2021 KIA Rio
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2021 KIA Rio. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2021 KIA Rio. Newest first.
Kia Motors America (Kia) is recalling certain 2021-2022 Rio and Forte vehicles. A bolt in the steering column may not be secured properly, which can cause the steering column to detach from the steering rack and result in a loss of steering control.
Risk and remedy
Risk
Loss of steering control can increase the risk of a crash.
Remedy
Dealers will tighten the lower steering column u-joint retention bolt, free of charge. Owner notification letters were mailed May 27, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall SC235.
Kia Motors America (Kia) is recalling certain 2020-2021 Rio vehicles. The brake master cylinder may have been manufactured with sharp edges that can damage the inner oil seal, resulting in reduced braking performance.
Risk and remedy
Risk
Reduced braking performance can cause longer brake pedal travel or extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy
Dealers will replace the brake master cylinder, free of charge. Owner notification letters were mailed January 11, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall SC223.
Owner complaints
15 complaints2 involved a crash
What owners report most
Latest complaints
- Unknown or other
Back up camera sometimes flips sides, so that obstacles on the right side of the car are shown on the left side of the camera screen. Sometimes the camera doesn't work at all.
- Steering
Steering Gear Assembly completely broke at 81,000 miles. My daughter was backing up in a busy street at 5pm and lost 100 percent of steering control. Lucking cars dodged her and she didn’t get hurt or worse.
- Power train · Unknown or other
Placed car in park got out to open a gate. Car took off forward even when shifter was in Park Position and almost ran a child over.
- Back over prevention › Sensing system › Camera · Electrical system
Center Console Display blank (screen black) upon startup unable to see cameras and backing up affected creating safety concern.
- Seat belts · Unknown or other
seatbelts in rear are inoperable/anti theft not working. Kia dealership told me that its not their issue about the anti theft. I have been told on 3 separate occasions that my seatbelts have been ordered but they haven’t!!!! No one is following up with me, when I call I get told “until they can get…
seatbelts in rear are inoperable/anti theft not working. Kia dealership told me that its not their issue about the anti theft. I have been told on 3 separate occasions that my seatbelts have been ordered but they haven’t!!!! No one is following up with me, when I call I get told “until they can get in contact with the dealership Kia the corporate company cannot do anything” have 2 kids Kia the dealership as well as the corporate company knows about this and no one is doing anything!! NO ONE CARES
- Unknown or other
At speeds over 20 miles per hours there is a “flapping” noise that sounds like a bag or piece of paper that is blowing in the wind. Although I don’t know were the noise originates, I can hear it clearly from the driver’s side b-pillar. It is incredibly annoying and greatly diminishes what is otherwise a solid entry, level vehicle.
- Lane departure › Assist · Lane departure › Warning · Steering
On 3/19/23, as I was driving on a dry, straight, two lane road at the posted speed of 40mph, the car began to try to steer into oncoming traffic. I had to exert moderate force to keep the car in my lane. This continued continuously for about 1/2 mile. No low tire pressure indicator lights were…
On 3/19/23, as I was driving on a dry, straight, two lane road at the posted speed of 40mph, the car began to try to steer into oncoming traffic. I had to exert moderate force to keep the car in my lane. This continued continuously for about 1/2 mile. No low tire pressure indicator lights were illuminated, however the lane assist icon was on and green, indicating normal operation. Just as I was going to turn down a side street to check the tires manually, the steering returned to normal. However, the lane assist icon was now white, and as I drove the remaining approximately 2 miles home, the icon would change from white to green every 20 seconds or so. The car now operates normally. We took the car to the dealer today to be checked and they reported they could not replicate the issue. Attached is their report.
- Unknown or other
The contol post for lights, turn signal, and high beams is too sensitive. To control the lights, you twist the top of lever. To turn on turn signals, you flip the lever up or down. To turn on brights, the lever goes forward. To turn of lights, the lever is pulled back. The issue..... If you…
The contol post for lights, turn signal, and high beams is too sensitive. To control the lights, you twist the top of lever. To turn on turn signals, you flip the lever up or down. To turn on brights, the lever goes forward. To turn of lights, the lever is pulled back. The issue..... If you have brights on, when you pull lever back to dim lights, the top automatically twists to shut off the headlights entirely. DANGEROUS DANGEROUS DANGEROUS. My husband doesn't have this problem, but he has longer fingers and his fingers hit the lever more at the base where nothing twists. I have shorter women's fingers and they can't reach all the way down the lever. I have since adjusted how I dim the brights by reacing under the lever, (close to steering column), to pull the lever back. This is very uncomfortable and tends to cause me to make the turn signal come on, which could cause its own traffic accident. My remedy would be to make the headlights twist in the opposite direction for on off, or make the switch for headlights have a little more resistance.
