2006 KIA Sedona
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › KIA › Sedona › 2006
These records cover every 2006 KIA Sedona. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2006 KIA Sedona. Newest first.
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Risk and remedy
Risk
An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy
Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 and originally sold in, or currently registered in Alaska, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Nebraska, New…
Risk and remedy
Risk
A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy
Kia will notify owners and dealers will replace the front lower control arms on 2006-2007 models. 2008-2012 models will either have their front lower control arms replaced or additional anti-corrosion coating will be applied. These repairs will be performed free of charge. The recall began on July 27, 2016. Owners may contact Kia at 1-800-333-4542. Kia's number for this recall is SC133.
Kia Motors Corporation (Kia) is recalling certain model year 2006-2014 Kia Sedona vehicles manufactured from June 15, 2005, through April 04, 2014. In the affected vehicles, the secondary hood latch may bind and remain in the unlatched position when the hood is closed.
Risk and remedy
Risk
If the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Remedy
Kia will notify owners and dealers will replace the secondary hood latch or clean and lubricate the latch, depending on the vehicle's location and the condition of the latch. These repairs will be performed free of charge. The recall began on July 27, 2016. Owners may contact Kia at 1-800-333-4542. Kia's recall number is SC134.
Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 originally sold in, or currently registered in Massachusetts, Maryland, Michigan, New Hampshire, New York, Pennsylvania, Vermont, Wisconsin, Connecticut, Delaware, Iowa, Illinois, Indiana, Maine, Minnesota…
Risk and remedy
Risk
A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy
Kia will notify owners and dealers will inspect the degree of corrosion of the front lower control arms, and will either rustproof or replace them, free of charge. The recall began on December 20, 2013. Owners may contact Kia at 1-800-333-4542. Kia's recall number is SC100.
Huyndai-kia IS recalling 139,844 my 2006-2007- sedona, sportage, sorento and my rondo and amanti vehicles. the stop lamp switch in the affected vehicles may malfunction. a malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal IS depressed or may cause the brake lights to remain illuminated when the brake pedal…
Risk and remedy
Risk
Any of these malfunctions, alone or in combination, may lead to a crash.
Remedy
Dealers will replace the stop lamp switch free of charge. the recall began on june 17, 2009. owners may contact kia's consumer assistance center at 1-800-333-4542.
On certain passenger vehicles equipped with adjustable brake pedals, the stop lamp switch wiring harness may be out of position. an improperly positioned stop lamp switch wiring harness could make contact with the u-joint assembly of the steering column. repeated contact may eventually cause the wiring harness insulation to chafe.
Risk and remedy
Risk
Chafed insulation could cause a short of the wiring harness resulting in the loss of brake lights, engine stalling, or an inability to start the vehicle increasing the risk of a crash.
Remedy
Dealers will inspect the wiring harness for chafing and, repair if necessary. in addition, the dealer will secure the wiring harness to prevent contact with the u-joint assembly. the recall began on september 29, 2006. owners may contact KIA at 1-800-333-4542.
On certain passenger vehicles, the rear caliper brake hoses may be out of position. an improperly positioned rear caliper brake hose may contact rear suspension components and over time breach the integrity of the hose.
Risk and remedy
Risk
This would result in the loss of brake fluid, which could cause decreased brake function, leading to crash and personal injuries.
Remedy
Dealers will inspect the positioning of the rear caliper brake hoses and adjust or replace them free of charge. the recall began on september 15, 2006. owners may contact KIA at 1-800-333-4542.
