise control engaged climbing up on hilly or steeper grades the vehicle accelerates on the dash at nearly 100 percent power according to the hybrid tachometer. This increase in power surpasses well over the set cruise speed. From what I have…
While vehicle IS in motion at various speeds with cruise control engaged climbing up on hilly or steeper grades the vehicle accelerates on the dash at nearly 100 percent power according to the hybrid tachometer. This increase in power surpasses well over the set cruise speed. From what I have noticed its 6-10 mph climbing past my set speed. There IS also a long delay in power restoration after coasting down hills. I found it to be extremely dangerous with the vehicle at 100 percent power because it could create a situation in which you could possibly rearend another driver or lose control in normal or adverse driving conditions, resulting in injury or loss of life. In addition the issue could lead to a traffic infraction. My state has a lot of speed cameras. This problem have resulted from the recent recall where hyundai installed a new battery management system. The vehicle has aproximently 16400 miles on it.
- Electrical system
This IS the plugin hybrid model. the lithium ion battery cannot be charged sometimes due to overheating condition. if this IS not fixed, it might cause a fire or explosion. sometimes, it will not let you charge. It will not even let you turn off the charge schedule to charge. sometimes, it…
This IS the plugin hybrid model. the lithium ion battery cannot be charged sometimes due to overheating condition. if this IS not fixed, it might cause a fire or explosion. sometimes, it will not let you charge. It will not even let you turn off the charge schedule to charge. sometimes, it stops charging due to thermal problem. hyundai IS not taking responsibility to fix this. attached photo documented that it did not allow me to switch off the charge scheduler to start charging. I hope hyundai will address this problem before the car burns up or explodes.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
- Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles…
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008009This bulletin provides instructions to update the 4th generation AVN head unit software to ensure the SIM Over The Air function for the Bluelink service is operating properly.
- 11002760This bulletin provides instructions to update the 4th generation AVN head unit software to ensure the SIM Over The Air function for the Bluelink service is operating properly.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10235524The warranty coverage for certain 2015-2017MY Sonata (LFa) and Sonata Hybrid/Plug-in (LF HEV/PHEV) vehicles exhibiting reduced power steering assist and/or motor driven power steering (MDPS) warning lamp has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first. Refer to the TSB 23-ST-003H (or latest version) for warranty, service parts information, and diagnostic information outlined in the bulletin.
- 10235349The warranty coverage for certain 2015-2017MY Sonata (LFa) and Sonata HEV/PHEV (LF HEV/PHEV) vehicles exhibiting reduced power steering assist and/or motor driven power steering (MDPS) warning lamp has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first. Refer to the warranty, service parts information, and diagnostic information outlined in this bulletin.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10227320Certain vehicles may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise, or no crank/no start condition related to connecting rod bearing wear or damage. This Dealer Best Practice outlines the service process to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results, as well as related warranty coverage for the conditions outlined above.
- 10227317Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10227316The warranty coverage for engine repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners. Commercial entities and individuals engaged in the buying, selling, leasing, or renting of motor vehicles, as well as salvaged vehicles, are ineligible for the extended warranty.
- 10227313Op code/part number (reference guide for service campaign T6G)
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10215599Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10211680Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10211678Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10211675The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
- 10211668Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10211667Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10211666Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10211664Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10211663Hyundai is conducting a service campaign to further enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs on certain 2017-2018 model year Sonata Hybrid/Plug-In vehicles.
- 10211662Certain vehicles that have completed Service Campaign 966 may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10210206Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10210205Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10206367When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) may not be available. This TSB# 21-01-080H describes the 3-part software to correct this condition and activate Blue Link Services.
- 10206366Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203282Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203280Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203277The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
- 10203272Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing
- 10199106This bulletin describes the procedure to diagnose and repair the Engine Electric Water Pump (EEWP) on certain Sonata Hybrid (LF HEV) and Sonata Plug-In Hybrid (LF PHEV) vehicles with DTC P2600, causing an HEV and/or MIL warning lamp illumination.
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190038This bulletin provides best practice recommendations when performing brake service procedures.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10183963This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10180985Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
- 10180981This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
Every Hyundai Sonata Plug-In Hybrid model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.