- Service brakes · Steering
Having been complaining about a noise from under the front right tire, I was initially told it was a little piece of plastic and that got cut off. I was still hear the scraping and squealing and I kept check the from right tire because I thought that's where it was coming from. I mentioned this to…
Having been complaining about a noise from under the front right tire, I was initially told it was a little piece of plastic and that got cut off. I was still hear the scraping and squealing and I kept check the from right tire because I thought that's where it was coming from. I mentioned this to every mechanic at kia and was told "that's just how 2021s sound". Finally after months of complaining the noise got louder and you could hear it was clearly something in steering. They schedules an appointment for Dec 7th on Mon Nov 28th. Said it was safe to drive when that night while working I was turning a corner, I heard a loud spring noise, the tire and wheel jerked. It was snowing, so the car slide, only sliding into the curb. The front right break seemed to be locked and when you turn the steering wheel makes even more noise. Haven't been told the issue, but I'm certain it is not safe and definitely shouldn't be on the streets until it's fixed.
- Power train
I had driven my wife to her school about 5 miles and headed back to my work another 5 miles when i tried to accelerate pass car I lost almost all power barely making it up a slight hill I kept going trying to make it to my house barely going 10 miles an hour. I thought the transmission had let…
I had driven my wife to her school about 5 miles and headed back to my work another 5 miles when i tried to accelerate pass car I lost almost all power barely making it up a slight hill I kept going trying to make it to my house barely going 10 miles an hour. I thought the transmission had let go cause while I had the gas peddle floored i went at best 10-15 miles an hour I eventually parked the car I knew it would never make it up another slight hill. It was rowed to a nearby dealer where they could find no problem telling me it was just some bad gas. This sounds like what I read about today with a couple of other models of Kia.
- Steering · Unknown or other
The steering wheel column does not have a lock therefore someone broke into my car and tried to steal it and destroyed it, also no alarm went off when this happened.
- Engine
I was driving 60-70 miles an hour for 45 minutes then car lost all acceleration and engine light came on. I pulled over immediately turned the car off. Turned it back on drove 1/4 of a mile and same thing happened. I pulled over turned car off and had it towed to the dealership.
- Service brakes
Vehicle failed to reduce speed effectively while trying to avoid a collision with another vehicle during a left turn, which then caused the vehicle to turn widely and collide with the curb.
- Engine · Fuel/propulsion system
Vehicle has less than 4000 miles and throttle body had to be replaced
- Service brakes
On the way to work, I had the brake pedal pressed waiting for a traffic signal to change. After it changed to green, I released the brake pedal and depressed the gas pedal, only for the vehicle not to move forward - as if the brake was still being applied. I took my foot off the gas pedal, waited a…
On the way to work, I had the brake pedal pressed waiting for a traffic signal to change. After it changed to green, I released the brake pedal and depressed the gas pedal, only for the vehicle not to move forward - as if the brake was still being applied. I took my foot off the gas pedal, waited a second or two, then tried the gas pedal again and it still did not move. I was at the traffic signal for nearly 10 seconds with nothing touching the brake pedal and unable to drive forward. The vehicle did not turn off, display any warning lights, or any signs of other trouble. The parking brake was not applied and the vehicle was in Drive. After putting the vehicle in reverse and back into drive while still stopped at the traffic signal, the car resumed normal operation. The vehicle has less than 200 miles, bought brand new from the dealership a few days prior and has only gone for a car wash at the dealership aside from normal daily commute. The problem has not been reported to the dealership or manufacturer at the time of this report.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009080TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
- 11005368TECHNICAL SERVICE BULLETIN: DISPLAY AUDIO 2.0V/AVN5W SOFTWARE UPDATE - This bulletin provides information to update the software on Display Audio 2.0 (D2V) and 5th Generation AVN Wide (AVN5W) head units on certain 2021-2023MY Kia vehicles. The affected vehicles may experience Apple CarPlay/Android Auto phone projection connectivity-related concerns.
- 11004930TECHNICAL SERVICE BULLETIN: IVT OIL PRESSURE SENSOR REPLACEMENT: This bulletin provides information to replace the Intelligent Variable Transmission (IVT) Oil Pressure Sensor (OPS) on some 2018-2024MY vehicles listed on page 3 equipped with IVT. The affected vehicles may exhibit a malfunction indicator lamp (MIL) illuminated on the instrument cluster with DTCs P084500, P084600, and/or P0867XX present with no drivability concerns due to a failed IVT oil pressure sensor.