Owner complaints
385 complaints13 involved a crash8 involved a fire18 injuries
What owners report most
Latest complaints
- Electrical system · Service brakes, hydraulic
The contact owned a 2006 Kia Sedona. The vehicle was bought used close to four years ago. The contact was unaware that the vehicle had received notifications of NHTSA campaign numbers 20V088000 (ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC), 16V389000 (LATCHES/LOCKS/LINKAGES), and 16V387000…
The contact owned a 2006 Kia Sedona. The vehicle was bought used close to four years ago. The contact was unaware that the vehicle had received notifications of NHTSA campaign numbers 20V088000 (ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC), 16V389000 (LATCHES/LOCKS/LINKAGES), and 16V387000 (SUSPENSION). The contact stated that while driving 30 MPH, an abnormal pop sound was heard coming from the vehicle. The contact noticed smoke was emitting from the front end of the vehicle. The contact stated that the heat gauge was rising. The contact pulled to the side of the road when a passerby ran up to the contact's vehicle and informed the contact that flames were visible under the vehicle. The passerby stated that he followed the contact for about a mile, honking and waving to notify the contact of the fire. The contact and child immediately exited the vehicle. The contact stated that once she exited the vehicle, the front end of the vehicle was engulfed in flames. The contact and child did not sustain any injuries. The police and fire department were called to the scene. The fire department extinguished the fire when, shortly after, there was an explosion. The vehicle was consumed by the fire and destroyed. The vehicle was towed to Wayne's towing yard. The manufacturer was notified of the fire. The contact was awaiting contact from KIA. The contact notified her insurance company. The failure mileage was approximately 189,000.
- Electrical system · Engine · Power train
Auto dealer fraud 8/3 2024 dealership sold me a title washed lemon with major safety hazards Defective unrepairable components Discovered later after purchase P0885 limp mode Fire hazard the vehicle may catch on fire when parked Went back to the dealership that I purchased from for a P0885 on…
Auto dealer fraud 8/3 2024 dealership sold me a title washed lemon with major safety hazards Defective unrepairable components Discovered later after purchase P0885 limp mode Fire hazard the vehicle may catch on fire when parked Went back to the dealership that I purchased from for a P0885 on December 4 2024 Returned Back to me march 18 2025 with a blown motor I asked the tow truck driver to be a witness to me firing up the vehicle for documentation Rey Prado of Prado towing located in Delaware he can verify my account Of events will give statement Dealership breached a bonded contract from a November 2021 purchase a 2004 ford f 250 super duty pick up truck vin# [XXX] and placed the title on the loan for the 2006 Kia Sedona without my prior knowledge the vehicle was purchased August 8 2024 with the cosign on August 21 2024 the dealer and staff purposely held the the buyer’s and purchasing agreement to pack the loan , the purchase agreement was finally given to me December 13 2024 after months of delay from the owners and staff . Owner finally told me on a march 17 2025 phone call he kept my title as a vested interest after I paid it off full in our contract agreement 8 months after the contract was signed the dealership operated in a Criminal Civil Rico fashion with me and is and has been extremely uncooperative with since I have been demanding all the original contracts for both vehicles , on February 20 while reviewing documentation that I was told was my title release forms I noticed a difference in dates they had me sign and date at the bottom 12/13/24 but the top of of the document it had a date of 12/2/2024 I didn’t realize this at first because they had me so confused about the van deal the truck title it seemed very systematic and intentional like they were purposely trying to confuse me about both contracts and my title it’s been a nightmare since then Please please please some one help my my mind and body are suffering because of this INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
- Electrical system · Engine · Vehicle speed control
Unknown. My vqn caught fire under my hood not sure were it came from.
- Air bags
Driver's airbag deployed prematurely. What should I do?
- Electrical system · Service brakes
The contact owns a 2006 Kia Sedona LX. The contact received notification of NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic) and stated that while powered off, he observed smoke emanating from the engine compartment. The contact stated that when the hood was opened…
The contact owns a 2006 Kia Sedona LX. The contact received notification of NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic) and stated that while powered off, he observed smoke emanating from the engine compartment. The contact stated that when the hood was opened, fire erupted from the engine compartment. The contact extinguished the fire. No police report or fire report was made available. The vehicle was taken to a dealer where it was diagnosed that an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 88,000.
- Suspension · Wheels
Frame rusted -out allowing right front wheel a -frame to come loose. Allowing wheel to move rearward into wheelwell stoping rotation. If I had been on the interstate ??? Maybe you wouldnot be reading this??? [xxx] uscg retired information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6).
