2011 International Terrastar
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › International › Terrastar › 2011
These records cover every 2011 International Terrastar. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2011 International Terrastar. Newest first.
Navistar IS recalling certain model year 2011-2012 ic ac, be, ce, hc and international 4300, and terrastar commercial trucks manufactured from february 25, 2010, through april 4, 2011, and equipped with a maxxforce 7 engine. a cap on the return fuel valve may fall off allowing air to be drawn into the fuel system possibly resulting in engine hard start, no…
Risk and remedy
Risk
Engine stall on the roadway increases the risk of a vehicle crash.
Remedy
Navistar will notify owners and dealers will replace the return fuel valve cap free of charge. the safety recall began on july 18, 2011. owners may contact navistar at 1-800-448-7825.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010428This article addresses chassis lean conditions on all chassis. This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
- 10251414Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
- 10251409Suggested alignment target values when performing a vehicle axle alignment.
- 10246231J1939 Data Link Source Address Information
- 10243610How to request a horsepower quote; all International and Cummins engines
- 10243596General Wheel Speed Sensor Troubleshooting
- 10243595Diagnosis of chassis wander complaints.
- 10241555J1939 Data Link Source Address Information
- 10241554J1939 Data Link Troubleshooting
- 10234000Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
- 10227455J1939 Data link source address information
- 10222490Pico Scope CCOS (Crankcase Separator Test)
- 10219330PicoScope Test One Channel RCT
- 10219328PicoScope Wheel Speed Sensor Test
- 10219325PicoScope Test Resistance and Ohmmeter
- 10219319PicoScope Test for Datalink (CAN) Health Shorts & opens
- 10219314PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
- 10219308PicoScope Test 12V Electrical Noise Detection
- 10219307PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- 10209487Calculating pulses per mile (speedometer setting); only models equipped with International engines
- 10208432ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- 10208431J1939 Data Link Source Address Information
- 10204139Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- 10204137J1939 Data Link Troubleshooting
- 10201758Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
- 10200831Cab water leak troubleshooting tips
- 10199915General wheel speed sensor troubleshooting
- 10198708Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- 10185108ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10. 2010-2012 MaxxForce DT/9/10, 2007-2009 MaxxForce V8, 2008-2009 MaxxForce 11/13 engines
- 10181960Cab Lean Concern
- 10179294Driveline Information Center and Troubleshooting Procedures
- 10179289Repair Procedures for Vehicles Struck by Lightning
- 10177096A/C Refrigerant and Oil Capacities
- 10173025Cleaning and Disinfecting Trucks and Buses
- 10172045J1939 Data Link Troubleshooting
- 10167661Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- 10167657How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- 10167628One piece sunshade mounting bracket becomes loose or comes off the cab; Only models built in Garland or Springfield between June 2010 and February 2012. This does not affect Escobedo built vehicles.
- 10167625TerraStar Transmission Shift Cable Routing
- 10166340Transfer Case Diagnostic and Operational Information; Only 4x4 Models
Every International Terrastar model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.