- 11001598TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from May 30, 2011 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
- 11000787This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
- 10250838TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
- 10250517TECHNICAL SERVICE BULLETIN: AVN 5.0 WIDE NON-RESPONSIVE RADIO ICON (AM, FM, SXM) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.
- 10247581CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia now has an additional vehicle modification available for installation to help deter or thwart attempted thefts. This modification consists of a theft deterrent ignition cylinder protector and will be available to you free of charge for eighteen (18) months from the date of this letter.
- 10247554TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
- 10247553TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 13, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
- 10245168TECHNICAL SERVICE BULLETIN: PARTIAL SEAT TRACK REPLACEMENT FOR INOPERATIVE FRONT SEAT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect and repair an inoperative front seat mechanism on some 2019-2024MY Forte (BDm) vehicles produced from June 18, 2018 through Present and some 2018-2023MY Rio (SC) vehicles produced from January 2, 2017 through August 16, 2023. Symptoms of an inoperative front seat include the inability of the seat to move forward and backward, which may be caused by a pin getting stuck on a rail.
- 10244292CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. Kia has since learned that some vehicles fall within a group of 2018-2021 MY Kia Rios that did not have the correct version of the software installed, and the software that was installed in the vehicle does not restrict operation of the vehicle as intended. We have corrected this issue and encourage customers to schedule an appointment with their local Kia dealer to install the corrected software as soon as possible. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
- 10243925TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from May 30, 2011 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10242912TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from February 28, 2012 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10242576CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia is now making steering wheel lock devices available directly to certain Kia vehicle owners. These devices can help deter a theft attempt. We are making this device available to customers free of charge and will ship it directly to customers who place orders within eighteen (18) months from the date of this letter.
- 10242575TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from February 28, 2012 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10241171CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
- 10239717TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from February 28, 2012 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10237139TECHNICAL SERVICE BULLETIN: OVERHEAD CONSOLE SUNGLASS DOOR-LATCH REPAIR - This bulletin provides information to repair the overhead console lamp assembly and sunglass door latch on some 2012-2023MY model vehicles listed in the table below, which may encounter the sunglass case of the overhead console lamp not closing properly.
- 10236653TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from February 28, 2012 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10236111CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
- 10236109TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) produced from February 28, 2012 through March 31, 2017 and 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
- 10235104PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
- 10234600TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB) and 2018-2021MY Rio (SC) vehicles produced from June1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
- 10234599TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2307) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2012-2017MY Rio (UB), 2018-2021MY Rio (SC) vehicles produced from June 1, 2017 through October 25, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
- 10226555TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
- 10220346TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
- 10217892TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."
- 10217891PITSTOP: REAR OCCUPANT ALERT (ROA) W/REAR DOOR LOGIC - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding the Rear Occupant Alert (ROA) with Rear Door Logic system on all 21MY~ models equipped with this feature. This system is designed to help prevent a rear passenger from being left inside the vehicle when exiting. The "Check Rear Seats" message will display on the cluster when driver opens the front door, if during vehicle operation the rear doors (one or both) were opened and closed.
- 10209438TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
- 10206642TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
- 10205426TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
- 10202226TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
- 10201529TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
- 10201158TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
- 10200525PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
- 10196825PIT STOP: LOG FILE COLLECTION FOR AVN 5.0/W AND DISPLAY AUDIO 2.0 - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop contains information regarding the log file collection procedure for 2020MY~ models equipped with AVN 5.0/W or Display Audio 2.0 head units.
- 10193091TECHNICAL SERVICE BULLETIN: SERVICE ACTION: FRONT CAMERA LOGIC IMPROVEMENT FOR DTC 160649 (SA475) - This bulletin provides the procedure to update the software logic of the Front Camera system on some 2021MY Rio (SC) vehicles produced from December 22, 2020 through March 29, 2021 to correct an out-of range fault signal that will disable the supplemental Forward Collison Avoidance (FCA), if equipped, Lane Departure Warning (LDW), Lane Following Assist (LFA), Lane Keep Assist (LKA), Driver Attention Warning (DAW) and High Beam Assist (HBA) systems.
- 10190178TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster.
- 10189270TECHNICAL SERVICE BULLETIN: SERVICE REMINDER SETTING RESET PROCEDURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to turn OFF the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster.
Every KIA Rio model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.