- Unknown or other
Intermittently not starting. Not cranking. Battery has been checked. Alternator is ok. We've left it with our mechanic for a week and he was unable to replicate the issue. It's happening a couple times a month. We wait about 20 minutes then the Kia starts up. Yes the van is available for…
Intermittently not starting. Not cranking. Battery has been checked. Alternator is ok. We've left it with our mechanic for a week and he was unable to replicate the issue. It's happening a couple times a month. We wait about 20 minutes then the Kia starts up. Yes the van is available for inspection. My safety was at risk as the van not starting in below freezing Temps. No it has not been inspected by manufacturer. No warning lamps before or during issue. Issue has been going on over 3 months.
- Service brakes · Unknown or other · Wheels
Unknown
- Electrical system · Latches/locks/linkages · Service brakes, hydraulic
The contact owns a 2006 Kia Sedona. The contact received notification of NHTSA Campaign Number: 16V389000 (Latches/Locks/Linkages) and 20V088000 (Electrical System, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The contact stated that the…
The contact owns a 2006 Kia Sedona. The contact received notification of NHTSA Campaign Number: 16V389000 (Latches/Locks/Linkages) and 20V088000 (Electrical System, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Exterior lighting › Brake lights
The contact owns a 2006 Kia Sedona. The contact stated that while driving at 4MPH, a bystander informed him that the brake lights of his vehicle were not functioning. The contact stated that the brake lights failed to operate as needed. There were no warning lights illuminated. The vehicle was not…
The contact owns a 2006 Kia Sedona. The contact stated that while driving at 4MPH, a bystander informed him that the brake lights of his vehicle were not functioning. The contact stated that the brake lights failed to operate as needed. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 235,232.
- Electrical system
I obtained this vehicle from a relative in Ohio. They tried twice to have the recall repaired and twice they showed for an appointment to find out parts were not available. I bought and brought the car to Florida. I started the same process here with Daytona Kia {(386) 252-7000}. I have had 2…
I obtained this vehicle from a relative in Ohio. They tried twice to have the recall repaired and twice they showed for an appointment to find out parts were not available. I bought and brought the car to Florida. I started the same process here with Daytona Kia {(386) 252-7000}. I have had 2 appointments. The first on 8/31/2021 I cancelled having called the day before to be told the part was not in. As I was not communicated with despite being told I would be called, I initiated another effort in October. After being assured the part was in I made an appointment for November 20, 2021. That Saturday morning I sat in their waiting room for 1 1/2 hours just to be finally told the part was not in and they would inform me when it was. Parts still backordered.
- Unknown or other
The contact owns a 2006 Kia Sedona. The contact stated while the vehicle was parked in a parking lot, the vehicle erupted in flames without warning. Fire marshals were called and extinguished the fire. No one was injured and a report was taken. The contact mentioned a possible smoke inhalation from…
The contact owns a 2006 Kia Sedona. The contact stated while the vehicle was parked in a parking lot, the vehicle erupted in flames without warning. Fire marshals were called and extinguished the fire. No one was injured and a report was taken. The contact mentioned a possible smoke inhalation from the smoke. The vehicle was towed to the contact's residence. The manufacturer was informed of failure and was awaiting a response. The failure mileage was approximately 150,000.
- Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
The contact owns a 2006 Kia Sedona. The contact stated that while driving at various speeds, the vehicle would stall with the check engine warning light illuminated. The contact also stated that the vehicle would fail to reverse once placing the gear shifter into reverse. The contact had initially…
The contact owns a 2006 Kia Sedona. The contact stated that while driving at various speeds, the vehicle would stall with the check engine warning light illuminated. The contact also stated that the vehicle would fail to reverse once placing the gear shifter into reverse. The contact had initially taken the vehicle to an independent mechanic who was unable to service the vehicle and referred him to another mechanic who replaced the transmission. Almost a year later, the failure recurred, and the contact bought a code scanner that informed him that the catalytic converter was defective. The contact bought a new catalytic converter and had the catalytic converter replaced. Recently, the contact stated that while driving at various speeds, the vehicle began to hesitate upon depression of the accelerator pedal with the throttle body warning light illuminated. The contact used the code reader to clear the warning light and the vehicle resumed normal operation. On another occasion while driving 45 MPH, the vehicle stalled with the check engine warning light illuminated. Due to the failure, the contact had the vehicle towed to an independent mechanic who replaced the throttle body. Soon after the test drive, the transmission failed. The contact agreed to have the transmission replaced and the vehicle remained in the possession of the dealer. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 60,000.
