2006 International 3000

Recalls

1 recall names the 2006 International 3000. Newest first.

• Electrical system

  Jun 5, 2008NHTSA 08V25800051,588 vehicles

  Navistar IS recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination…

  Risk and remedy

  Risk

  A fire could cause personal injury or death.

  Remedy

  Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890.

  Full recall details →

Owner complaints

Latest complaints

• Oct 1, 2008FL
  Steering
  Tl*the contact owns a 2006 international semi 3000. while driving approximately 60 mph or less on an uneven road surface, the vehicle automatically turned in the opposite direction of the desired steering. there were situations when the steering was uncontrollable. there were no warnings prior…

  Tl*the contact owns a 2006 international semi 3000. while driving approximately 60 mph or less on an uneven road surface, the vehicle automatically turned in the opposite direction of the desired steering. there were situations when the steering was uncontrollable. there were no warnings prior to this failure. the vehicle has not been repaired. the contact was concerned of the safety risk involved. the contact was uncertain of the vehicle model. the vin and failure mileage were unknown.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11010428This article addresses chassis lean conditions on all chassis. This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
• 10251414Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
• 10251409Suggested alignment target values when performing a vehicle axle alignment.
• 10243610How to request a horsepower quote; all International and Cummins engines
• 10243596General Wheel Speed Sensor Troubleshooting
• 10243595Diagnosis of chassis wander complaints.
• 10234000Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
• 10209487Calculating pulses per mile (speedometer setting); only models equipped with International engines
• 10204139Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
• 10204137J1939 Data Link Troubleshooting
• 10201758Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
• 10199915General wheel speed sensor troubleshooting
• 10198708Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
• 10179296Codes 141, 142, and 621 in a 2-box ECM/IDM; only models with 2-box ECM/IDM from 2003-2007
• 10179294Driveline Information Center and Troubleshooting Procedures
• 10179289Repair Procedures for Vehicles Struck by Lightning
• 10177073This article is for adding additional protection to the driver's area of the bus to help mitigate the transmission of germs.
• 10173025Cleaning and Disinfecting Trucks and Buses
• 10172045J1939 Data Link Troubleshooting
• 10167666Injector Driver Module (IDM) Bottom Kit
• 10166288Uneven Brake Pad Wear Between the Inner and Outer Pads on Hydraulic Brake /Pin Slide Vehicles; only models built after 1/2004
• 10165643Oil Capacities; All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX
• 10163416Suspension Lean Diagnostics; All models
• 10162034J1939 Data Link Source Address Information
• 10156576Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
• 10156324Driveline Information Center and Troubleshooting Procedures
• 10156305Tool Instruction - BCM Programming Harness
• 10145721A/C Refrigerant and Oil Capacities
• 10145715Engine Oil Capacities All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX
• 10145711Radio Diagnostics and Information
• 10131400The engine high pressure oil line may develop a leak or possibly rupture.
• 10131243Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
• 10130950J1939 Data Link Troubleshooting
• 10130884HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
• 10130883NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
• 10130882Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR Aftertreatment system and N9, N10, N13, A26 or Cummins ISB, ISL, ISX engines built from January 2016
• 10130822J1939 Data Link Troubleshooting
• 10130787Using Supplier Software to Check DTCs
• 10129185Cooling System Flush Procedure
• 10129177J1939 Data Link Source Address Information

Every International 3000 model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.