- Suspension
Driving slowly out of parking lot a loud bang was heard. Scraping noise was heard from under van, drove about 25 yards then stopped at side of road. Left rear wheel was crooked and under van the left rear lower control arm was broken in half and was dragging on ground, left rear wheel was off…
Driving slowly out of parking lot a loud bang was heard. Scraping noise was heard from under van, drove about 25 yards then stopped at side of road. Left rear wheel was crooked and under van the left rear lower control arm was broken in half and was dragging on ground, left rear wheel was off ground. No one was injured, no other damage to this vehicle or others. This vehicle was previously serviced on Kia Service Campaign SC102, unknown date. Would have been serious accident if this occurred at highway speeds. Both lower control arms have been replaced, parts saved for inspection. Pictures attached. Kia was notified of this, case #[XXX]. Vehicle has one owner since new. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
- Seats · Service brakes · Unknown or other
Bought a van the next day my breaks were metal on metal. I found out it was flooded. The second day the key stuck in the ignition, the middle seats got stuck and will not fold up. The dealer said their mechanic went all over the van and said it was in good condition. The calipers are in very bad shape. He said they need replaced soon.*dt*jb
- Steering
TL* the contact owns a 2006 KIA sedona. The contact stated that while making a turn, a popping noise occurred coming from the rack and pinion steering. No warning light was illuminated. The vehicle was taken to an independent mechanic and was diagnosed that the rack & pinion steering needed to be…
TL* the contact owns a 2006 KIA sedona. The contact stated that while making a turn, a popping noise occurred coming from the rack and pinion steering. No warning light was illuminated. The vehicle was taken to an independent mechanic and was diagnosed that the rack & pinion steering needed to be replaced. The vehicle was repaired with a new rack & pinion however, the failure recurred. The technician informed the contact that there was a problem with the rack and pinion. The technician informed the contact that a KIA dealer rack & pinion was tested and failed, and was unable to correct the failure. The contact mentioned that six months ago, when the vehicle was purchased, the rack and pinion was replaced. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 112,000. The vin was not available.
- Steering
Power steering pump has had to be replaced 4 times in past 4 years. Needs replacement about every year bit last 2 were 6 minths apart. Something IS causing friction and ruining pumps. Makes fluid instantly pour out and car IS uncontrollable. So dangerous
- Air bags · Electrical system · Service brakes
Wcs error . Airbag system issue .KIA recalled 2015 but doesnt bother on earlier cars.sometimes car doesnt start many have this issues it has to do with immobilizer wires .and brakes with rotors are bad every 2 years breaks and rotors get killed .my car has only 56856 mls
- Power train
Van has just over 115xxx miles on it. have noticed that transmission has a whip or slip feel when you take foot off gas pedal and then reapply foot to gas pedal. took to my mechanic and he stated that transmission IS showing wear. wanted to report due to potential recall in the future.
- Unknown or other
Paint issues with vehicle. paint clear coat peels off. noticed on many KIA sedonas sand just had to have van repainted due to clear coat issue.
- Suspension
Passenger side rr control arm rusted through which caused it to bend and caused rr tire to fold inward. had to replace rr control arm, rr coil spring and shocks on both sides which was affected by rusted control arm. I brought it in to repair shop when I noticed a loud thump when going over a bump. this should be a recall.
- Suspension
Left rear lower control arm had rusted and broke while backing up in a parking lot.
- Electrical system · Engine · Service brakes
I went to the dealer KIA orisman on june 22 in the morning. You will inform me that you have to make an order for part. I called after a week and the part had not arrived. It's been two weeks and you still won't call me. I want to sell my car and I can't.
- Electrical system · Service brakes, hydraulic
TL* the contact owns a 2006 KIA sedona. The contact received notification of nhtsa campaign number: 20v088000 (electrical system, service brakes, hydraulic). The contact stated while driving 40 mph, the parking brake warning light was illuminated with an abnormal sound. The contact stated that the…
TL* the contact owns a 2006 KIA sedona. The contact received notification of nhtsa campaign number: 20v088000 (electrical system, service brakes, hydraulic). The contact stated while driving 40 mph, the parking brake warning light was illuminated with an abnormal sound. The contact stated that the steering wheel was difficult to turn. The contact stated that the vehicle was driven to the residence. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had not been informed of failure. The failure mileage was 143,194.
- Electrical system · Service brakes, hydraulic
TL* the contact owns a 2006 KIA sedona. The contact received notification of nhtsa campaign number: 20v088000 (electrical system, service brakes, hydraulic) however, the part to do the recall repair was unavailable. the contact called brewbaker KIA (222 eastern blvd, montgomery, al 36117, (334)…
TL* the contact owns a 2006 KIA sedona. The contact received notification of nhtsa campaign number: 20v088000 (electrical system, service brakes, hydraulic) however, the part to do the recall repair was unavailable. the contact called brewbaker KIA (222 eastern blvd, montgomery, al 36117, (334) 271-4111) where it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. the manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10201529TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
- 10195109Tsb_bod051_closed: technical service bulletin closed
- 10183431TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device
- 10177599These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10177598These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.
- 10174520TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures.
- 10133170PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
- 10116109TSB: FRONT DOOR GLASS RUN CHANNEL REPLACEMENT - This bulletin provides information on some Sedona (VQ) vehicles, produced from June 15, 2005 through May 06, 2013, which may experience wind noise coming from the front door window/door frame area, at highway speeds, and/or glass run channel deformation caused by improper sealing of the front windows. To correct this concern, follow the procedure outlined in this bulletin to replace the left and right side front door glass run channels.
- 10109812TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.
- 10109777TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
- 10109735TSB: COMBINED TSB/SERVICE ACTION: FRONT DOOR GLASS RUN CHANNEL REPLACEMENT (SA167) - This bulletin provides information on some Sedona (VQ) vehicles, produced from June 15, 2005 through May 06, 2013, which may experience wind noise coming from the front door window/door frame area, at highway speeds, and/or glass run channel deformation caused by improper sealing of the front windows.
- 10109710TSB: FRONT DOOR GLASS RUN CHANNEL REPLACEMENT -This bulletin provides information on some Sedona (VQ) vehicles, produced from June 15, 2005 to May 06, 2013, which may experience wind noise coming from the sides of the windshield, at highway speeds, and/or glass run channel deformation caused by improper sealing of the front windows.
- 10109669PITSTOP: SECOND ROW SEAT RELEASE MECHANISM INOPERATIVE - When diagnosing a concern relating to a difficult to release or inoperative second row seat tumble feature, review this Article for instructions.
- 10091489Tsb: automatic transmission fluid application guide - this bulletin provides information relating to the correct automatic transmission fluids that are required for each KIA model. Refer to the shop manual on kgis for the specific KIA model, then reference the automatic transaxle system/ repair procedures/ inspection and adjustment section for the correct atf check/fill procedures.
- 10090945Pitstop: hvac receiver/dryer - desiccant replacement - in the event of a hvac system concern in which metal particles or shards have contaminated the system, the desiccant or the entire a/c receiver/dryer assembly may need to be replaced. This IS due to the fact that it may be impossible to remove all metal contaminants from the receiver/dryer during the a/c flushing procedure. Refer to the included table for detailed information on component replacement by model. If you suspect a plugged expansion valve, the inlet screens can be cleaned. If the valve IS not equipped with an inlet screen and IS restricted, the expansion valve may also need to be replaced.
- 10090713Tsb: windshield washer pump inlet filter replacement - this bulletin provides information relating to possible foreign debris accumulation on the windshield washer pump inlet filter. Over time, some KIA vehicles may exhibit a limited application of windshield washer fluid when the washer function IS used. Limited application of windshield washer fluid can be caused by foreign debris on the washer pump inlet filter. To correct this condition, replace the washer pump inlet filter and perform the windshield washer reservoir flushing procedure outlined in this tsb.
- 10090609Pitstop: audible tone from back-up assist always on - if you encounter a customer complaint relating to the audible tone from the back-up assist feature remaining on at all times, inspect the sensors in the rear bumper for possible collision damage causing a short in the sensor. Also, make sure to check the harnesses feeding the sensors for continuity to ground.
- 10072333Summary to be provided on a future date.
- 10060135Summary to be provided on a future date.
- 10055487Application of preventative anti corrosion material rear lower control arm and suspension. 06/03/2014*Lj
- 10055432KIA: on some vehicles, to prevent corrosion on suspension cross member and rear lower control arm, procedure information provided on application of anti corrosion material. Model 2006-2012 sedona.
- 10055372KIA: procedure information regarding the front heater pipe assembly needing replacing due possible corrosion forming on heater pipe, preventing heater pipe to fail and not operate correctly. Model 2006-2010 sedona.
- 10055339KIA: revised procedure on applying additional anti corrosion material to suspension cross member and rear lower control arms, on some vehicles. Model 2006-2012 sedona.
- 10044140KIA: front coil spring replacement. Owners of some vehicles currently registered in the 21 states which are known to use heavy amounts of road salt are being notified to schedule an appointment with the nearest KIA dealer to have both front springs replaced with improved ones.
- 10037416KIA: the sliding door latches can stick from debris if improperly maintained.
- 10034637KIA: provides information related to the ecm software upgrade of some vehicles with 3.8L and 2.7L engines which may experience a malfunction indicator lamp illuminated with the pcm (powertrain control module) system related dtc(s).
- 10033972KIA: rear coil spring lower tube replacement. Some vehicles may exhibit noise from rear suspension coil springs when traveling on a rough road or when cornering.
- 10033464KIA: ecm upgrade with tp sensor replacement-mil on with dtc p2135/p0638. Information related to ecm software and tp sensor upgrade on some vehicles with 2.7L engines which may experience a malfunction indicator lamp (mil) illuminated with the electronic throttle control (etc) system related dtc p2135 or p0638 or p2a00 or p2a03.
- 10031947KIA: power sliding door remoe controller motor replacement. On some vehicles, a power sliding door (psd) may not open when using an overhead console switch, b pillar switch or remote control button.
- 10030292KIA: on some vehicles with 2.7L engines, the ecm software and tp sensor upgrade may experience a malfunction indicator lamp (mil) illuminated with the electronic throttle control (etc) system related dtc p2135 or p0638 or p2a00 or p2a03.
- 10027725KIA: power sliding door (psd) control module replacement. The power sliding door (psd) may exhibit a condition where a psd reopens approx. 6 inches from the latch area while closing. Some models 2006 & 2007 updated 5/22/09.
- 10026726KIA: all models. Article provides information relating to the improved durability of bulb life for rear combination bulb; rear stop lamp/tail lamp bulb utilized on multiple KIA models.
- 10025151Some customers of 2006-2007 sedona (vq), 2007 amanti (gh), or 2007 sorento (bl) may experience a concern of a check engine light (mil) being on. 02 sensor (HO2S) codes.
- 10023620Sedona (vq) abs/esc warning lamp on - poor grounds.
- 10022961Sedona (vq) intermittent no-crank condition.
- 10021664Lambda engine noises.
- 10021561Automatic transmission adaptive value reset/relearn.
- 10020652Sliding door cables replacement. Consumer may complain that the driver and passenger side sliding door handles are sticking and not returning to there proper positions.
- 10020651Power sliding doors with switch. Consumers may complain of the button sticking while depressed in higher temperatures.
- 10020650Power tailgate (ptg) pinch strip replacement.
Every KIA Sedona model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.